Professional Documents
Culture Documents
Compiled by
Submitted by
1 Introduction
8 Rainfall Month-wise
10 Details of Royalty or Revenue collected from Major Minerals and Minor Minerals in last three years
16 Use of Mineral
Impact on the Environment (air, water, noise, soil, flora & fauna, land use, agriculture, forest etc)
21
due to mining activity
Reclamation of mined out area (best practice already implemented in the District, requirement as
23
per rules and regulation, proposed reclamation plan)
26 Plantation and green belt development in respect of leases already granted in the District
27 Other information
Conclusion
PREFACE
The MOEF &CC came out with Environmental Impact Assessment Notification S.O.-
1533(E) dated 14th Sept, 2006. It has been made mandatory to obtain environmental clearance
for different kinds of development projects as listed in Scheduled -1 of notification. Accordingly
the State Govt. Vide Notification No.FOR.29/2019/1, Dated Shillong the 9th July, 2019
constituted the State Level Committee and District Level Task Force thereafter vide Order
No.FOR.29/2019/6, Dated Shillong the 19th July, 2019 notified the Nodal Officer for the
purpose of preparation of District Survey Report for Sand mining or river bed mining and for
other minor minerals.
Further, in pursuance of the order of Hon’ble Supreme Court Petition (C) No. 19628-19629
of 2009, dated 27th Feb, 2012 in the matter of Deepak Kumar etc., Vs State of Haryana and
others etc., prior environmental clearance has now become mandatory for Mining of Minor
Minerals irrespective of the area of Mining Lease.
In pursuance MOEF&CC Notification S.O. 141(E) dated 15th Jan, 2016, District
Environment Impact Assessment Authority (DEIAA) & District level Expert Appraisal
Committee (DEAC) has been formed for Category –B2 Minor Minerals having area less than or
equal to 5 ha.
Under 7(iii) (a) it was also suggested to prepare the district survey report for sand mining or
river bed mining and mining of other mineral as prescribed in Appendix X. This has been
modified vide S.O. No. - 3611(E) dated 25th July, 2018.
SEAC will scrutinize and recommend the prior environmental clearance of Mining of Minor
Mineral on basis of District Survey report. This will be a model and guiding document which is
a compendium of available mineral resources, geographical setup, environmental and
ecological set up of the district and replenishment of minerals and is based on data of various
departments, published reports, Journal and websites. The District Survey report will form the
basis for application for environmental clearance, preparation of reports and appraisal of
projects. District Survey Reports are to be reviewed once in every five years as per statue,
however the data bank of DSR can be updated, if required.
The Main objective of the preparation of District Survey Report is to ensure the following:-
1. Identification of river sand mining areas with geo references.
2. Identification of potential area of river silt with geo reference, which is being used
for filling purposes.
3. Identification of other minor minerals with geo reference.
4. Identification of other mineral resources if available.
CHAPTER-1
INTRODUCTION
1.1 ABOUT DISTRICT
The West Khasi Hills District was carved out of the East Khasi Hills District on 28th October
1976. The district is situated between 25010’ and 25051’ Latitude and 90044’ and 91049’ Longitude.
It is bounded on the north-west by Kamrup District of Assam, north-east by Ri-Bhoi District. On the
east by East Khasi Hills District and on the south by South West Khasi Hills District, on the west by
East Garo Hills District and South Garo Hills District. It have an area of 3911.22 km2 and population
of 2,87,781 (2011 census) and density of 73.58% and literacy rate of 78.83%. Nongstoin is the
District Headquarter and is divided into four C & RD Blocks viz Mairang, Mawshynrut,
Mawthadraishan and Nongstoin and has two Sub-Divisions viz Mairang and Mawshynrut.
West Khasi Hills District
The CLIMATE of the district is mildly tropical in the northern and southern foothills, while in
the central upland zone, the climate is temperate and places at medium altitude in the northern,
western and southern parts of the district experience sub-tropical climate. The district is influenced
by the South-West monsoon and rainfall is assured during summer, but differs greatly in intensity
from area to area within the district. The average rainfall ranges from 1200 mm to 3000 mm per
annum.
The district comprises of eight SYIEMSHIP viz Nongstoin, Nongkhlaw, Maharam, Myriaw,
Rambrai, Mawiang, Langrin, Noboshphoh together with the three SIRDARSHIPS of Jyrngam,
Riangsih and Nonglang.
CHAPTER-2
Overview of Mining activity in the District
There has been no approved mining lease or quarry permit in the District and hence no
mining lease or quarry permit has been granted so far. However the minerals deposit in the District
are presented in the table below:
The West Khasi Hills District was carved out of the East Khasi Hills District on 28th October
1976. The district is situated between 25010’ and 25051’ Latitude and 90044’ and 91049’ Longitude.
It is bounded on the north-west by Kamrup District of Assam, north-east by Ri-Bhoi District. On the
east by East Khasi Hills District and on the south by South West Khasi Hills District, on the west by
East Garo Hills District and South Garo Hills District. It have an area of 3911.22 km2 and population
of 2,87,781 (2011 census) and density of 73.58% and literacy rate of 78.83%. Nongstoin is the
District Headquarter and is divided into four C & RD Blocks viz Mairang, Mawshynrut,
Mawthadraishan and Nongstoin and has two Sub-Divisions viz Mairang and Mawshynrut.
The CLIMATE of the district is mildly tropical in the northern and southern foothills, while in
the central upland zone, the climate is temperate and places at medium altitude in the northern,
western and southern parts of the district experience sub-tropical climate. The district is influenced
by the South-West monsoon and rainfall is assured during summer, but differs greatly in intensity
from area to area within the district. The average rainfall ranges from 1200 mm to 3000 mm per
annum.
The Climate of the district varies in latitudinal and longitudinal directions and is influenced
mainly by physiography. There are four seasons in the district namely summer, monsoon or rainy,
autumn and winter. The summer season extends from the end of March to mid May, which is
characterized by relatively high temperature, occasional thunderstorm with high wind velocities. The
rainy season commences with the onset of southwest monsoon in April and lasts up to October.
This is followed by short autumn from mid October to November. This season indicates the slow
retreating of monsoon with clear and sunny sky. The winter season extends from December to the
end of March. This is the coldest season of the year with sharp decline in the temperature. During
winter, some high altitude areas of the state experiences very cold nights. Winter is basically dry
with lower diurnal range of temperature.
In general, the district has a mildly tropical climate in the northern and southern foothills,
whereas central upland portion experiences temperate climate and the places of medium altitude of
the northern, southern and western parts of the district experience sub-tropical climate.
The district receives a fairly high rainfall throughout the year. Most of the precipitation occurs
during the rainy season i.e. between April and October due to SW monsoon. The average rainfall in
some of the selected stations of the district is presented in Table
Average Rainfall (mm) of Selected Stations in West Khasi Hills
CHAPTER-4
The Geology of West Khasi Hills is characterized by the presence of wide variety of rock
types that originated in various epochs of the earth's evolution. The older metamorphic comprising of
banded magnetite quartzite (BMQ), quartzite, schists, and amphibolites constitute the basement
rocks and belongs to Proterzoic in age. The other group of rocks exposed under Assam Meghalaya
Gneissic Complex (AMGC) is a combination of classified and unclassified metamorphic rocks. The
AMGC is unconformably overlain by Shillong Group of rocks of Proterozoic age comprising of
rhythmic sequence of conglomerate, quartzite, shale phyllites quartzite, phyllites and quartz sericite
schist. Khasi Greenstone of Proterozoic age is represented here bt meta diorite, epidiorite,
ambhibolite, norite and basic megaxenolith.
