Professional Documents
Culture Documents
machine when using it, please read the manual carefully to avoid
24000RPM, so the operator must wear clothes, work wear hats, gloves
prohibited.
5. When the machine is working, staff and machines should keep certain
distance.
7.To avoid lighting storm work to prevent the risk of long-range electric
1. Machine need warm up before work then check the lubrication system,
such as the machine does not start for a long time, can be manually each
part of the lubrication; After adding the oil slowly back and forth, to
ensure lubrication oil can be uniformly applied to the rail and screw.
2. Due to low temperatures, can be both the rail and screw add oil, plus
3. Before the process of engraving must check that the spindle cooling
6.After the tool installed should be test cut one or two times.
8.Workpiece clamping, must follow the "real loaded, installed flat, fitted
10.The tool installed card, the card must first head screwed into the lock
nut being put together fitted to the motor shaft, then the tool is inserted
into the first card, and then use the lock nut on the blade wrench slowly,
handling tools , elastic nut disable push-pull method, use rotation mode.
11.The length of the tool head is exposed card must be decided jointly in
accordance with the engraving depth, the workpiece and the jig is
knife point. After replacing the tool, you must immediately redefined Z
axis from the knife point, X, Y-axis from the knife point can not be
changed.
13. Do not spindle rotate when make tool sensor, prohibited on the knife
to water, oiling, the knife would have to cover the cup when not in use.
14. Before the start of the processing (the knife), shall put hand on the red
1. Prohibits touch the tip and iron, iron must use a brush to clean.
2. Prohibit contact with your hands or any other means is rotating spindle,
not wipe the piece with cotton yarn, can not clean the machine.
4. Operation of the machine, the operator may not leave their posts
5.Always check the bearing temperature is too high should find the
relevant personnel.
6. During the process, not allowed to open the machine guard doors.
8. Its prohibited on the beam and put the machine baffle anything to avoid
falling injury.
1. Remove the chips, clean the machine, keep the machine and the
environment clean.
3. Turn off the power and total power on the machine operator panel.
4.Its strictly prohibited to beat the chuck when unloading cutter beat.
5.To turn off the power to the machine processing is completed, the
accuracy of the machine, and screw in the transmission process also plays
an important role.
1.All cleaning of the spindle, maintenance and repair work must make
contact with the rotating part of the spindle arm, otherwise it will cause
injury.
5. Please use the specified spindle shank, it may damage the spindle
they may cause mechanical failure and damage, and shorten the life of
electric spindle.
3. The computer and the machine should connect earth wire to prevent
interference.
5.The machine does not work long-term, you should turn off the machine
power.
Thank you for purchasing BCAMCNC products
Website: www.bcamgroup.com
www.bcamcnc.com
www.bcamlaser.com
Service email: service@bcamgroup.com
service01@bcamgroup.com
Skype: bcamservice1jason/nashmeng1
Whatsapp: 15153116692/18615691023
Phone:0531-67864283 Fax:0531-67864283