You are on page 1of 36

OPERATION AND

MAINTENANCE MANUAL

om
i.c
rv

Drill press with drive belt


fe

Art. 0012

ORIGINAL INSTRUCTIONS
MACHINES AND
ACCESSORIES

FOREWORD
All rights are reserved of reproduction and dissemination of this Technical Manual and documentation cited and/or attached. It is expressly forbidden to reproduce, publish or distribute any information from this Manual. Copyright by FERVI

Read this manual before operating any machinery

ORIGINAL INSTRUCTIONS
Before starting any operation it is compulsory to read this instruction manual. The guarantee
that the machine will function and perform properly is strictly dependent upon the application
of all the instructions contained in this manual.

om
Operator Qualification

The operators assigned to using this machine must be supplied with all of the necessary
information and instruction and should be provided with adequate training regarding
safety in pertaining to:
a) The conditions of use of the equipment;
i.c
b) Foreseeable abnormal situations, pursuant to Article 73 of Legislative Decree
81/08.
rv

We guarantee the Machine's conformity to the specifications and technical instructions


described in the Manual on the date of issuance and listed herein; On the other hand,
fe

the machine may also be subject to important technical changes in the future, without
the manual being updated.

Therefore, see FERVI for information about modifications that could be implemented.

REV. 2 November 2013

Page 2 of 36
MACHINES AND
ACCESSORIES

CONTENTS

1 INTRODUCTION ........................................................................................ 5

All rights are reserved of reproduction and dissemination of this Technical Manual and documentation cited and/or attached. It is expressly forbidden to reproduce, publish or distribute any information from this Manual. Copyright by FERVI
1.1 Preface .......................................................................................................................... 6

2 SAFETY WARNINGS .................................................................................. 7


2.1 General safety rules for machine tools .......................................................................... 7
2.2 Specific safety regulations for drills .............................................................................. 9
2.3 Safety regulations regarding the electric system of machine-tools ............................. 10
2.4 Technical support ........................................................................................................ 10

om
2.5 Other provisions ......................................................................................................... 10

3 TECHNICAL SPECIFICATIONS ................................................................. 11

4 ASSEMBLING THE MACHINE.................................................................... 12


4.1 Main Components........................................................................................................ 12
4.2 Pillar and base assembly ............................................................................................. 13
4.3 Installation of the table support and the rack ............................................................. 13
i.c
4.4 Installation of the handle and the table ...................................................................... 13
4.5 Installing the head assembly ...................................................................................... 14
4.6 Installation of the knobs ............................................................................................. 14
4.7 Installing of the spindle .............................................................................................. 14
4.8 Installing the spindle guard ........................................................................................ 15
rv

5 MACHINE ELEMENTS ............................................................................... 16


5.1 Information plate ........................................................................................................ 17
5.2 Pictograms .................................................................................................................. 17

6 SWITCHES AND CONTROL LEVERS .......................................................... 19


fe

6.1 Control Buttons ........................................................................................................... 19


6.2 Control Levers ............................................................................................................. 21

7 OPERATION ............................................................................................ 22
7.1 Installation of the tip .................................................................................................. 23

8 ADJUSTING THE MACHINE ...................................................................... 24


8.1 Adjusting the table...................................................................................................... 24
8.2 Adjusting the drilling depth ........................................................................................ 24
8.3 Adjusting the Speed .................................................................................................... 24

9 SAFETY DEVICES ON THE MACHINE ........................................................ 27


9.1 Grounding ................................................................................................................... 27
9.2 Safety devices ............................................................................................................. 27
9.2.1 INTERLOCKING MOVEABLE GUARD ............................................................................ 27
Page 3 of 36
MACHINES AND
ACCESSORIES

9.2.2 PULLEY HOUSING LOCK ............................................................................................ 28

10 MAINTENANCE ..................................................................................... 29
10.1 Routine maintenance ............................................................................................... 29
All rights are reserved of reproduction and dissemination of this Technical Manual and documentation cited and/or attached. It is expressly forbidden to reproduce, publish or distribute any information from this Manual. Copyright by FERVI

11 TROUBLESHOOTING ............................................................................. 30

12 ELECTRICAL CIRCUIT ........................................................................... 31

13 DISPOSAL OF PARTS AND MATERIALS ................................................. 31

14 SPARE PARTS ....................................................................................... 32

15 DRILL PRESS ACCESSORIES ................................................................. 36

om
i.c
rv
fe

Page 4 of 36
MACHINES AND
ACCESSORIES

1 INTRODUCTION
This manual is delivered with the machine, and it must be regarded as an inseparable part of

All rights are reserved of reproduction and dissemination of this Technical Manual and documentation cited and/or attached. It is expressly forbidden to reproduce, publish or distribute any information from this Manual. Copyright by FERVI
it.
The manufacturer holds all ownership to material and intellectual property of this manual;
any disclosure or copying, even partial, of this publication without prior written consent is
forbidden.

The purpose of this manual is to provide the knowledge necessary for the use and
maintenance of the machine Drill press Art. 0012 and create a sense of responsibility and
an understanding of the capabilities and limitations of the means entrusted to the operator.

om
As the machine is entrusted to experienced and skilled operators, the following machine must
be perfectly known by the operator if you want it to be used safely and effectively.
Operators must be properly trained and prepared, so make sure that this manual is read and
consulted by the staff responsible for commissioning, operation and maintenance of the Drill
press. This is to make all operations the safest and most effective possible for those who
carry out these tasks.
Therefore, it is imperative to strictly comply with the requirements in this manual, a
necessary condition for safe and satisfactory operation of the machine.
Prior to installation and use of the Drill press, authorised personnel shall:
i.c
 carefully read this technical document;
 know which protections and safety devices are available on the machines, their location
and how they work.