Pink-grey porphyritic granite or non-porphyritic granitoid belonging to the Mylliemgranitoid
occurs in the south western part of West Khasi Hills. The Nongpohgranitoid occurs in the central and
northern part of the districts and they are represented by granodiorite- diorite, grey- pink porphritic
granite, coarse grained pink-gery granite and quartz vein/reef. South khasi batholith is represented
by porphyritic granite, coarse grained pink granite and pegmatite veins.
The Mahadekfromation is represented by gritty sandstone alternating with conglomerate
which is overlain by felsphatic sandstone, conglomerate and clay overlain by glauconitic sandstone.
The Mahadek formation occurs in the southern and south western part of the district. The Jaintia
group of rocks is represented by the members of Sylhet limestone, Sylhet sandstone, Tura limestone
and Siju-Prang limestone. The Jaintia group is overlain by older alluvium of Pleistocene to Holocene
age represented by Chaparfromation and Sarbhog formation. The Chapar formation is represented
by highly oxidized dark brown to red brown loamy sand and the Sarbhog formation is represented by
oxidized to feebly oxidized sand, silt and clay.
MINERAL RESERVES/RESOURCES AND POTENTIAL OCCURRENCES
Sillimanite and corundum are the main economic mineral occurring in Sonapahar and north
of Nanku. The famous Sonapahar- Nongdom-Langtor, Riangdo, Sillimanite-corundum deposit in
West Khasi hills, is the singular occurrence in India, from which superior grade sillimanite and
corundum are being exploited. The massive lensoid bodies of sillimanite-corundum are contained
mostly in quartz-sillimanite schist and in a few cases in biotite-sillimanite-quartz schist. The reserve
estimate of sillimanite as per Indian Mineral Year Book, 2000 is 55807 tonnes.
Lateritic bauxite was identified around Rambrai area, northwestern and northeastern parts
of Maupatshiyar village of West Khasi Hills District, Meghalaya. All the lateritic bauxite bodies were
developed over granite gneiss, norite/metanorite and sheared amphibolites. The thickness of the
complete profile of lateritic bauxite is about 8-10 m. Lateritic bauxite were also identified around
Umsung, Nongjyellieh, Lawse, Nongyllieh and Mawdub areas. The host rock is granite gneiss with
patchy charnockite of Assam-Meghalaya Gneissic Complex. The thickness of the bauxite is about
3m. Mainly four varieties of bauxite ore viz. pisolitic, bouldery, massive and clayey (friable) are
present in the area. A total of 1.58 MT of bauxite have been estimated in Rambrai area.
Occurrence of Banded Ferruginous Quartzite was reported in West Khasi Hills. Titanium
vanadiferous, magnetite body associated with gabbroic body 5 km east of Rambrai was also
reported. Minor bands were also recorded from Rangsapara, Nongkyndong, Um Kiang and
Nongianglang. The ferruginous bands occur with quartzite and are a few millimetres thick.
Ferruginous layers comprise of flaky hematite with little magnetite. Many thin bands were also
observed around Sildubi, Aradonga and Bansapani areas of south of Hahim in West Khasi Hills
district.
The limestone band around Barsora area belongs to Shella formation. The limestone is
highly fossiliferous, hard, massive, jointed and fractured. The physical and chemical properties
suggest that this can be used in chemical and cement industry.
Coal occurrences are mainly confined to the tertiary sediments of West Khasi hills. Langarin
coalfield is located in southern part of West Khasi hills and it forms the largest coalfield of
Meghalaya. The coal occurs around Barsora and Maheshkhola village. Exploration for coal by GSI in
Nongjri-Kulang area, Nonghyllum plateau, has proved coal in Langrin coal field. The resource
estimated in Langrin coal field is 133.16 MT.
Deposits of multicoloured granite have been located around Sonapahar (Mawthaliang block)
and Maroid,Thangmaw, Lawar and Old Nongstoin in West Khasi Hills district. In Mawthaliang block,
West Khasi Hills district, the granite is occurring as bouldery outcrops and in Maroid and Thangmaw
areas the granites occur as rectangular to ellipsoidal detached boulders. The granite may yield good
dimension stone and the gneisses are used as road and building materials.
CHAPTER-5
Drainage of Irrigation Pattern
Topographical features of West Khasi Hills District include a significant hill range that is the
Mawthadraishan range, which runs from east to west.River systems also form a part of the
geography of West Khasi Hills District. There are two important river systems in the district, the
Kynshi and the Khri, with a number of tributaries. Kynshi is the bigger one and it rises in the southern
slopes of Marpna Peak near Mawmaram village (about 10 kms from Mairang on the way to Shillong).
It follows a westerly course for a considerable distance then takes a sharp bend to the east and
enters the plains of Bangladesh at Ranikor. The Khri River rises near Kyllang rock and flows
northwards and is joined by Khri Synnia River before it enters the plains of Assam.
Other important rivers that constitute the drainage system of West Khasi Hills District are
Umngi, Wahblei, Riangdo, Tyrsung, Ryndi Umrambrai, Umit and Rwiang,
CHAPTER-6
Land Utilization Pattern
3 Forests (Classed 31900 31900 36772 36772 51850 51850 14489 14489 135011 135011
and uncalssed
forest)
4 Area not
available for
cultivation
(i) Area under
non-agricultural
uses
(a) Water logged 0 0 0 0 0 0 0 0 0 0
land
(b) Social Forestry 5076 5076 2544 2544 3938 3938 2181 2181 13739 13739
(c) Land under still 1254 1254 571 571 692 692 761 761 3278 3278
water
(d) Other land 4060 4098.5 609 633.5 847 1443 102 104 5618 6279
Total (a + b + c + 10390 10428.5 3724 3724.5 5477 6073 3044 3046 22635 23296
d)
(ii) Barren 6590 6590 5156 5156 44370 44370 2960 2690 59076 59076
&unculturable
land
(Total of (i) + 16980 16980 8880 8880 49847 49847 6004 6004 81711 82372
(ii)
5 Other
uncultivated
lands
(a) Permanent
pasture and other
grazing lands
(b) Land under
miscellaneous
tree crops and
grooves etc.
(c) Cultivable waste 17000 17000 13690 13690 24499 24499 12390 12390 67579 67579
lands
Total (a + b + c) 24608 24608 23136 23136 38314 38314 16505 16482 102563 102540
6 Fallow lands
(a) Fallow lands 8553 8553 7606 7606 11772 11772 4624 4624 32555 32555
other than
current fallows
(b) Current fallows 2200 2200 3801 3801 3720 3720 2251 2251 11972 11972
Total (a + b) 10753 10753 11407 11407 15492 15492 6875 6875 44527 44527
7 Net areas sown 1321 1282.5 4873 4845.5 3827 3231 1920 1941 11939 11939
8 Area sown 940 940 2525 2525 1420 1420 1100 1100 5985 5985
more than once
9 Total crooped 2261 2222.5 7398 7373.5 5247 4651 3020 3041 17924 17288 Area
area figure
shown in
Appendix
NB:If the Block-wise area is not available , then the report can be prepared for the whole district fort he time
being (as the district wise area is available)
Area of broom stick cultivation in this report is shown under Land Misc. Etc. and no. Longer shown under
Total Cropped Area
Social forestry considered for forest taken under Old Plantation, JFMC and 12thFinance Commission.
