Professional Documents
Culture Documents
1、 Set the DIP switch on NCP board to all ON state (Download state).The DIP
switch is “S3”.
Instead you can push B-off button for 3 sec to go to download state.
2、 Connect the EMS with the Qx interface of the SMB board, and confirm the
Ethernet cable connection between the EMS computer and NCP board is
correct.
3、 Set the IP address and subnet mask of the EMS computer according to the
following rules:
6、 Input the command” d-erase -d1” under the prompt Z T E + > to erase the
database
本文所有信息为中兴通讯股份有限公司内部信息,未经允许,不得外传 第 1 页,共 2 页
内部公开▲
Figure 1
9、prompt “Do you want to save new network configuration? This will take you a
few minutes,are you sure?Yes[Y]/No[N]”,input “y”, as shown in Figure 1
11、Wait for the NCP card reboot, after it has been finished, pull out the NCP card. Set the DIP
switch on NCP board not all ON state and also not all OFF state .The DIP switch is “S3”. Then
insert the NCP card.
12、Set the IP address of EMS computer to be within the same network section as
the NE IP address. In the EMS client operation window, select the NE, and click
System →NCP data Management →DB Download to download all the
databases via the EMS software.
本文所有信息为中兴通讯股份有限公司内部信息,未经允许,不得外传 第 2 页,共 2 页