It is the responsibility of the buyer to ensure that users are properly trained, that they are
aware of all the information and instructions in this document and that they are aware of the
rv

potential risks that exist while working with the Drill press.

The manufacturer waives any and all responsibility for damage to people and/or
things caused by non-observance of the instructions in this manual.
fe

The Drill press was designed and built with mechanical guards and safety devices designed
to protect the operator/user from possible injury. It is strictly forbidden to modify or remove
guards, safety devices and caution labels. If this must be done (for example, for cleaning or
repair), make sure that no one can use the machine.

Modifications to the machine carried out by the user must be considered their sole
responsibility, therefore the manufacturer waives any and all responsibility for any
damage caused to persons and/or property resulting from maintenance performed
by unqualified personnel and in a manner unlike the operating procedures shown
below.

Page 5 of 36
MACHINES AND
ACCESSORIES

GRAPHIC REPRESENTATION OF SAFETY, OPERATIONAL AND RISK WARNINGS


The following boxes are designed to attract the attention of the reader / user for the proper
and safe use of the machine:
All rights are reserved of reproduction and dissemination of this Technical Manual and documentation cited and/or attached. It is expressly forbidden to reproduce, publish or distribute any information from this Manual. Copyright by FERVI

Pay attention
This highlights behavioural rules to prevent damage to the machine and/or the occurrence of
dangerous situations.

Residual Risks

om
This highlights the presence of dangers that cause residual risks to which the operator must
pay attention in order to avoid injury or damage to property.

1.1 Preface
For safe and easy operation of the Drill press, this manual must be read carefully in order to
acquire the necessary knowledge. In other words, durability and performance are strictly
dependent on how it is used.
i.c
Even if already familiar with the Drill press, it is necessary to follow the instructions
contained herein, in addition to the general precautions to be observed while working.
 Acquire full knowledge of the machine.
Read this manual carefully to understand: operation, safety devices and all necessary
precautions. All this is to allow safe use of the machine.
 Wear appropriate clothing for the job.
rv

The operator must wear appropriate clothing, so as to prevent the occurrence of


unpleasant accidents.
 Maintain the machine with care.
fe

Machine operation
The machine must only be used by qualified personnel trained to use the machine by
authorized personnel.

Page 6 of 36
MACHINES AND
ACCESSORIES

2 SAFETY WARNINGS

2.1 General safety rules for machine tools

All rights are reserved of reproduction and dissemination of this Technical Manual and documentation cited and/or attached. It is expressly forbidden to reproduce, publish or distribute any information from this Manual. Copyright by FERVI
Risks related to Using the Machine
Do NOT underestimate the risks related to the use of the machine and stay focused on the
work you are carrying out.

om
Risks related to Using the Machine
Despite the implementation of all safety devices for safe use of the machine, it is necessary to
take note of all the accident prevention requirements highlighted in various parts of this
manual.

Risks related to Using the Machine


i.c
Every person who is responsible for the use and maintenance of the machine should first have
read the instruction manual, particularly the chapter dealing with safety.
It is recommended that the plant safety manager get written confirmation of the above.
rv

Risks related to Using the Machine


 During all work phases with the machine, you should proceed with great caution in
order to avoid damage to persons, to the property or to the machine itself.
 Please use the machine only for its expected uses (drilling or tapping).
fe

 Don't tamper with the safety devices equipping the machine.

Risks related to Using the Machine


Before starting any work on the machine, the operator must wear the appropriate personal
protective equipment (PPE) such as gloves and eye protection.

Page 7 of 36
MACHINES AND
ACCESSORIES

1. Always check the efficiency and integrity of the machine.


2. Before connecting the machine to the mains make sure that the switch is in the rest
position.
3. Do not start the machine in an enclosed or poorly ventilated area, or in the presence of
All rights are reserved of reproduction and dissemination of this Technical Manual and documentation cited and/or attached. It is expressly forbidden to reproduce, publish or distribute any information from this Manual. Copyright by FERVI

a flammable and/or explosive atmosphere. Do not use the machine in damp and/or wet
locations, or those exposed to rain or humidity.
4. Avoid starting accidentally.
5. Before starting the machine, get used to ensuring that no remaining adjustment or
maintenance wrenches have remained inserted.
6. Keep the workplace tidy and free from hindrances; disorder causes accidents.
7. Make sure that the work environment is forbidden to children, non-employees and
animals.

om
8. Do not perform tasks on the machine other than those for which it was designed. Only
use the machine in the manner in which it was intended, as described in this instruction
manual.
9. Work without disturbances.
10.Work areas must be well lit.
11.Always wear eye protection and protective gloves while working. If dust is produced,
use the appropriate masks.
12.Wear appropriate clothing. Loose clothing, dangling jewellery, long hair, etc.., can get
caught in the moving parts, causing irreparable injury.
i.c
13.Replace worn and/or damaged parts, check that the guards and protection devices work
properly before operating. If necessary, have the machine checked by the service
support personnel. Use only original spare parts.
14.Cut the mains voltage supply to the machine when:
 the machine is not being operated;
 is left unattended;
rv

 you are performing maintenance or adjustment because the machine does not
work properly;
 the power cable is damaged;
 you are replacing its tool;
 in case the machine is being moved to another location;
fe

 you are cleaning the machine.