Forest:
Table Showing Forest covers in West Khasi Hills District as per the
(area in sq km)
State of Forest Report 2017
1 31 NA NA NA Nil
CHAPTER-7
Surface Water and Ground Water scenario of the District
So far no hydrological model for computing surface water resources based on catchment
characteristics have been developed for this zone. In such a scenario of inadequate data for
preliminary planning, effort have been made for computing run- off of particular dependability i.e 75%
by run-off factor approach using the rainfall data of Nongtoin. For this study the average value of
rainfall data collected at the nearest station Nongstoin by Agriculture Department Government of
Meghalaya for the period from 2002-2013 has been adopted. The surface water available
considering 75% dependability in respect of West Khasi Hills District is 3400 MCM approximately. In
the district there are no major or medium irrigation projects, hence the agricultural development in
the area is dependent on minor irrigation schemes. The existing irrigation schemes are based only
on surface water and the source is mainly through non-monsoon base flow. The total command area
is 4972.59ha in the district. Piped water supply schemes and spot source water schemes are the
main source of water supply schemes and play a major role for the water requirement of the people
especially in the rural areas. Piped water supply schemes are categorized into (i) Gravity Feed
Schemes and (ii) River Pumping Schemes. Spot source water supply scheme are classified into (i)
Hand pump, (ii) Spring tapped chamber and (iii) Well (dug, ring) maintained by Public Health
Engineering Department, Meghalaya (PHED).
The availability of water through surface irrigation in the district is 138.5 MCM in which
majorly the availability of water is through minor irrigation and has a share of 124 MCM (89.53%)
while from various water bodies including rain water harvesting is 14.50 MCM (10.47%).
Rainfall: month-wise
CHAPTER-9
From To From To
1 2 3 4 5 6 7 8 9 10
Nil Nil Nil Nil Nil Nil Nil Nil
Nil
Details of Royalty or Revenue collected from Major Minerals and Minor Minerals in last
three years NIl
CHAPTER – 11
Details of Production of Minor Mineral in last three years is not available since there is no
List of letter of intent (LOI) holders in West Khasi Hills District along with its validity
are as follows:
Area
of
Name Location
Sl Name of Address/conta Mining Validit
of LOI Grant order Us of the
N the ct no of LOI lease y of
Miner No & date e Mining
o Lessee holder to be LOI
al Lease
allotte
d
T/WSW/ML/Ston Miangsai
Shri e/ H.Tabah/39 6
4.90 n,
1 Stone Hamerlesr Nongstoin month
Dated ha Nongdom
oy Thabah s
16/01/2019 Rambrai
T/WSW/ML/Ston
Shri. e/ 6
M.Kharbani/217 Rangjada
2 Stone Maniksing Nongstoin 2 ha month
p
Kharbai Dated s
13/11/2019
CHAPTER-14
6 Kaoline 5.24 million White ware Good quality Kaolin (China Clay)
tonnes occurs around Mawphlang, Smit and
Laitlyngkot in the East Khasi Hills
District; Thandlaskein, Shangpung,
Mulieh and Mynsngat in the Jaintia
Hills District; and Darugiri in the East
Garo Hills District.
7 Iron ore - Low grade West khasi hills and East Garo Hills
8 Glass sand 3.00 million Oridanary glass Glass Sand - Glass sand is found to
tones ware occur at Laitryngew, Umstew and
Kreit in the East Khasi Hills and
Tura in the West Garo Hills.
9 Quartz 0.5 million tones Industrial grade Quartz occurs almost in all districts
in the Northern part of the State.
25°49'32.08"N
1 Quartzite Aradonga low grade
91° 9'34.38"E
Occur as
Massive
3 Quartzite Aradonga 25°49'32.08"N
Layered
91° 9'34.38"E
outcrops
Granite is used in
buildings, bridges,
paving,
monuments, and
Major part
many other
of the
Occur as exterior projects.
district is
4 Granite 25°31'16.71"N massive Indoors, polished
covered
91°15'19.48"E outcrops granite slabs and
with
tiles are used in
Granite
countertops, tile
floors, stair treads
and many other
design elements
Occur as
massive
outcrops
Around found in the
Used as Building
5 Amphibolite Nongstoin 25°31'58.42"N low lying
Materials
area 91°11'53.50"E areas below
the Shillong
Group of
rocks
Since the District has not granted any mining lease or quarry permit till date, therefore Mining
Since the District has not granted any mining leases or quarry permit, therefore details of the
area of where there is a cluster of mining leases viz number of mining leases, location (latitude and
Impact on the Environment (air, water, Noise, soil, flora & Fauna, land use, agriculture,
Mining operations impact the environment in several ways. Impact on Environment due to
The largest sources of air pollution in mining operations dust emission in the form of Respirable
Suspended Particulate (RSPM) Matter and Suspended particulate matter (SPM) during excavations,
blasting, loading and unloading, transportation of materials, wind erosion (more frequent in open-pit
mining),fugitive dust from tailings facilities, stockpiles, waste dumps, and haul roads. Another source
of pollution would be emission from trucks/vehicle used for transportation of mineral. These
pollutants can cause serious effects to people’s health and to the environment.
Mining activity affects both surface and subsurface water. Due to mining water bodies can get
contaminated with dust and toxic materials. The drainage system and topography will influence
extent of water pollution. During excavation huge quantity of waste and dust generated which may
flow to water bodies leading to reduced water carriage capacity, floods and reduced light
penetration. Acid mine drainage is considered one of mining most serious threats to water
resources. A mine with acid mine drainage has the potential for long-term devastating impacts on
Noise pollution
Noise pollution associated with mining may include noise from vehicle engines, loading and
unloading of rock into steel dumpers, chutes, power generation, and other sources. Cumulative
impacts of shoveling, ripping, drilling, blasting, transport, crushing, grinding, and stock-piling can
significantly affect wildlife and nearby residents. Vibrations are associated with many types of
equipment used in mining operations, but blasting is considered the major source. Vibration has
affected the stability of infrastructures, buildings, and homes of people living near large-scale open-
pit mining operations. According to a study commissioned by the European Union in 2000: “Shocks
and vibrations as a result of blasting in connection with mining can lead to noise, dust and collapse
of structures in surrounding inhabited areas. The animal life, on which the local population may
Mining activity is one of the major reasons for deforestation, loss of biodiversity, habitat
degradation and habitat fragmentation . Mining activity will require clearing of vegetation leading to
loss of green cover. Dust and noise pollution will create affect wildlife. Mining activity in the wild life
corridor/wildlife habitat will affect animal movement and will lead to man-animal conflict. Mining will
change the topography of the area thereby causing physical disturbances to the landscape, creating
eyesores.
Impact on agriculture
Agricultural yield will be reduced due to obstructions by the dust particles as settled on the
Records of such site plan, duly verified by competent authority shall be maintained. Mining
lease area should be demarcated on the ground with wire fencing to show the boundary of the lease
area on all sides with red flags on every pillar. The Project Proponent shall erect the pillars for
depicting GPS details in the earmarked boundary for the quarry site to monitor centrally.
Mining activities shall be restricted only to ‘non forest area’ of the leased area and shall not
be extended to any other area. No tree felling shall be done, except only with the permission from
A minimum distance of 15 meters from any civil structure shall be kept from the periphery of
Air and Noise pollution shall be checked periodically and to maintain records. Device for
checking Air and Noise Pollution shall be installed at the site as specified by the MSPCB, Shillong in
the plan. The PP shall take appropriate measures to comply with the revised National Ambient Air
Quality (NAAQ) norms notified by MoEF &CC on 16.11.2009 and measures should be taken to
comply with the provisions laid under Noise Pollution (Regulation and Control) (Amendment) Rules,
2010 dated11.01.2010 issued by MoEF & CC to control noise to the prescribed levels.
