Professional Documents
Culture Documents
Micro Project ETI 2
Micro Project ETI 2
MONITORING SYSTEM
(1.1)Need of IOT based weather monitoring system
data to the cloud service. The Blynk app is used to monitor data
from the cloud service, so the real-time data can be accessed from
any smart phone supported by android or IOS.
(1.2)Hardware requirements
(1.2)Hardware requirements
Fig1: prototype of particle of photon and blynk based IOT based weather monitoring system
Components Required –
fi
fi
fi
Fig: Table listing pin con guration of particle photon
It should be noted that 3V3 is a filtered output used for analog
sensors. This pin is the output of the on-board regulator and is
internally connected to the VDD of the Wi-Fi module. When
powering the Photon via VIN or the USB port, this pin will output
a voltage of 3.3 V DC. This pin can also be used to power the
Photon directly (max input 3.3 V DC). When used as an output,
the max load on 3V3 is 100 mA. The PWM signals have a
resolution of 8-bit and run on a frequency of 500 Hz. In the circuit,
6 GPIO pins of the module are used to interface the character
LCD and one pin is used to interface the DHT-11 temperature and
humidity sensor.
16X2 LCD: The 16X2 LCD display is used to display the values of
the measured temperature and humidity. It is connected to the
Particle Photon by connecting its data pins D7 to D4 to the pins
D0 to D3 of the Particle board. The E and RS pins of the LCD are
connected to pins D5 and D6 of the Particle board respectively.
The RW pin of the LCD is grounded.
Features