15.Do not use the machine in areas with a risk of fire and / or explosion.
16.It is recommended that users of this publication, for maintenance and repair, have a
basic knowledge of mechanical principles and of repair technique procedures.
17.Management in charge of safety is to make sure that the staff responsible for
using the machine has read and understood this manual in its entirety.
18.The company safety manager is responsible for monitoring the company's risk
status according to Legislative Decree no. 81/08.

Page 8 of 36
MACHINES AND
ACCESSORIES

2.2 Specific safety regulations for drills

Accident

All rights are reserved of reproduction and dissemination of this Technical Manual and documentation cited and/or attached. It is expressly forbidden to reproduce, publish or distribute any information from this Manual. Copyright by FERVI
 The operation of drilling or tapping always presents a risk of injury associated with the
possibility of accidental contact of parts of the body with the tool in motion, detachment
of splinters from the workpiece, tool breakage, or ejection of a badly blocked piece.
 There is no "intrinsic" means of safety, just as there is no worker who, while careful,
can "always" avoid an accident. Therefore, DO NOT underestimate the risks associated
with using the machine and concentrate on the work in progress.

om
1. Firmly secure the workpiece before starting the drill.
2. Always use the tool (tip or tap) in an appropriate manner. Perform only the work for
which the tool is made. Do not use the tool for inadequate work.
3. Only use suitable resistance tools in relation to the work that is to be done. This is to
avoid risky and unnecessary overloading for the operator, which may be harmful for the
life of the tools themselves.
4. Do not pick up moving tools or other moving parts. To stop the spindle on the machine,
i.c
always only use the stop command device.
5. 17. Do not remove the shavings from the table with hands, even at a standstill. To do
this, use tongs or a palette knife.
6. When the cutting tools need to be replaced or the speed needs to be changed, stop the
motor and wait for the spindle to stop.
7. Do not leave the machine until the spindle and the tool are completely stopped.
rv

8. After the work is completed, clean the tool and check its efficiency.
fe

Page 9 of 36
MACHINES AND
ACCESSORIES

2.3 Safety regulations regarding the electric system of machine-


tools
All rights are reserved of reproduction and dissemination of this Technical Manual and documentation cited and/or attached. It is expressly forbidden to reproduce, publish or distribute any information from this Manual. Copyright by FERVI

Risks related to Using the Machine


1. Do not modify the electrical system in any way. Any attempt in this regard may
jeopardize the operation of electrical devices, thus causing malfunction or accident.
2. Work carried out in the electrical system of the machine must, therefore, be carried out
only by qualified and authorized personnel.
3. If one hears unusual noises, or feels something strange, immediately stop the machine.
Then carry out an inspection and, if necessary, perform any repairs as required.

om
1. Ensure supply voltage complies with the label and technical specifications (230 V / 50
Hz).
2. It is necessary to use a device for the automatic interruption of the power supply in
case of failure, which is to be coordinated with the machine's electrical system. For
more detailed information, contact a trusted electrician.
i.c
3. The mains power outlet should be bipolar grounded (10/16 A, 250 V), extension cables
must have sections that are the same or greater than the sections of the power cable
of the machine.
4. The power supply cable (and its possible extension cable) should never come in contact
with hot objects, sharp edges, wet or oiled surfaces.
5. The power cord should be checked regularly and before each use to check for signs of
damage or wear. If these are not in good condition, replace the cable.
rv

6. Do not use the power cord to lift the machine or to remove the plug from the socket.

2.4 Technical support


For any problems or concerns, please contact, without hesitation the Customer Service
fe

Department of your dealer, who has competent and specialized staff, specific equipment and
spare parts.

2.5 Other provisions


IT IS FORBIDDEN TO TAMPER WITH SAFETY DEVICES
The first thing to do when starting work is to check for the presence and integrity of the
protections and the operation of the safety devices.

If any defect is encountered do not use the machine!

Even more so, it is strictly forbidden to modify or remove guards, safety devices,
labels and indication signs.

Page 10 of 36
MACHINES AND
ACCESSORIES

3 TECHNICAL SPECIFICATIONS

All rights are reserved of reproduction and dissemination of this Technical Manual and documentation cited and/or attached. It is expressly forbidden to reproduce, publish or distribute any information from this Manual. Copyright by FERVI
Height (mm) 990
dimensions
Overall

Width (mm) 290

Depth (mm) 560

Net mass (kg) 54


Mass

om
Gross mass (kg) 62

Rated voltage (V/Hz) 230/50.


Nominal
Values

Power (W) 650

Spindle travel (mm) 80


i.c
Spindle travel distance (mm) 160
General Characteristics

Sleeve (mm)  40

Spindle (mm)  16 CM2


rv

Column (mm)  71

Spindle-base distance (mm) 650

Speed (r/min) 280- 2380


fe

Table size (mm)  290

Acoustic emission (dB(A)) 60.1

Page 11 of 36
MACHINES AND
ACCESSORIES

4 ASSEMBLING THE MACHINE


All rights are reserved of reproduction and dissemination of this Technical Manual and documentation cited and/or attached. It is expressly forbidden to reproduce, publish or distribute any information from this Manual. Copyright by FERVI

Staff Required

The assembly must be carried out by at least two people.