Catch drains and siltation ponds of appropriate size shall be constructed around the mine
working, mineral and OB dumps to prevent run off or water and flow of sediments directly into the
river and other water bodies. The water so collected should be utilized for watering the mine area,
roads, green belt development etc. the drains shall be regularly desilted and maintained properly.
The dump capacity shall be designed keeping 50 % safety margin over and above peak sudden
rainfall (based on 50 years data) and maximum discharge in the area adjoining the mine site, and it
shall allow adequate retention period for proper setting of the silt material.
Plantation shall be raised in 7.5 m wide green belt in the safety zone around the mining
lease, backfilled and reclaimed area, around water body, along the road etc. by planting native
species, following the CPCB guidelines for green belt plantation and in consultation with the DFO
(Social Forestry). Greenbelt shall be developed all along the mine lease area in a phased manner
and shall be completed within 3 years. The density of trees shall be around 2500 per ha.
1. Water shall be sprinkled at regular interval on the main roads, service roads and at
loading points to suppress fugitive dust.
2. Wet drilling method is to be adopted to control emission.
3. Provision of ear plug to the workers.
4. Blasting shall be carried out during day time only after taking necessary precautionary
measures to ensure safety of public.
5. Air and noise pollution shall be checked periodically and to maintain records.
6. Speed of trucks entering or leaving the mine is to be limited to moderate speed to
prevent undue noise from empty trucks and reduce dust emission.
7. The mined out pits should be backfilled and area should be suitably landscaped to
prevent environmental degradation.
8. Mine closure plan as per the mining plan shall be strictly followed with back filling, tree
plantation.
9. Rain water getting accumulated in the quarry/mines shall not be discharged directly to
the nearby stream or water body.
10. The workers employed shall be provided with personal protective equipment and dust
masks.
11. Periodic medical examination of the workers and shall organize medical camp in the
area.
12. Occupational health check ups shall be done once in six months for workers.
13. Adequate measures to be taken during excavation to ensure that mining activity does
not affect hydrological regime.
14. Shall ensure that no natural water course/ or water resources shall be obstructed due
to mining activity.
15. Pollution due to transportation shall be effectively controlled.
16. Mineral transportation shall be carried out through covered trucks only.
17. Regular and proper maintenance of working equipments.
18. Regular training program to the mines workers and operators.
19. In the mining area adequate number of check dam, retaining walls garland drain and
settling ponds should be provided to arrest the wash-off with rain water.
20. Comprehensive green belts of desired widths are to be maintained around the mining
areas to control noise, dust pollution and to generate a healthy environment.
CHAPTER-23
Reclamation of mined out area (best practice already implemented in the District,
requirement as per rules and regulation, proposed reclamation plan)
The mined out pits should be backfilled and area should be suitably landscaped to prevent
environmental degradation. The mine closure plan as per the Mining Plan shall be strictly followed
with back filling, tree plantation, with indigenous species. The over burden (OB) generated during the
mining operations shall be stacked at earmarked dump site(s) only. The maximum height of the
dumps shall not exceed 8m and width 20 m and overall slope of the dumps shall be maintained at
450. The OB dumps should be scientifically vegetated with suitable native species to prevent erosion
and surface run off. In critical areas, use of geo textiles shall be undertaken for stabilization of the
dump. The PP to adopted following measures to control erosion of dumps: (a) Retention/ toe walls
shall be provided at the foot of the dumps. (b) worked out slopes are to be stabilized by planting
appropriate shrub/ grass species on the slopes. During closure of the mine the over burden can be
used for filling up the entire excavated areas and in no circumstances the PP shall bring top soil from
other areas to fill the pit. In the partially filled pit, the maintenance of trenches should be strictly
followed to allow soil to stabilize on the trenches. It is preferable that an orchard is raised by the PP
on the reclaimed area to demonstrate that the mined denuded land can be reclaimed. Monitoring
and management of rehabilitated area shall continue until the vegetation becomes self sustaining.
Rainwater getting accumulated in the quarry floor shall not be discharged directly to the
nearby stream or water body. If it is to be let into the nearby water body, it has to be discharged into
silt trap on the surface within the lease area and only the overflow after allowing setting of soil to be
let into the nearby water ways. The silt trap should be of sufficient dimensions to catch all the slit
water being pumped out during one season. The silt trap should be cleaned of all the deposited silt
at the end of the season and kept ready for taking care of the silt in the next season.
It shall be ensured that the total extent of nearby quarries (existing, abandoned and proposed)
located within 500 meter radius from the periphery of this quarry is not exceeding 25 hectares within
ii. Rehabilitation – Rehabilitation is to bring bach the degraded land to a normal stage by a
special treatment. It is a process of taking some mitigation measures for disturbed environmental
condition created through mining activities.
iii. Restoration – Restoration is the process of returning the mined out land being fit to an
acceptable environmental condition. However, the general acceptable meaning of the term is
bringing the disturbed land to its original form. Restoration is often used to indicate that biological
properties of soil are put back ot what they were.
When active mining ceases, mine facilities and the site are reclaimed and closed. The goal of
mine site reclamation and closure should always be to return the site to a condition that most
resembles the pre-mining condition. Mines that are notorious for their immense impact on the
environment often made impacts only during the closure phase, when active mining operations
ceased. These impacts can persist for decades and even centuries. Mine reclamation and closure
plans must describe in sufficient detail how the mining company will restore the site to a condition
that most resembles pre-mining environmental quality; how it will prevent – in perpetuity – the
release of toxic contaminants from various mine facilities (such as abandoned open pits and tailings
impoundments); and how funds will be set aside to insure that the costs of reclamation and closure
will be paid for.
Reclamation Plan
Items Activities
(i) Backfilling
(i) Terracing
Statutory requirement:
As per the Mineral Conservation Development Rule, 2017, the following rules must be in mind
by the mine owner/agent/manager, which is a part of reclamation activities –
Regarding the District Survey Report on Minor Minerals, in connection with point no. 22 on Risk
Assessment and Disaster Management Plan from Directorate of Mineral Resources, it may be
mentioned that as per the Meghalaya Minor Mineral Concession Rule 2016 only the minerals which
falls under the Schedule II list is under the purview of the Mining and Geology Department and those
in Schedule III falls under the State Forest Department. Moreover Mining is a site specific for which
EIA and EMP in general form is not possible as long as the whole area is not disturbed. Further, if
any Mining operation comes in any location all the relevant EIA and EMP of all the applicationfor
Mining Lease on Minor Mineralswill be detailed and reflected in the Mining Plan for each specific
The Mining Operations is usually hazardous and destructive in nature. Some of the risk
assessment relating to Mining Operations is as below:
In order to mitigate the above Risk Assessment, the Disaster Management Plan in order to
minimize accidents and control the damage, the followings are to be followed:
Plantation and green belt development in respect of leases already granted in the
District
Plantation shall be raised in 7.5 m wide green belt in the safety zone around the mining lease,
backfilled and reclaimed area, around water body, along the road etc. by planting native species,
following the CPCB guidelines for green belt plantation and in consultation with the DFO (Social
Forestry). Greenbelt shall be developed all along the mine lease area in a phased manner and shall
be completed within 3 years. The density of trees shall be around 2500 per ha.
