Professional Documents
Culture Documents
MODEL : M220-T200
SER.NO.:
DAT E :
2. Please use the power supply at the voltage and frequency specified on the
nameplate of the cutting machine and grinder. Before starting, you must have a
reliable ground. Before use, you must use a megohmmeter above 500 volts to
measure the insulation between live parts and the shell that the human body contacts
meters of the wheel alignment. The operator is not allowed to stand in the position
where the wheel is aligned; otherwise, the wheel may fly out and hurt people.
6. Before turning on the machine, turn the machine in the same direction as the
indicator.
production permit, and fail to reach the machine's marked line speed.
8. Turn on the machine for 10 minutes before turning it on. Make sure that the
machine can rotate flexibly, the grinding wheel starts smoothly, there is no noise, and
9. When in use, balance them with force, and the workpiece and the grinding wheel
must not slam into each other, so as to prevent the grinding wheel from flying and
hurting.
10. The difference between the diameters of the two grinding wheels of the grinding
machine is greater than 15%. The grinding wheel should be replaced. The distance
between the working bracket and the grinding wheel should not be greater than 2mm.
11. When using a multi-functional cutting machine to cut on the board, the board's
cutting seam and the sand sheet should be aligned in a straight line to grasp the
balance of the machine, and evenly force the hook to move slowly. After cutting, lift
12. When replacing the grinding wheel, you must cut off the power supply, check that
the grinding wheel is not cracked, tap the grinding wheel with a mallet, and make a
13. When the machine is in use, if it is found that the motor has abnormal sound, heat
troubleshooting.
14. The working system of the motor adopts S2 30min, that is, continuous working
for 30 minutes. It should be stopped and cooled before use, otherwise it is easy to
damage the motor winding, the insulation level of the motor is B, and the allowable
appreciation is 90K. Therefore, it is normal for the temperature rise value to be less
15. The lubricating grease of the bearing shall be changed every six months and
repaired once a year. During the overhaul, the machine shall be completely
disassembled. After the disassembly and repair, the coil shall be confirmed to be free
of short circuit, and the screw shall be fastened. It can only be used after the machine
Press the wire firmly. When the machine is stopped, turn off the power switch.
I. Overview
Grinders are mainly used for the grinding of knives and cutting tools, as well as
grinding, deburring and cleaning parts. Widely used in industrial and mining
The grinder can be used in areas where the altitude does not exceed 1000 meters, the
relative humidity of the surrounding air is not greater than 95%, and the maximum
This machine uses a bag to remove dust. The dust removal efficiency can reach more
than 98%, and the dust concentration is less than 10 mg / m3, which complies with
relevant national regulations. Using this machine can improve the working
The grinder is not resistant to chemical corrosion and cannot be exposed to outdoor
use.
Grinders use dust bags to remove dust. When dust is more and more absorbed in the
dust bag, it will affect the air intake of the fan. Therefore, the front door should be
opened regularly to remove the dust bag and purge the dust in the bag.
1. In order to keep your grinding machine in good working condition for a long time,
and to enable you to operate and maintain the grinding machine correctly, please read
2. Idle the machine for 10 minutes before turning it on. Make sure that the grinder
rotates flexibly and the grinding wheel start-up protection device is firm before use.
3. For grinders above 200mm, the outer circle of the grinder must be corrected to