4.1 Main Components


Make sure that the machine inside the packaging contains all the following parts:

om
i.c
rv
fe

Figure 1 - The parts of the machine

1 Head assembly 7 Spindle and key

2 Table 8 Spindle connector

3 Base 9 Lowering handwheel knobs

4 Pillar assembly 10 Screws

5 Table support assembly 11 Allen wrench

6 Handle 12 Wedge

Page 12 of 36
MACHINES AND
ACCESSORIES

4.2 Pillar and base assembly


1. Position the base on the floor or on a bench
2. Position the pillar on the base by aligning the holes of the

All rights are reserved of reproduction and dissemination of this Technical Manual and documentation cited and/or attached. It is expressly forbidden to reproduce, publish or distribute any information from this Manual. Copyright by FERVI
pillar with those of the base.
3. Search among the parts for the 4 long hex head screws for
mounting.
4. Insert the screws into the holes and tighten.

Figure 2 - Assembly of the

om
base

4.3 Installation of the table support and the rack


1. Remove the ring and the rack
2. Install the table support together
with the rack.
3. Install the ring and secure it
firmly with the supplied screw.
i.c
Figure 3 – Table support installation
rv

4.4 Installation of the handle and the table


1. Attach the handle with the screw provided.
2. Tighten the rear lever to lock the table support
3. Position the table on the support and tighten the locking lever.
fe

Figure 4 – Table installation

Page 13 of 36
MACHINES AND
ACCESSORIES

4.5 Installing the head assembly


1. Carefully raise the head assembly above the pillar and
position it on the top of the pillar itself.
2. Make sure that the head slides on the upper part of the
All rights are reserved of reproduction and dissemination of this Technical Manual and documentation cited and/or attached. It is expressly forbidden to reproduce, publish or distribute any information from this Manual. Copyright by FERVI

pillar along its full length.


3. Align the head with the base
4. Use the Allen wrench and tighten all the screws to lock
the head in position

om
Figure 5 – Head installation

4.6 Installation of the knobs


1. Locate the three handles inside the packaging.
2. Screw the handles into the threaded holes in the hub of the
handwheel and tighten firmly.
i.c
Figure 6 – Knob
installation
rv

4.7 Installing of the spindle

Mounting the spindle


fe

Before assembly of the spindle and the spindle connector, clean all connection surfaces with a
non-petroleum based cleaning product such as alcohol or thinner. The grease and oil used in
the packaging of the drill must be removed otherwise the spindle may loosen during
operation.

1. Open the spindle jaws by rotating the external part of the


spindle clockwise. To prevent any kind of damage, make
sure that the terminals are fully inserted into the spindle.
2. Press the spindle into its upper housing
3. Using a wooden mallet firmly push the spindle into the
upper housing to lock into place.

Figure 7 – Spindle
installation

Page 14 of 36
MACHINES AND
ACCESSORIES

4.8 Installing the spindle guard


To assemble the protective plexiglass to the rod, proceed as shown in the following figures:
1. Attach the mounting brackets to the rod and tighten the screws Figure 8/A;
2. Insert the plexiglass shield in the slots of the brackets and tighten the locking screw

All rights are reserved of reproduction and dissemination of this Technical Manual and documentation cited and/or attached. It is expressly forbidden to reproduce, publish or distribute any information from this Manual. Copyright by FERVI
Figure 8/B;

om
Figure 8 – Application of the brackets (A) – Insert the guard (B).

Assembling the Guard


i.c
The spindle guard must be mounted so that the stickers remain on the outside and are
readable, so that they can be seen properly by the operator while using the machine.

3. Place the rod inside the box


containing the safety micro switch;
4. Adjust the height and the opening
direction so that the upper
rv

projection of the rod fits perfectly


into the slot of the lid, when the
guard is closed.
fe

Figure 9 – Installation of the Rod Carrying the Guard.

5. Secure the support rod


carrying the guard to the
head of the drill;
6. The mechanical stop has
a fine adjustment to
better position it inside
the slot of the pulley
housing.

Figure 10 – Fitting and Adjusting the End of the Rod.

Page 15 of 36
All rights are reserved of reproduction and dissemination of this Technical Manual and documentation cited and/or attached. It is expressly forbidden to reproduce, publish or distribute any information from this Manual. Copyright by FERVI

5
4
3
2
1

Page 16 of 36
4
3
2
1

Controls

Drill base
Work table
Spindle protector
fe

Belts protective cover


5 MACHINE ELEMENTS

rv

9
8
7
6

10
Figure 11 – Overview.
i.c

Spindle
Electric motor

Table lever lock


8

9
7
6
5

10

Hand wheel spindle


om
Table adjustment handle
ACCESSORIES
MACHINES AND
All rights are reserved of reproduction and dissemination of this Technical Manual and documentation cited and/or attached. It is expressly forbidden to reproduce, publish or distribute any information from this Manual. Copyright by FERVI

Page 17 of 36
om
Figure 12 – Identification Plate.
i.c
The following plates are present on the machine:

rv
5.1 Information plate

fe
5.2 Pictograms
MACHINES AND
ACCESSORIES
MACHINES AND
ACCESSORIES

PLATE IN ITALIAN PLATE IN ENGLISH


All rights are reserved of reproduction and dissemination of this Technical Manual and documentation cited and/or attached. It is expressly forbidden to reproduce, publish or distribute any information from this Manual. Copyright by FERVI

ATTENZIONE ATTENTION
È VIETATO ESEGUIRE LAVORI SU IT IS PROHIBITED TO WORK ON LIVE ELECTRICAL
APPARECCHIATURE ELETTRICHE SOTTO EQUIPMENT
TENSIONE  ANY EXCEPTIONS MUST BE APPROVED BY THE HEAD
 EVENTUALI DEROGHE DEVONO ESSERE MANAGER
AUTORIZZATE DAL CAPO RESPONSABILE  UNDER PARTICULARLY DANGEROUS CONDITIONS,
 IN CONDIZIONI DI PARTICOLARE PERICOLO DEVE ANOTHER PERSON MUST BE PRESENT WHO IS NOT
ESSERE PRESENTE UN’ALTRA PERSONA OLTRE A CHI PERFORMING THE WORK
ESEGUE IL LAVORO ONLY BEGIN WORKING WHEN SAFETY MEASURES
INIZIARE I LAVORI SOLO AD AVVENUTA HAVE BEEN IMPLEMENTED
ATTAZIONE DELLE MISURE DI SICUREZZA In accordance with Legislative Decree 81/08 on accident
In ottemperanza al Dgs.81/08 relativo alla prevenzioni prevention
infortuni