In respect of plantation and green belt development of already granted leases the lessee will
maintained a 7.5m boundary zone of the lease area which is a part of environment protection
measures and for this the proposed yearly expenditure on environment activities is as submitted by
the lesses in the Pre- Feasibility Report prior to granting of Environmental Clearance. The green belt
will not only on the one hand function as a foreground and background landscape feature resulting in
harmonizing and amalgamating the physical structures of the mines with the surrounding
environment but will also on the other hand act as a pollution sink , control erosion, make the
ecosystem more stable and also make the climate more conductive. The choice of species to be
planted should preferably be the local species compatible with the environmental conditions
Parameters
Location
Distri Name of
cts Rivers Total Suspended
pH Turbidity (mg/L)
Solids (mg/L)
West Kynshi
Nongkhnum 6.8 7.1 6.9 3.4 4.8 4.0 7.0 11 8.8
Khasi River
Hills Ranikor 6.0 6.7 6.3 2.8 8.9 5.4 5.0 19 11.7
Compiled by
Submitted by
1 Introduction
Details of Royalty or Revenue collected from Major Minerals and Minor Minerals in last three
4
years
Conclusion
PREFACE
The MOEF &CC came out with Environmental Impact Assessment Notification S.O.-
1533(E) dated 14th Sept, 2006. It has been made mandatory to obtain environmental clearance
for different kinds of development projects as listed in Scheduled -1 of notification. Accordingly
the State Govt. Vide Notification No.FOR.29/2019/1, Dated Shillong the 9th July, 2019
constituted the State Level Committee and District Level Task Force thereafter vide Order
No.FOR.29/2019/6, Dated Shillong the 19th July, 2019 notified the Nodal Officer for the
purpose of preparation of District Survey Report for Sand mining or river bed mining and for
other minor minerals.
Further, in pursuance of the order of Hon’ble Supreme Court Petition (C) No. 19628-19629
of 2009, dated 27th Feb, 2012 in the matter of Deepak Kumar etc., Vs State of Haryana and
others etc., prior environmental clearance has now become mandatory for Mining of Minor
Minerals irrespective of the area of Mining Lease.
In pursuance MOEF&CC Notification S.O. 141(E) dated 15th Jan, 2016, District
Environment Impact Assessment Authority (DEIAA) & District level Expert Appraisal
Committee (DEAC) has been formed for Category –B2 Minor Minerals having area less than or
equal to 5 ha.
Under 7(iii) (a) it was also suggested to prepare the district survey report for sand mining or
river bed mining and mining of other mineral as prescribed in Appendix X. This has been
modified vide S.O. No. - 3611(E) dated 25th July, 2018.
SEAC will scrutinize and recommend the prior environmental clearance of Mining of Minor
Mineral on basis of District Survey report. This will be a model and guiding document which is
a compendium of available mineral resources, geographical setup, environmental and
ecological set up of the district and replenishment of minerals and is based on data of various
departments, published reports, Journal and websites. The District Survey report will form the
basis for application for environmental clearance, preparation of reports and appraisal of
projects. District Survey Reports are to be reviewed once in every five years as per statue,
however the data bank of DSR can be updated, if required.
The Main objective of the preparation of District Survey Report is to ensure the following:-
1. Identification of river sand mining areas with geo references.
2. Identification of potential area of river silt with geo reference, which is being used
for filling purposes.
3. Identification of other minor minerals with geo reference.
4. Identification of other mineral resources if available.
CHAPTER-1
INTRODUCTION
1.1 ABOUT DISTRICT
The West Khasi Hills District was carved out of the East Khasi Hills District on 28th October
1976. The district is situated between 25010’ and 25051’ Latitude and 90044’ and 91049’ Longitude.
It is bounded on the north-west by Kamrup District of Assam, north-east by Ri-Bhoi District. On the
east by East Khasi Hills District and on the south by South West Khasi Hills District, on the west by
East Garo Hills District and South Garo Hills District. It have an area of 3911.22 km2 and population
of 2,87,781 (2011 census) and density of 73.58% and literacy rate of 78.83%. Nongstoin is the
District Headquarter and is divided into four C & RD Blocks viz Mairang, Mawshynrut,
Mawthadraishan and Nongstoin and has two Sub-Divisions viz Mairang and Mawshynrut.
The CLIMATE of the district is mildly tropical in the northern and southern foothills, while in
the central upland zone, the climate is temperate and places at medium altitude in the northern,
western and southern parts of the district experience sub-tropical climate. The district is influenced
by the South-West monsoon and rainfall is assured during summer, but differs greatly in intensity
from area to area within the district. The average rainfall ranges from 1200 mm to 3000 mm per
annum.
The district comprises of eight SYIEMSHIP viz Nongstoin, Nongkhlaw, Maharam, Myriaw,
Rambrai, Mawiang, Langrin, Noboshphoh together with the three SIRDARSHIPS of Jyrngam,
Riangsih and Nonglang.
CHAPTER-2
Overview of Mining activity in the District
Details of production of Sand or Bajri (Gravel/Aggregate) or minor minerals in last three years is
Nil
CHAPTER-6
Erosion is natural process, weathering, corrosion, or abrasion can reduce a material into
smaller particles. Normally, these smaller units are relocated by water, wing, ice, or man. Erosion
removes to soil, organic material, and other valuable resources. Once a material is broken free of the
larger mass, it can be carried away and deposited elsewhere.
There are four seasons in the District namely summer, monsoon or rainy, autumn and winter.
The summer season extends from the end of March to mid- May, which is characterized by relatively
high temperature. Rainy season commences with the onset of southwest monsoon in April and lasts
up to October. This is followed by short autumn from mid-October to November. Winter season
extends from December to the end of March. This is the coldest season of the year with sharp
decline in temperature.
The important rivers of the District are Kynshi, Wahblei, Rwiang and Wahryndi are which are
south flowing rivers and Khri, Tyrsung, Umrambrai, Umit and Umshiak are north flowing joining the
Brahmaputra . All these rivers emerges from the catchment and hills of the district having an average
height of 1300m above mean sea level as first order river, navigates down the undulating land with
gentle to moderate slopes whose elevation ranges from 200 to 600 above msl before meeting the
plains bordering Assam and Bangladesh
The soils of Khasi Hills are generally red loamy, varying sometimes between clayey and
sandy loam and rich in organic matter and nitrogen, vegetation cover is mostly dense tropical mixed
forest type with predominance of Pine and other local indigenous trees and bamboos.
Most of these rivers have gone through the two stages of life within the district and because
of the type of soil and reduction in vegetation cover as people have started taking up cultivation in
the slopes of the hills, compounded by depleting forest cover and moderate to high velocity,
significant erosion activity occurs and during monsoon the rivers water is laden with good amount of
solids. As it enters the flat terrain, the rivers meandering start to occur leading to deposition of
sediments on one side and erosion on the other. However, as banks of theses rivers at this stage
are still of relatively good height, even though from time to time flood water covers the agricultural
plains only deposition of thin sheet of silt would happen in the field which actually benefits the soil.
In winter when the river is carrying just the base flow, sediment deposits in the river beds in
the lower plain stretches gets expose and mining activity becomes favorable.
CHAPTER-7
General Profile of the District
The West Khasi Hills District was carved out of the East Khasi Hills District on 28th October
1976. The district is situated between 25010’ and 25051’ Latitude and 90044’ and 91049’ Longitude.
It is bounded on the north-west by Kamrup District of Assam, north-east by Ri-Bhoi District. On the
east by East Khasi Hills District and on the south by South West Khasi Hills District, on the west by
East Garo Hills District and South Garo Hills District. It have an area of 3911.22 km2 and population
of 2,87,781 (2011 census) and density of 73.58% and literacy rate of 78.83%. Nongstoin is the
District Headquarter and is divided into four C & RD Blocks viz Mairang, Mawshynrut,
Mawthadraishan and Nongstoin and has two Sub-Divisions viz Mairang and Mawshynrut.
