Professional Documents
Culture Documents
ELECTRICAL COMPONENT LOCATOR 1993 ELECTRICAL COMPONENT LOCATION Isuzu Electrical Components
CONTROL UNITS
CONTROL UNITS LOCATION
Component Location
ABS Control Unit Under passenger front seat.
Engine Control Module (ECM)
2.3L Overhead View of Engine Compartment Behind left kick panel. See
Fig. 3 .
View of ECM Behind left kick panel. See
Fig. 4 .
View of Engine Compartment (2.6L) Behind left kick panel. See
Fig. 5 .
Ignition Control Module (2.3L) In distributor.
Shift Lock Control Unit Under center console, at base
of gear selector.
MOTORS
MOTORS LOCATION
Component Location
A/C-Heater Blower Motor Under right side of dash, on A/C-heater blower motor
housing.
Fuel Pump Inside fuel tank.
Windshield Washer Motor On bottom of windshield washer reservoir.
Windshield Wiper Motor On right side of firewall.
EGR
2.3L On right front inner fender panel.
2.6L On top rear center of engine, on
valve cover. See Fig. 5 .
Ignition (2.3L) On right side of engine compartment,
on inner fender panel. See Fig. 3 .
Fuel Pressure Regulator On right fender panel, near fuel vapor
canister. See Fig. 5 .
MAP Sensor On right side of engine compartment,
on inner fender panel. See Fig. 3 .
Vent Switch Solenoid (2.3L) On front top of carburetor.
SWITCHES
SWITCHES LOCATION
Component Location
ABS Combination Valve Pressure Differential Switch In left rear of engine compartment, in
proportioning valve.
Accelerator Switch (2.3L) On top of accelerator pedal.
A/C Dual-Pressure Switch On receiver-drier, in left front corner
of engine compartment.
Back-Up Light Switch
A/T On right side of transmission.
M/T On left side of transmission.
Brakelight Switch On bracket, above brake pedal.
Clutch Interrupt Switch (M/T) On bracket, above clutch pedal.
Clutch Start Switch (M/T) On bracket, above clutch pedal.
Idle Vacuum Switch On right front inner fender panel. See
Fig. 3 .
Ignition Key Switch Integral of ignition assembly.
Park/Neutral Position Switch (A/T) On right side of transmission.
Oil Pressure Switch (2.3L & 2.6L) On lower right rear of engine, above
oil pan.
Parking Brake Switch On base of parking brake lever.
Power Switch (2.6L) On right side of engine, at valve
cover. See Fig. 6 .
Seat Belt Warning Switch On driver's seat belt buckle.
Wide Open Throttle Switch (2.6L) On throttle linkage. See Fig. 6 .
4WD Indicator Switch On right side of transmission.
MISCELLANEOUS
MISCELLANEOUS LOCATION
Component Location
A/C Electronic Thermostat Behind right side of dash, on evaporator.
A/C-Heater Blower Motor Resistors On top of A/C-heater blower motor
housing.
Diagnostic/Test Connectors
ABS Behind left kick panel.
Data Link Connector (DLC) (View of ALDL Connector) Behind left kick panel. See Fig. 4 .
Mixture Dwell Test Lead (2.3L) Taped to harness, on right rear corner
of engine compartment.
Tachometer (2.6L) On right side of engine compartment,
behind fuse/relay block.
Trouble Code Test Terminals (2) Behind left kick panel. See Fig. 4 .
Diode Boxes
"A" - 2.6L In fuse/relay block, on right side of
engine compartment. See Fig. 1 .
"B" - 2.6L In fuse/relay block, on right side of
engine compartment. See Fig. 1 .
"C" - 2.6L Taped to harness, behind left side of
dash.
"D" Taped to harness, behind left side of
dash.
EFE Heater (2.3L) On top of intake manifold, below
carburetor.
Radio Noise Suppressor
2.3L On right side of engine, on intake
manifold.
2.6L On top center of engine, on valve
cover.
NOTE: Figures may show multiple component locations. Refer to appropriate table for
proper figure references.