ATTENZIONE ATTENTION

om
 -LEGGERE ATTENTAMENTE LE ISTRUZIONI  Read the instructions carefully before using the
PRIMA DI UTILIZZARE LA MACCHINA machine
 Per qualsiasi lavoro di regolazione o  Before carrying out any adjustment or
manutenzione, prima di intervenire sulla maintenance on the machine, detach its plug
macchina, togliere la spina dalla presa di from the power supply socket.
corrente.  Before operating, secure solidly to the table the
 Prima di operare, fissare saldamente alla tavola piece to be machined.
il pezzo da lavorare.  Keep hands away from the tool while in motion.
 Non avvicinare le mani all’utensile mentre è in  Before starting the machine make sure the
movimento. spindle locking key has been removed.
 Prima di avviare la macchina verificare che la  Always wear suitable goggles and protective
chiave di serraggio del mandrino sia stata gloves.
disinserita.  Do not wear loose clothing, ties, necklaces,
 Indossare sempre occhiali e guanti bracelets and tie up long hair because it could
i.c
antinfortunistici adeguati. catch on moving parts.
 Non indossare abiti ampi, cravatte, collane,  Do not remove or disable any safety devices.
bracciali e raccogliere i capelli lunghi perché  For further information on safety, please
potrebbero essere agganciati dalle parti in consult the instruction manual.
movimento.
 Non rimuovere o disattivare dispositivi di
sicurezza.
 Per altre indicazioni sulla sicurezza, si consiglia
la consultazione del manuale istruzioni.
rv

NON RIMUOVERE DO NOT REMOVE


I DISPOSITIVI DI SICUREZZA THE SAFETY DEVICES
E’ SEVERAMENTE VIETATA MALICIOUS OMISSION OR
LA RIMOZIONE E LA REMOVAL IS STRICTLY
OMISSIONE DOLOSA FORBIDDEN
fe

D.LGS. 81/08 LEGISLATIVE DECREE 81/08

ATTENZIONE! ATTENTION!

TOGLIERE LA BEFORE
CORRENTE OPENING THE
PRIMA DI SHIELD, CUT
APRIRE IL POWER
CARTER SUPPLY OFF.

Page 18 of 36
MACHINES AND
ACCESSORIES

6 SWITCHES AND CONTROL LEVERS

All rights are reserved of reproduction and dissemination of this Technical Manual and documentation cited and/or attached. It is expressly forbidden to reproduce, publish or distribute any information from this Manual. Copyright by FERVI
6.1 Control Buttons

A Start Button

om
B Stop button
B

Figure 13 – Control buttons.


i.c
START BUTTONS
To start the machine and the rotating tip, press the button on the
side.
rv

Figure 14 – Start.
STOP BUTTONS
To stop the machine and the rotating tip, press the button on the
fe

side.

Figure 15 – Stop.

Page 19 of 36
MACHINES AND
ACCESSORIES

EMERGENCY BUTTON
Before starting work, always make sure that the red safety cap is
always lowered. When pressure is applied, the stop button is
pressed and the machine stops.
All rights are reserved of reproduction and dissemination of this Technical Manual and documentation cited and/or attached. It is expressly forbidden to reproduce, publish or distribute any information from this Manual. Copyright by FERVI

Press this button in case of emergency.

om
F
igure 16 – Emergency.

Checking the Emergency Button


Before starting any work on the machine, the operator must ensure that the emergency stop
button functions.
i.c
In case of emergency
In an emergency, press the red emergency button to stop the machine.
rv

Risk of injury
After pressing the emergency shut down button, the spindle continues to rotate for a few
seconds, wait until it is completely stopped before you place your hands near the workpiece or
the tool.
fe

Page 20 of 36
MACHINES AND
ACCESSORIES

6.2 Control Levers


Handle 3 is used to adjust the height of the table. To adjust see chapter 8.1.
Handle 4, if rotated in a clockwise direction, locks the table; if the handle is rotated anti-

All rights are reserved of reproduction and dissemination of this Technical Manual and documentation cited and/or attached. It is expressly forbidden to reproduce, publish or distribute any information from this Manual. Copyright by FERVI
clockwise, the table is unlocked.

C Table height handle

D Table lock handle D

om Figure 17 – Activating the table.

The steering wheel allows for the vertical displacement of the spindle and, therefore, the
advancement of the tool needed for the machine to work.
i.c
rv
fe

Figure 18 – Activating the Spindle

Page 21 of 36
MACHINES AND
ACCESSORIES

7 OPERATION
The Drill Press is a very easy machine to use. It performs the function of making holes in
All rights are reserved of reproduction and dissemination of this Technical Manual and documentation cited and/or attached. It is expressly forbidden to reproduce, publish or distribute any information from this Manual. Copyright by FERVI

metal parts.

Machine operation
The Drill Press should only be used with tools for machining holes (drill bits, countersinks and
equivalents).

om
Risk of Crushing
Before using the machine, make sure that the base is fixed to the floor to prevent movement
or loss of stability.