The CLIMATE of the district is mildly tropical in the northern and southern foothills, while in
the central upland zone, the climate is temperate and places at medium altitude in the northern,
western and southern parts of the district experience sub-tropical climate. The district is influenced
by the South-West monsoon and rainfall is assured during summer, but differs greatly in intensity
from area to area within the district. The average rainfall ranges from 1200 mm to 3000 mm per
annum.
The Climate of the district varies in latitudinal and longitudinal directions and is influenced
mainly by physiography. There are four seasons in the district namely summer, monsoon or rainy,
autumn and winter. The summer season extends from the end of March to mid May, which is
characterized by relatively high temperature, occasional thunderstorm with high wind velocities. The
rainy season commences with the onset of southwest monsoon in April and lasts up to October.
This is followed by short autumn from mid October to November. This season indicates the slow
retreating of monsoon with clear and sunny sky. The winter season extends from December to the
end of March. This is the coldest season of the year with sharp decline in the temperature. During
winter, some high altitude areas of the state experiences very cold nights. Winter is basically dry
with lower diurnal range of temperature.
In general, the district has a mildly tropical climate in the northern and southern foothills,
whereas central upland portion experiences temperate climate and the places of medium altitude of
the northern, southern and western parts of the district experience sub-tropical climate.
The district receives a fairly high rainfall throughout the year. Most of the precipitation occurs
during the rainy season i.e. between April and October due to SW monsoon. The average rainfall in
some of the selected stations of the district is presented in Table
Average Rainfall (mm) of Selected Stations in West Khasi Hills
CHAPTER-8
Land Utilization Pattern
3 Forests (Classed 31900 31900 36772 36772 51850 51850 14489 14489 135011 135011
and uncalssed
forest)
4 Area not
available for
cultivation
(i) Area under
non-agricultural
uses
(a) Water logged 0 0 0 0 0 0 0 0 0 0
land
(b) Social Forestry 5076 5076 2544 2544 3938 3938 2181 2181 13739 13739
(c) Land under still 1254 1254 571 571 692 692 761 761 3278 3278
water
(d) Other land 4060 4098.5 609 633.5 847 1443 102 104 5618 6279
Total (a + b + c + 10390 10428.5 3724 3724.5 5477 6073 3044 3046 22635 23296
d)
(ii) Barren 6590 6590 5156 5156 44370 44370 2960 2690 59076 59076
&unculturable
land
(Total of (i) + 16980 16980 8880 8880 49847 49847 6004 6004 81711 82372
(ii)
5 Other
uncultivated
lands
(a) Permanent
pasture and other
grazing lands
(b) Land under
miscellaneous
tree crops and
grooves etc.
(c) Cultivable waste 17000 17000 13690 13690 24499 24499 12390 12390 67579 67579
lands
Total (a + b + c) 24608 24608 23136 23136 38314 38314 16505 16482 102563 102540
6 Fallow lands
(a) Fallow lands 8553 8553 7606 7606 11772 11772 4624 4624 32555 32555
other than
current fallows
(b) Current fallows 2200 2200 3801 3801 3720 3720 2251 2251 11972 11972
Total (a + b) 10753 10753 11407 11407 15492 15492 6875 6875 44527 44527
7 Net areas sown 1321 1282.5 4873 4845.5 3827 3231 1920 1941 11939 11939
8 Area sown 940 940 2525 2525 1420 1420 1100 1100 5985 5985
more than once
9 Total crooped 2261 2222.5 7398 7373.5 5247 4651 3020 3041 17924 17288 Area
area figure
shown in
Appendix
NB:If the Block-wise area is not available , then the report can be prepared for the whole district fort he time
being (as the district wise area is available)
Area of broom stick cultivation in this report is shown under Land Misc. Etc. and no. Longer shown under
Total Cropped Area
Social forestry considered for forest taken under Old Plantation, JFMC and 12thFinance Commission.
Forest:
Table Showing Forest covers in West Khasi Hills District as per the
(area in sq km)
State of Forest Report 2017
1 31 NA NA NA Nil
CHAPTER-9
Geomorphologically the district is an undulatory terrain with the E-W trending Khasi hill
ranges of Central Upland zone. The West Khasi Hills district also represents the remnant of ancient
plateau of Indian Peninsular shield that is deeply dissected suggesting several geotectonic and
structural deformities that the plateau has undergone. The average altitude of the Central Upland is
about 1,300 m above Mean Sea Level. The highest peak is “Kyllang rock” touching a height of 1774
m.amsl (metres above Mean Sea Level). Mawthadraishan range, trending east – west, is the most
significant hill range of West Khasi Hills District. Other northern, southern and western parts have a
general altitude of 150 to 900 m.amsl. Geomorphologically, the district represents denudational hills
of old gneissic and schistose rocks except in the southern parts where highly dissected plateau are
observed. Few narrow elongated intermontane valleys are seen along major lineaments. The
drainage system of the district is controlled by topography. The east-west trending central upland
acts as water divide dissecting the district into two drainage basins. The northern system drains out
into the mighty Brahmaputra River in the adjoining Assam state and the major drainage system in
the south drains into the Meghna basin merges into the Bangladesh plains. Kynshi is the major river
that originates in the southern slope of Marpna peak near Mawmaram village. This river is joined by
number of tributaries on its westerly course ultimately draining into Bangladesh. Another River Khri
rises near Kyllang rock flowing northward into Assam plains. Other important Rivers of the district
are Wahblei, Riangdo, Tyrsung, Ryndi, Rwiang etc. The drainage pattern of the district is angular to
sub-angular and is found to be structurally controlled.
Broadly, the district can be differentiated into the following geomorphic units.
- Denudational Low and High Hills: It occupies the major part of the district comprising of
hard rocks like granite and gneiss. It is moderately dissected by fractures and joints
forming a good number of narrow intermontane valleys.
- Dissected Plateau: It is found in the southern portion of district comprising of soft and
friable rocks like shale, sandstone and quartzite.
- Deep Gorges: It is exposed in the southern parts comprising of Tertiary rocks like
sandstone, shale and limestone.
Soil Type
The district shows different types of soil as the provenance differs widely. Red Gravelly and Red
Loamy Soil are the common soil types. The soils are acidic in nature and comparatively rich in
organic matter and nitrogen but poor in phosphorous.
CHAPTER-10
Rainfall: month-wise
CHAPTER-11
The Geology of West Khasi Hills is characterized by the presence of wide variety of rock
types that originated in various epochs of the earth's evolution. The older metamorphic comprising of
banded magnetite quartzite (BMQ), quartzite, schists, and amphibolites constitute the basement
rocks and belongs to Proterzoic in age. The other group of rocks exposed under Assam Meghalaya
Gneissic Complex (AMGC) is a combination of classified and unclassified metamorphic rocks. The
AMGC is unconformably overlain by Shillong Group of rocks of Proterozoic age comprising of
rhythmic sequence of conglomerate, quartzite, shale phyllites quartzite, phyllites and quartz sericite
schist. Khasi Greenstone of Proterozoic age is represented here bt meta diorite, epidiorite,
ambhibolite, norite and basic megaxenolith.
Pink-grey porphyritic granite or non-porphyritic granitoid belonging to the Mylliemgranitoid
occurs in the south western part of West Khasi Hills. The Nongpohgranitoid occurs in the central and
northern part of the districts and they are represented by granodiorite- diorite, grey- pink porphritic
granite, coarse grained pink-gery granite and quartz vein/reef. South khasi batholith is represented
by porphyritic granite, coarse grained pink granite and pegmatite veins.
