Professional Documents
Culture Documents
A. folding
B. collapsible
C. fixed
c
A. retaining wall M
B. breast wall
C. parapet wall
D. buttress
Answer: B
53. The term pitch in connection with pitched roofs is defined as the
Answer: B
D. none of these
Answer: C
A. bitumen
o m
B. paraffin wax
.c
te
C. cement solution
a
D. cement concrete
q M
Answer: A
c
M
56. In brick masonry, for good bonding
Answer: C
57. H-piles
Answer: D
Answer: B
q
c
C. perpendicular distance between the intrados and extrados
M
D. horizontal distance between the supports
Answer: D
D. all of these
Answer: D
Answer: B
A. In English bond, vertical joints in the header courses come over each other and vertical joints in
the stretcher courses are also in the same line.
B. In English bond, the heading course should start with a queen closer.
.c
D. In Flemish bond, every alternate course starts with a header at the corner.
te
Answer: B
a
q M
63. A raking shore is a system of
c
M
A. giving temporary lateral support to an unsafe wall
B. providing temporary support to the party walls of two buildings where the intermediate building
is to be pulled down and rebuilt
C. providing vertical support to walls and roofs, floors etc. when the lower part of a wall has to be
removed for the purpose of providing an opening in the wall
Answer: A
64. The window which projects outward from the walls of a room to
provide an increased area of opening for admitting greater light and
ventilation, is called
A. dormer window
B. corner window
C. bay window
D. clerestorey window
Answer: C
A. skew back
B. intrados
C. extrados
D. keystone
Answer: D
o m
.c
66. The surface of the abutment on which the arch rests, is known as
te
A. span a
B. keystone
q M
c
C. skew back
D. crown
M
Answer: C
67. The nogging pieces are housed in the studs at a vertical distance of
about
A. 100 to 200 mm
B. 200 to 400 mm
C. 400 to 600 mm
D. 600 to 900 mm
Answer: D
68. When the depth of water is from 4.5 to 6 m, the type of coefferdam
used is
A. earthen cofferdam
B. rockfill cofferdam
C. single-walled cofferdam
Answer: C
69. A block of stone or concrete provided under the end of tie beam to
spread the load from the roof over a large area of bearing, is called
A. gable
B. hip
C. verge
o m
D. template
.c
Answer: D
te
a
q M
70. A ridge formed by the intersection of two sloped surfaces having an
c
exterior angle greater than 180?, is called
A. gable
M
B. hip
C. verge
D. template
Answer: B
A. underpinning
B. scaffolding
C. shoring
D. jacking
Answer: A
C. centre of gravity of the column loads must coincide with the centre of gravity of the footing
Answer: C
73. The vertical distance between the wall plate and top of the ridge is
called
o m
A. rise
.c
B. pitch
te
a
C. template
q M
D. gable
c
Answer: A
M
74. The dampness in a building is due to
A. ground moisture
B. rain water
C. defective construction
D. all of these
Answer: D
75. When the pile is driven by means of water jets, water is forced through
the jet pipe under a pressure of
Answer: C
For Discussion / Reporting / Correction of any MCQ please visit discussion page by clicking on
'answer' of respective MCQ.
PlayStore
o m
.c
te
a
q M
c
M