The machine is used as follows:


1. Lift the work table to the desired height via the appropriate
i.c
handle;
2. The operating speed of the machine is changed via the
transmission belt;
3. Secure the workpiece on the table using a vice;
The vice must be firmly secured to the table by means of
bolts.
rv

Figure 19 –Using the vice.

Risk of injury
fe

The workpiece must be firmly fixed to the table (with the vice) while operating the machine.
Never is the workpiece to be held in place with one's hands.

4. Press the green button (A) to turn on the machine and rotate the spindle;
5. Lower the spindle with the wheel located on the right side of the drill;
When done, lift the spindle with the wheel and then turn the machine off with the red button
(B).

Risk of injury
After stopping the machine, the spindle continues to rotate for a few seconds, wait until it is
completely stopped before you place your hands near the workpiece or the tool.

Page 22 of 36
MACHINES AND
ACCESSORIES

7.1 Installation of the tip


1. Make sure the machine is turned off
2. Open the clamps (1) using the spindle key (2).

All rights are reserved of reproduction and dissemination of this Technical Manual and documentation cited and/or attached. It is expressly forbidden to reproduce, publish or distribute any information from this Manual. Copyright by FERVI
Turn the key anti-clockwise to open the spindle
clamps.
3. Insert the tip (3) into the spindle at a sufficient
depth to obtain maximum grip with the clamps
but not to a depth that causes the spiral portion
of the tip to come into contact with clamps.
4. Make sure that the tip is centred inside the
spindle.
5. Rotate the spindle key clockwise to tighten the

om
tip.

Figure 20 – Fastening the spindle.

Remove the adjustment wrenches


To avoid injury, make sure the spindle locking key has been removed before putting the
i.c
machine into operation. The key could be ejected at high speed.
rv
fe

Figure 21 – Fastening the spindle.

Page 23 of 36
MACHINES AND
ACCESSORIES

8 ADJUSTING THE MACHINE


All rights are reserved of reproduction and dissemination of this Technical Manual and documentation cited and/or attached. It is expressly forbidden to reproduce, publish or distribute any information from this Manual. Copyright by FERVI

8.1 Adjusting the table

Adjustment of the work table is only carried out vertically


through the following operations:
 Loosen the lever under the table (D);
 Raise the table by moving the handle (C) until the desired
height is reached;

om
 Tighten the knob positioned under the table (4).
Figure 22 – Adjusting the
table.

8.2 Adjusting the drilling depth


If you want to make more holes all at the same depth, taking the first hole as a reference:

 Loosen the locking screw and turn the scale until the
i.c
pointer indicates zero on the scale at the desired depth.
 Tighten the locking lever.

If you want to set the maximum descent depth of the sleeve at a


previously determined level:
 Loosen the locking screw and rotate the scale, while
touching the surface of the workpiece to be drilled, until
rv

the pointer indicates the number corresponding to the


desired drilling depth in millimetres
Figure 23 - Drilling depth
 Tighten the locking lever.
adjustment.
fe

8.3 Adjusting the Speed


To adjust the speed of the machine, proceed as follows:
 Loosen the handle on the engine mounting.

Figure 24 – Handle.

Page 24 of 36
MACHINES AND
ACCESSORIES

 Open the handle guard in order to unlock the protected


pulley housing.

All rights are reserved of reproduction and dissemination of this Technical Manual and documentation cited and/or attached. It is expressly forbidden to reproduce, publish or distribute any information from this Manual. Copyright by FERVI
Figure 25 – Pulley
compartment lock.

om
 Open the protective cover of the drive belt;
i.c
Figure 26 – Opening the
compartment.
 Set the drilling speed by selecting one of the five
positions of the belt;
rv
fe

Figure 27 – Pulley
compartment

Page 25 of 36
MACHINES AND
ACCESSORIES

For the selection of the spindle velocity refer to the following table

D 4
All rights are reserved of reproduction and dissemination of this Technical Manual and documentation cited and/or attached. It is expressly forbidden to reproduce, publish or distribute any information from this Manual. Copyright by FERVI

C 3
B 2
A 1
Spindle Motor

RPM @ 50Hz 1 2 3 4
A 620 440 280

om
B 1400 660 420
C 1830 1180 550
D 2380 1550 1150

 Adjust the belt tension by pushing the motor backwards;


 Tighten the handle securely and close the protective cover;
 To restart the drill, it is necessary to close the spindle guard, which locks the protective
cover on the pulley housing, and press the start button.
i.c
rv
fe

Page 26 of 36
MACHINES AND
ACCESSORIES

9 SAFETY DEVICES ON THE MACHINE

All rights are reserved of reproduction and dissemination of this Technical Manual and documentation cited and/or attached. It is expressly forbidden to reproduce, publish or distribute any information from this Manual. Copyright by FERVI
9.1 Grounding
In case of malfunction or breakdown, grounding provides a path of least resistance for the
electrical current that reduces the danger of electrical shock. The tool is equipped with a
power cord with ground conductor and plug. The plug must be plugged into an appropriate
outlet and installed on the ground according to the regulations.

Never change the plug provided for any reason. If it will not fit the outlet, entrust a
qualified electrician to install the proper outlet.

om
Electric Shock
Incorrectly connecting the conductor to the tool's grounding system can cause the risk of
electric shock.