The Mahadekfromation is represented by gritty sandstone alternating with conglomerate
which is overlain by felsphatic sandstone, conglomerate and clay overlain by glauconitic sandstone.
The Mahadek formation occurs in the southern and south western part of the district. The Jaintia
group of rocks is represented by the members of Sylhet limestone, Sylhet sandstone, Tura limestone
and Siju-Prang limestone. The Jaintia group is overlain by older alluvium of Pleistocene to Holocene
age represented by Chaparfromation and Sarbhog formation. The Chapar formation is represented
by highly oxidized dark brown to red brown loamy sand and the Sarbhog formation is represented by
oxidized to feebly oxidized sand, silt and clay.
MINERAL RESERVES/RESOURCES AND POTENTIAL OCCURRENCES
Sillimanite and corundum are the main economic mineral occurring in Sonapahar and north
of Nanku. The famous Sonapahar- Nongdom-Langtor, Riangdo, Sillimanite-corundum deposit in
West Khasi hills, is the singular occurrence in India, from which superior grade sillimanite and
corundum are being exploited. The massive lensoid bodies of sillimanite-corundum are contained
mostly in quartz-sillimanite schist and in a few cases in biotite-sillimanite-quartz schist. The reserve
estimate of sillimanite as per Indian Mineral Year Book, 2000 is 55807 tonnes.
Lateritic bauxite was identified around Rambrai area, northwestern and northeastern parts
of Maupatshiyar village of West Khasi Hills District, Meghalaya. All the lateritic bauxite bodies were
developed over granite gneiss, norite/metanorite and sheared amphibolites. The thickness of the
complete profile of lateritic bauxite is about 8-10 m. Lateritic bauxite were also identified around
Umsung, Nongjyellieh, Lawse, Nongyllieh and Mawdub areas. The host rock is granite gneiss with
patchy charnockite of Assam-Meghalaya Gneissic Complex. The thickness of the bauxite is about
3m. Mainly four varieties of bauxite ore viz. pisolitic, bouldery, massive and clayey (friable) are
present in the area. A total of 1.58 MT of bauxite have been estimated in Rambrai area.
Occurrence of Banded Ferruginous Quartzite was reported in West Khasi Hills. Titanium
vanadiferous, magnetite body associated with gabbroic body 5 km east of Rambrai was also
reported. Minor bands were also recorded from Rangsapara, Nongkyndong, Um Kiang and
Nongianglang. The ferruginous bands occur with quartzite and are a few millimetres thick.
Ferruginous layers comprise of flaky hematite with little magnetite. Many thin bands were also
observed around Sildubi, Aradonga and Bansapani areas of south of Hahim in West Khasi Hills
district.
The limestone band around Barsora area belongs to Shella formation. The limestone is
highly fossiliferous, hard, massive, jointed and fractured. The physical and chemical properties
suggest that this can be used in chemical and cement industry.
Coal occurrences are mainly confined to the tertiary sediments of West Khasi hills. Langarin
coalfield is located in southern part of West Khasi hills and it forms the largest coalfield of
Meghalaya. The coal occurs around Barsora and Maheshkhola village. Exploration for coal by GSI in
Nongjri-Kulang area, Nonghyllum plateau, has proved coal in Langrin coal field. The resource
estimated in Langrin coal field is 133.16 MT.
Deposits of multicoloured granite have been located around Sonapahar (Mawthaliang block)
and Maroid,Thangmaw, Lawar and Old Nongstoin in West Khasi Hills district. In Mawthaliang block,
West Khasi Hills district, the granite is occurring as bouldery outcrops and in Maroid and Thangmaw
areas the granites occur as rectangular to ellipsoidal detached boulders. The granite may yield good
dimension stone and the gneisses are used as road and building materials.
CHAPTER-12
Averag
Length
e Volum Mineable
of the Area
Width e mineral
Portion of area Recom
of area recom potential
River recom mende
recom mende (in metric
Sl recommen mende d for
River GPS mende d for tonne)
No ded for d for mineral
d for mineral (60% of
mineral mineral conces
mineral conces total
concession conces sion
conces sion (in mineral
sion (in (sq m)
sion (in cu m) potential)
m)
m)
E 91035’12.95”
E 91034’01.72”
E 91034’52.16”
E 91033’54.89”
E 91033’27.00”
E 91032’45.08”
E 91032’35.79”
E 91032’12.98”
E 91017’55.83”
E 91018’36.61”
E 91019’10.57”
E 91019’35.20”
E 91019’33.77”
E 91020’49.16”
E 91020’58.38”
E 91021’01.92”
E 91023’07.86”
E 91039’57.55”
E 91039’43.54”
E 91041’26.37”
E 91042’49.22”
E 91042’12.61”
E 91043’27.41”
E 91041’50.49”
E 91011’15.97”
E 91011’50.95”
E 91011’13.97”
E 91010’14.09”
E 91010’28.60”
Mineral Potential
- - 533427 720126.45
Annual Deposition
- - - -
- - - -
Conclusion
Ordinary earth and Sand has become very important minerals for our society due to its many uses.
Ordinary earth can be used for making brick, filling roads, whereas sand may be used as building
sites, brick-making, making glass, Sandpapers, reclamations, and etc. The role of sand is very vital
with regards to the protection of the environment. It acts as a buffer against strong waves and storm
surges by reducing their impacts as they reach the river bed. Clean sand is indeed a rare commodity
on land, but common in sand dunes and beaches.
The composition of sand is highly variable, depending on the local rock sources and conditions, but
the most common constituent of sand in inland continental settings and non-tropical coastal settings
is silica (silicon dioxide, or SiO2), usually in the form of quartz which because of its chemical
inertness and considerable hardness, is the most common mineral resistant to weathering and it has
become a very important mineral for the expansion of society.
Sand is a naturally occurring granular material composed of finely divided rock and mineral particles.
River sand is one of the world’s most plentiful resources (perhaps as much as 20% of the Earth’s
crust is sand) and has the ability to replenish itself. River sand is vital for human well being & for
sustenance of rivers.
The MoEF & CC has also issued notifications SO No. 141(E) dated 15.01.2016 and SO No. 190(E)
dated 20.01.2016. These notifications promote use of satellite imagery to decide the site suitable for
mining and quantity of sand which can be mined.
a. Parts of the river reach that experience deposition or aggradations shall be identified first.
The Lease holder/ Environmental Clearance holder may be allowed to extract the sand
and gravel deposit in these locations to manage aggradations problem.
b. The distance between sites for sand and gravel mining shall depend on the
replenishment rate of the river. Sediment rating curve for the potential sites shall be
developed and checked against the extracted volumes of sand and gravel.
c. Sand and gravel may be extracted across the entire active channel during the dry
season.
d. Abandoned stream channels on terrace and inactive floodplains be preferred rather than
active channels and their deltas and flood plains. Stream should not be diverted to form
inactive channel.
e. Layers of sand and gravel which could be removed from the river bed shall depend on
the width of the river and replenishment rate of the river.
f. Sand and gravel shall not be allowed to be extracted where erosion may occur, such as
at the concave bank.
g. Segments of braided river system should be used preferably falling within the lateral
migration area of the river regime that enhances the feasibility of sediment replenishment.
h. Sand and gravel shall not be extracted within 200 to 500 meter from any crucial hydraulic
structure such as pumping station, water intakes, and bridges. The exact distance should
be ascertained by the local authorities based on local situation. The cross-section survey
should cover a minimum distance of 1.0 km upstream and 1.0 km downstream of the
potential reach for extraction. The sediment sampling should include the bed material and
bed material load before, during and after extraction period. Develop a sediment rating
curve at the upstream end of the potential reach using the surveyed cross- section. Using
the historical or gauged flow rating curve, determine the suitable period of high flow that
can replenish the extracted volume. Calculate the extraction volume based on the
sediment rating curve and high flow period after determining the allowable mining depth.
i. Sand and gravel could be extracted from the downstream of the sand bar at river bends.
