Professional Documents
Culture Documents
Nanofiltration NF Systems
The fundamental principle of Nanofiltration membrane's technology is the use of pressure to
separate soluble ions from water through a semi permeable membrane. The membrane,
operates under a different hydraulic profile which is also known cross flow filtration, unlike a
dead end filter.
Most Nanofiltration membranes are composite materials supported by polymer substrate and
manufactured in a spiral design as opposed to a flat sheet or tube geometry. The predominant
model used today for industrial applications is the spiral configuration. To ascertain further
understanding of nanofiltration systems, you will need to be aware of the following
information.
Like RO, and unlike UF, Nanofiltration Systems will recover a percentage of the feed water.
Most all NF membranes are of a spiral wound configuration.
call+1 (714)
Daily432-9996
Capacity Range:
Membrane Diameter: 4" search
call+1 (714)432-9996
13,000 to 32,000 GPD
Operating Pressure: up to 300 PSI
(50 to 121 M³/day)
call+1 (844)309-7501
REVERSE OSMOSIS & WATER TREATMENT SYSTEMS
Microprocessor Control Panel person
email
SALES@PUREAQUA.COM
Pure Aqua has over 20 years of experience as a global supplier of industrial and commercial
nanofiltration systems for the removal of unwanted impurities from water. Our NF systems
ensure the production of clean and potable water for any type of application in the water
treatment industry. Check out our selection of nanofiltration systems for commercial
establishments and industrial plants to meet your water treatment needs.
Nanofiltration (NF), in water treatment, “bridges” a gap between ultrafiltration and reverse
osmosis membranes. It is sometimes referred to as a loose or lower rejecting RO membrane. It
could also be called a tight UF, as NF membrane pore size ranges from .01 to a little less than
.001. Generally, an NF membrane system lets more salt pass than an RO membrane. In
addition, an NF membrane element will produce the same quantity of product at 50 to 70%
the applied pressure as an RO water treatment system.
There are applications where a 75% rate of salt rejection is preferable to 95 to 99%, especially
when it is achieved using only half of the energy. Unlike with RO membrane elements, the NF
call+1 (714)of432-9996
offerings the major membrane manufacturers are quite different in performance from search
call+1 (714)432-9996
company to company. With RO membrane elements, any model with less than 99.5% sodium
call+1chloride
REVERSE OSMOSIS & WATER TREATMENT SYSTEMS
rejection, especially with seawater membranes, is considered inferior. In the case of
(844)309-7501 person
email NF, there is a “place” for any membrane with a NaCl rejection rate of 40%, or more.
Nanofiltration has also been called a “softening” membrane as while its salt rejection may be
SALES@PUREAQUA.COM
80% or less, hardness rejection will often remain well over 90%.
Nanofiltration membranes are utilized for the filtration of water with low total dissolved
solids (TDS) for the purposes of eradicating organic substances and softening water.
Nanofiltration is usable in many water and wastewater treatment industries for the practical
removal of ions and organic material. It has also been adopted as pretreatment to RO. Other
than water purification, nanofiltration membranes are also used in the manufacturing
production of food & beverages, and pharmaceuticals.
While nanofiltration and reverse osmosis systems have similar designs and operation uses,
there are some notable differences between the two. The primary distinction is that
nanofiltration is not as rigid as reverse osmosis. It functions with less feed water pressure and
is incapable of removing single charge ions from the water as definitely as reverse osmosis
membranes.
While up to 99% of chlorides and sodium are removed by reverse osmosis systems,
nanofiltration membranes typically remove only 50% to 80%. This percentage relies on the
type of material and manufacturing of the membrane. However, due to its effectiveness in
removing multiple charge ions, nanofiltration is the preferred choice for removing hardness
from water while not affecting the total dissolved solids content than would reverse osmosis.
call+1 (714) 432-9996 COD and color higher value product search
call+1Caustic
(714)432-9996
call+1cleaning
Caustic
(844)309-7501
BOD, COD,OSMOSIS & WATER TREATMENT SYSTEMS
REVERSE person
Allows caustic cleaning solution to be
cleaning suspended solids, recycled resulting in reduced cleaning
email solutions solution caustic cleaner chemical costs
SALES@PUREAQUA.COM
Recycle of BOD, COD, calcium, Allows acid solution to be recycled
Acid
acid suspended solids, resulting in reduced cleaning chemical
solution
solutions acidic water costs
Desalted,
Salty waste NF produces high value pharmaceutical
Antibiotics concentrated
product products
Antibiotics
Category Filter
keyboard_arrow_down
LIST GRID
Email address
SUBSCRIBE
STAY CONNECTED
Instagram
Facebook linkedin Twitter Youtube
Pinterest
EXPLORE +
INFORMATION +
FIND +
Industrial & Commercial Water Filters and Purifiers in Africa, Asia, Europe, North America, South
America, Australia | Made in USA by Pure Aqua, Inc., an ISO9001:2015 Certified Company
© Pure Aqua, Inc. All Rights Reserved | 2230 S Huron Dr, Santa Ana, CA 92704 | +1 (714) 432-9996 |
sales@pureaqua.com
https://pureaqua.com/nanofiltration-nf-systems/ 5/5