If the electric cord or plug need to be repaired or replaced, do not connect the conductor to
i.c
tool's grounding system to a live terminal.
Connect the machine to a grounded electrical system and suitable device for the automatic
disconnection of the power supply.
If you do not understand the instructions for grounding or if you doubt the exact
grounding of the machine, check with a qualified electrician.
Repair or replace damaged or worn cords immediately.
Reconnection must take place in accordance with regulations.
rv

9.2 Safety devices


9.2.1 INTERLOCKING MOVEABLE GUARD
fe

This device prevents contact between the operator and the


moving spindle while the drill is operating.

Figure 28 – Spindle
guard.

Page 27 of 36
MACHINES AND
ACCESSORIES

9.2.2 PULLEY HOUSING LOCK


This device locks the opening of the pulley housing so that the
spindle guard stays closed and it is possible to start the drill.
All rights are reserved of reproduction and dissemination of this Technical Manual and documentation cited and/or attached. It is expressly forbidden to reproduce, publish or distribute any information from this Manual. Copyright by FERVI

Opening the housing is done via the safety micro switch, which
stops power to the Drill's motor.

Figure 29 – Locking the

om
pulley compartment.

Checking the Safety Devices


Each time the Drill is used, check that the devices function well; if they do not function, do not
use the machine.
i.c
Risk of injury
After opening the guard, the spindle continues to rotate for a few seconds, wait until it is
completely stopped before placing hands near the workpiece or the tool.
rv
fe

Page 28 of 36
MACHINES AND
ACCESSORIES

10 MAINTENANCE

All rights are reserved of reproduction and dissemination of this Technical Manual and documentation cited and/or attached. It is expressly forbidden to reproduce, publish or distribute any information from this Manual. Copyright by FERVI
10.1 Routine maintenance
With a compressor, routinely blow away the dust that accumulates inside the motor and the
pieces of metal remaining on the table and on the tip.

Worn power cable


Immediately replace the power cable when you notice that it is worn, cut or damaged.

om
Every 50 hours, or every 5 days, lubricate the gear mechanism, the rack that lifts the
table and the grooves of the spindle with oil.

Every 300 hours or every 6 months during the life of the machine, a thorough check of
operation, and wear and tear on the machine is to be carried out by a qualified technician.
i.c
Lubricate bearings 3 and 4 with oil.

Every 600 hours or every year during the life of the machine , lubricate bearings 1-2
by removing the pulley.
rv
fe

Spindle bearing

Page 29 of 36
MACHINES AND
ACCESSORIES

11 TROUBLESHOOTING
PROBLEM PROBABLE CAUSE SOLUTION
All rights are reserved of reproduction and dissemination of this Technical Manual and documentation cited and/or attached. It is expressly forbidden to reproduce, publish or distribute any information from this Manual. Copyright by FERVI

Noisy A) Incorrect belt tension. A) Adjust the tension.


operation. B) Dry spindle. B) Remove the spindle sleeve and
C) Loose Pulley. lubricate.
D) Loose belt. C) Tighten the pulley.
E) Broken bearing. D) Adjust the belt tension.
E) Replace the bearing
Excessive A) Loose spindle. A) Tighten the spindle shaft.
wobbling of the B) Worn spindle shaft or bearings. B) Replace the spindle shaft or
spindle. C) Broken spindle. bearings.

om
C) Replace the spindle.
The motor will A) Electrical power supply. A) Check the mains power supply.
not start. B) Motor connection. B) Check the motor connection.
C) Switch connections. C) Check the switch connections
D) Burnt motor windings. D) Replace the motor.
E) Broken switch. E) Replace the switch.
The tip is A) Excessive forward pressure on A) Apply less pressure.
jammed in the the handle. B) Check the belt tension.
workpiece. B) Loose belt. C) Tighten the tip.
i.c
C) Loose tip. D) Change the speed.
D) Speed is too fast.
The tip is A) Incorrect speed. Revolutions A) See table speed.
burning or per minute. B) Clean the tip.
smoking. B) Shavings will not discharge. C) Check the sharpness and taper.
C) Tip is worn or does not cut the D) Lubricate while drilling.
rv

material well. E) Apply less pressure.


D) Needs lubrication.
E) Incorrect feeding pressure.
Raising the A) Needs lubrication. A) Lubricate with light oil.
table is B) Bent rack. B) Straighten the rack.
difficult. C) The table is clamped into C) Loosen the clamp.
fe

position.
The tip A) Knot in the wood, the tip A) Sharpen the tip correctly.
vibrates, the was sharpened off-center. B) Replace the tip.
hole is not B) Wrong tip.
round.
The spindle will A) Dirt, grease or oil in the A) Use detergents (alcohol, etc.) to
not stick to the morse taper. clean the conical part of the drill and
sleeve. B) Running in an unauthorized the spindle.
mode. B) Drilling causes the failure.

Page 30 of 36
MACHINES AND
ACCESSORIES

12 ELECTRICAL CIRCUIT

All rights are reserved of reproduction and dissemination of this Technical Manual and documentation cited and/or attached. It is expressly forbidden to reproduce, publish or distribute any information from this Manual. Copyright by FERVI
om
i.c
13 DISPOSAL OF PARTS AND MATERIALS
rv

If the machine is to be scrapped, its parts must be disposed of differently.


The Drill press is composed of the following materials:
 the head, column, table and base are made of cast iron;
 gears, shafts, bearings, slideways and spindle are made of steel;
fe

 the guard and cable sheaths are made of polymeric material.

Respect the environment!

Contact a specialist center for the collection of materials.