Retaining the upstream one to two thirds of the bar and ripariangh Vegetation is accepted
as a method to promote channel stability.
j. Flood discharge capacity of the river could be maintained in areas where there are
significant flood hazard to existing structures or infrastructure. Sand and gravel mining
may be allowed to maintain the natural flow capacity based on surveyed cross- section
history.
l. The Piedmont Zone (Bhabhar area) particularly in the Himalayan foothills, where riverbed
material is mined, this sandy-gravelly track constitutes excellent conduits and holds the
greater potential for ground water recharge. Mining in such areas should be preferred in
locations selected away from the channel bank stretches.
m. Mining depth should be restricted to 3 meter and distance from the bank should be 3
meter or 10 percent of the river width whichever less.
n. The borrow area should preferably be located on the river side of the proposed
embankment, because they get silted up in course of time. For low embankment less
than 6 m in height, borrow area should not be selected within 25 m from the toe/heel of
the embankment. In case of higher embankment the distance should not be less than 50
m. In order to obviate development of flow parallel to embankment, cross bars of width
eight times the depth of borrow pits spaced 50 to 60 meters centre-to centre should be
left in the borrow pits.
o. Demarcation of mining area with pillars and geo-referencing should be done prior to start
of mining.
The above notifications and Guidelines, being notified under the provisions of the Environment
(Protection) Act, 1986, have acquired the status of statutory Provisions and have to be followed.
GSI Guidelines-Geological Survey of India (GSI) has collated/ formulated considered geo-scientific
opinions to address issues pertaining to riverbed gravel/sand mining. Besides resource extraction,
ultimate objectives of riverbed mining should be:-
III. To work out the sediment influx/ replenishment capacity of the river, to restore the
riverine configuration (landforms and fluvial geomorphology, such as bank erosion,
change of river course gradient, flow regime, etc.),
GSI has identified major hazards caused due to mining of sand/gravel as under:
Instream habitat: The impact of mining may result in increase in river gradient, suspended load,
sediment transport, sediment deposition, turbidity, change in temperature, etc. Excessive sediment
deposition for replenishment/ refilling of the pits affect turbidity, prevent the penetration of the light
required for photosynthesis of micro and macro flora which in turn reduces food availability for
aquatic fauna. Increase in river gradient may cause excessive erosion causing adverse effect on the
instream habitats. B
Riparian habitat: This includes vegetative cover on and adjacent to the river banks, which controls
erosion, provide nutrient inputs into the stream and prevents intrusion of pollutant in the stream
through runoff. Bank erosion and change of morphology of the river can destroy the riparian
vegetative cover.
Degradation of Land: Mining pits are responsible for river channel shifting as well as degradation of
land, causing loss of properties and degradation of landscape.
Lowering of groundwater table in the floodplain area: Mining may cause lowering of riverbed
level as well as river water level resulting in lowering of groundwater table due to excessive
extraction and draining out of groundwater from the adjacent areas. This may cause shortage of
water for the vegetation and human settlements in the vicinity.
Depletion of groundwater: excessive pumping out of groundwater during sand mining especially in
abandoned channels generally result in depletion of groundwater resources causing severe scarcity
and affecting irrigation and potable water availability. In extreme cases it may also result in creation
of ground fissures and land subsidence in adjacent areas.
Polluting groundwater: In case the river is recharging the groundwater, excessive mining will
reduce the thickness of the natural filter materials (sediments), infiltration through which the ground
water is recharged. The pollutants due to mining, such as washing of mining materials, wastes
disposal, diesel and vehicular oil lubricants and other human activities may pollute the ground water.
Choking of filter materials for ingress of ground water from river: Dumping of waste material,
compaction of filter zone due to movement heavy machineries and vehicles for mining purposes may
reduce the permeability and porosity of the filter material through which the groundwater is
recharging, thus resulting in steady decrease of ground water resources.
The GSI has suggested that riverbed mining may be allowed considering minimization of the above
mentioned deleterious impacts. The guidelines of National Water Policy of India should also be
followed which states that watershed management through extensive soil conservation, catchment
area treatment, preservation of forest, increasing of forest cover and construction of check dams
should be promoted. Efforts shall be made to conserve the water in the catchments. Following geo-
scientific considerations have been suggested to be taken into account for sand/ gravel mining:-
1. Abandoned stream channels on terrace and inactive floodplains may be preferred rather
than active channels and their deltas and floodplains. Replenishment of ground water has
to be ensured if excessive pumping out of water is required during mining.
5. Segments of braided river system should be used preferably falling within the lateral
migration area of the river regime that enhances the feasibility of sediment replenishment.
Mining at the concave side of the river channel should be avoided to prevent bank erosion.
Similarly meandering segment of a river should be selected for mining in such a way as to
avoid natural eroding banks and to promote mining on naturally building (aggrading)
meander components.
6. Scraping of sediment bars above the water flow level in the lean period may be preferred
for sustainable mining.
8. The Piedmont Zone (Bhabbar area) particularly in the Himalayan foothills, where riverbed
material is mined. This sandy- gravelly track constitutes excellent conduits and holds the
greater potential for ground water recharge. Mining in such areas should be preferred in
locations selected away from the channel bank stretches. Areas where channel banks are
not well defined, particularly in the braided river system, midstream areas should be
selected for mining of riverbed materials for minimizing adverse effects on flow regime and
instream habitat.
9. Mining of gravelly sand from the riverbed should be restricted to a maximum depth of 3m
from the surface. For surface mining operations beyond this depth of 3m (10 feet), it is
imperative to adopt quarrying in a systematic bench- like disposition, which is generally
not feasible in riverbed mining.
10. Hence, for safety and sustainability restriction of mining of riverbed material to maximum
depth of 3m.is recommended.
11. Mining of riverbed material should also take cognizance of the location of the active
channel bank. It should be located sufficiently away, preferably more than 3m away
(inwards), from such river banks to minimize effects on river bank erosion and avoid
consequent channel migration.
12. Continued riverbed material mining in a given segment of the river will induce seasonal
scouring and intensify the erosion activity within the channel. This will have an adverse
effect not only within the mining area but also both in upstream and downstream of the
river course. Hazardous effects of such scouring and enhanced erosion due to riverbed
mining should be evaluated periodically and avoided for sustainable mining activities.
13. Mineral processing in case of riverbed mining of the sandy gravelly material may consist of
simple washing to remove clay and silty area. It may involve crushing, grinding and
separation of valueless rock fragments from the desirable material. The volume of such
waste material may range from 10 to 90%. Therefore, such huge quantities of mine
wastes should be dumped into artificially created/ mined - out pits. Where such tailings /
waste materials are very fine grained, they may act as a source of dust when dry.
Therefore, such disposal of wastes should be properly stabilized and vegetated to prevent
their erosion by winds.
14. Identification of river stretches and their demarcation for mining must be completed prior to
mining for sustainable development.
15. The mined out pits should be backfilled where warranted and area should be suitably
landscaped to prevent environmental degradation.
16. Mining generally has a huge impact on the irrigation and drinking water resources. These
attributes should be clearly evaluated for short-term as well as long-term remediation
(MoWR,2017.