Page 31 of 36
All rights are reserved of reproduction and dissemination of this Technical Manual and documentation cited and/or attached. It is expressly forbidden to reproduce, publish or distribute any information from this Manual. Copyright by FERVI

Page 32 of 36
14 SPARE PARTS
fe
rv
i.c
om
ACCESSORIES
MACHINES AND
MACHINES AND
ACCESSORIES

Ref. Description Ref. Description


0012/001 Retainer ring 0012/040 Pin
0012/002 Grooved shaft 0012/041 Bolt

All rights are reserved of reproduction and dissemination of this Technical Manual and documentation cited and/or attached. It is expressly forbidden to reproduce, publish or distribute any information from this Manual. Copyright by FERVI
0012/003 Retainer ring 0012/042 Retainer ring
0012/004 Bearing 0012/043 Lifting lever
0012/005 Retainer ring 0012/044 Nut
0012/006 Shaft pulley 0012/045 Spring seat
0012/007 Bolt 0012/046 Spring
0012/008 Belt 0012/047 Nut
0012/009 Bearing 0012/048 Bolt

om
0012/010 Belt 0012/049 Bolt
0012/011 Small pulley 0012/050 Switch
0012/012 Bolt 0012/051 Switch box
0012/013 Pulley 0012/052 Washer
0012/014 Shaft 0012/053 Locking washer
0012/015 Rivet 0012/054 Bolt
0012/016 Flat washer 0012/055 Bolt
i.c
0012/017 Washer 0012/056 Warning label
0012/018 Bolt 0012/057 Switch
0012/019 Bolt 0012/058 Rivet
0012/020 Flat washer 0012/059 Bolt
0012/021 Speed label 0012/060 O-ring
0012/022 Pulley compartment cover 0012/061 Retainer ring
rv

0012/023 Washer 0012/062 Bearing


0012/024 Flat washer 0012/063 Sleeve coupling
0012/025 Locking washer 0012/064 Spindle removal wedge
0012/026 Nut 0012/065 Bearing
fe

0012/027 Flat washer 0012/066 Shaft


0012/028 Nut 0012/067 Shaft
0012/029 Motor 0012/068 Spindle
0012/030 Connecting plate 0012/069 Base
0012/031 Flat washer 0012/070 Flange
0012/032 Adjustment shaft 0012/071 Bolt
0012/033 Bolt 0012/072 Locking washer
0012/034 Adjustment shaft 0012/073 Bolt
0012/035 Bolt 0012/074 Rivet
0012/036 Lifting lever 0012/075 Rack
0012/037 Pin 0012/076 Adjustment handle
0012/038 Head 0012/077 Bolt
0012/039 Bolt 0012/078 Retainer ring
0012/079 Sprocket 0012/091 Bolt
Page 33 of 36
MACHINES AND
ACCESSORIES

Ref. Description Ref. Description


0012/080 Shaft 0012/092 Table holding unit
0012/081 Table adjustment lever 0012/093 Lever knob
All rights are reserved of reproduction and dissemination of this Technical Manual and documentation cited and/or attached. It is expressly forbidden to reproduce, publish or distribute any information from this Manual. Copyright by FERVI

0012/082 Table vice 0012/094 Spindle lever


0012/083 Graduated scale 0012/095 Lever housing
0012/084 Rivet 0012/096 Shaft
0012/085 Table inclination scale 0012/097 Pin
0012/086 Table 0012/099 End feed ring
0012/087 Rivet 0012/100 Rivet
0012/088 Table lift locking lever 0012/101 Normal feed scale

om
0012/089 Worm 0012/105 Bolt
0012/090 O-ring i.c
rv
fe

Page 34 of 36
MACHINES AND
ACCESSORIES

All rights are reserved of reproduction and dissemination of this Technical Manual and documentation cited and/or attached. It is expressly forbidden to reproduce, publish or distribute any information from this Manual. Copyright by FERVI
om
i.c
Ref. Description Ref. Description
0012/A01 Spindle guard 0012/A19 Upper plate
rv

0012/A02 Bolt 0012/A20 Screw


0012/A03 Washer 0012/A21 Motor power supply cable
0012/A04 Clamp guard 0012/A22 Power supply cable
0012/A05 Washer 0012/A23 Grommet
fe

0012/A06 Nut 0012/A24 Fixed casing seat


0012/A07 Cap 0012/A25 Flat washer
0012/A08 Bolt 0012/A26 Locking washer
0012/A09 Electrical parts box 0012/A27 Screw
0012/A10 Cable gland 0012/A28 Screw
0012/A11 Micro switch power supply cable 0012/A29 Screw
0012/A12 Guard rod 0012/A30 Washer
0012/A13 Grub screw 0012/A31 Micro switch
0012/A14 Screw 0012/A32 Nut
0012/A15 Bolt 0012/A33 Nut
0012/A16 Plain bearing 0012/A34 Mounting plate
0012/A17 Guard locking bracket 0012/A35 Screw
0012/A18 Screw 0012/A36 Grommet

Page 35 of 36
MACHINES AND
ACCESSORIES

15 DRILL PRESS ACCESSORIES


ACCESSORIES (in a separate box) PARTS/GROUPS
All rights are reserved of reproduction and dissemination of this Technical Manual and documentation cited and/or attached. It is expressly forbidden to reproduce, publish or distribute any information from this Manual. Copyright by FERVI

1 Chuck key (see figure below) 1 Group


2 Wedge shaft 1 Group
3 Feeding knobs 3 Parts
4 Regulating know for support table height 1 Group
5 Table support mounting bolt 1 Part
6 Table arm mounting bolt 1 Part
7 Upper pulley cover knob and screw 1 Group

om
8 Flange screws and washers 1 Group
9 Allen wrenches 1 Group
i.c
rv
fe

Page 36 of 36

You might also like