Professional Documents
Culture Documents
Data recovery Software used for different problems (Deleted partition recovery, Formatted data recovery, MBR
repair, Deleted files recovery, Different software used idea)
Pen drive and Memory card logically data recovery concept
Practical used of data recovery software with problems
o Partition recovery
o MBR deleted recovery
o File deleted recovery
Introduction to HARD DISK PCB, block diagram section of hard disk, Power Connection
Different power required in pcb
Power & protection section (TVS diode, fuse, coil , 0ohms transistor, Mosfet, other smd component working and
power detail in hard disk)
DC to DC converter (switching section, linear section, 1.5, 2.5, 3.3v supply)
MCU section, Data section (chip working concept power main signals)
Buffer Ram, flash ROM section (working concept types and main signals)
VCM Motor controller & read channel chip (working concept and main signals)
Head , Voice coil, pre amp section head
Live PCB tracing (different volt of pcb, fault finding of hard disk pcb Online offline)
Identify problem (shorting, open pcb, motor not get power, switching section not work)
Identify hard disk pcb no for donor pcb (matching criteria Samsung, Seagate, wd, Hitachi, Ibm, Maxtor)
Points to Notes when replacing PCB from patient to donour
Replacing component and IC`s of hard disk (demo video) (understand different hard disk pcb, circuit
troubleshooting chart)
Websites Links for purchasing donour pcb
Mechanical Failure Problems (click voice, head stuck, spindle jam, scratch voice, water damage, filter damage,
voice coil)
Introduction about storage of data on platter (head, preamp, voice, coil, platter, spindle)
Platter surface layers (lubricant, carbon, magnetic, aluminum)
Introduction to data recovery tools (Low end, medium end, high end, very high)
Explaining Different head voice coming from hard disk (11,7,5,3 clicking, scratch, high voice etc)
Donor Selection of Different Hard Disk for patient (head, Magnet, Spindle motor, pcb)
Matching criteria of donour hard disk (model no, MLC, firmware, made in, Site Code, Firmware code, Key
Maxtor)
Data recovery hard ware instrument detail and used detail with demo on opening hard disk (clean room, head
replacement, Head unstuck tools, spindle motor remover, magnet remove tools, clean cloth, hand gloves, cap,
etc)
Steps for opening hard disk, video, instruction (do’s, dont’s while opening, donor selection, used of instruments)
Inspection of patient hard disk before replacing parts (already opened, or seal pack, scratch on platter, condition
of head, all head is present, filter condition, preamp, dust inside, head is on parking area, head unlock from
parking, no scratch below platter on other heads
Steps for remove each platter and inspect surface, no scratch, before donour used
Practice on removing magnet & head replacement of hard disk (without and with tools)
Practice on platter replacement of hard disk (single platter, double platter)
Practice on spindle motor / body changing of hard disk (swapping case with spindle motor)
Basic Idea about how to unstuck head from platter
Idea about how to Unstuck spindle motor
After replacing head from donour to patient firmware work
TEST :- Practical on working hard disk opening removing head of ok detect hard disk in clean room
Basic idea of data recovery from pen drive, memory card, flashcard
Data recovery common problems and solution step Chart for hard disk repair
Basic Introduction to hard disk firmware updating and high end instruments idea
Seagate hard disk connection with Seagate tools (usb to rs232 converter, rx tx gnd connection, types of Seagate
hard disk, F3 and old hard disk)
Seagate common terminal commands idea Prompt T> F3 T> (Command /T /1/2/3/4/5/6…)
introduction and used of Seagate firmware repair tools Terminal command for (smart reset, clear plist, clear
glist, repair, module update, format, service area, regenerator)
WD hard disk firmware repair tools used (clear smart, clear plist, clear glist, format, clear regenerator, module
check, etc)
WD rom and module, IDR basic idea
Practical using firmware software and terminal command
High end device idea
Connection and used of MRT data recovery device
Data extractor used and setting
How to copy disk to disk or copy selected files from data extractor
Seagate hdd basic & families (types of hard disk F3, old classic, families name, model identify)
Seagate hard disk pcb no equivalent model
Seagate hard disk common problem due to firmware (error, busy, 500E, 3.86)
Working and booting idea of hard disk firmware files (rom, ldr, module, cp, system files, id, track)
Seagate ROM files (RAP, SAP CAP)
Seagate modules list, important module (Module 00, 03, 1D/1E/1F, 2B, 32A 35)
Seagate system files, important sys files (1Bh, 28h, 35h, 93h, 20h)
Seagate cp files, important files
Calculate Sector size of Seagate hard disk
Seagate pcb types and shorting read channel
How to find short pin of Seagate hard disk
Hot swapping concept of PCB
Terminal connection
Seagate hard disk connection, usb ttl dongle, software
Seagate hard disk connect with MRT terminal
Seagate common Terminal Diagnostic commands Level
Defect list view edit clear (plist, glist, tlist, nrglist)
Smart, View, Clear Reset
Seagate head (testing, smash, bad head, depop, cut head, RAP edit)
Seagate hard disk zone idea (view, test, check, cut bad zone, repair zone)
Seagate motor stop, start
Translator regenerator, m commands,
Formatting command
Zone disable
Seagate common problem solution Busy error, SMP error, no model, wrong model, sim error, servo error, read
write error, LED error, undetected etc
Modules, system files, cp files, backup, restore
Virtual Repair
Boot mode of hard disk
Identify hard disk model no, families, pcb no, parts, DCM no
Chart of Wd hard disk families with micro code, and models,
Hard disk board types, Pcb no, chip detail, MCU buffer, ROM, VCM
USB hard disk to sata conversion detail, jumper
Booting process, Bios ROM, RAM, SA, MBR, MFT, boot sector, NTFS
Common problem due to firmware corruption
Basic idea of tools used for repair WD hard disk firmware
Wd marvel and MRT tools basic used, read ROM and module
SA Module Structure and Analysis Types of module (main, data, management, defect list backup modules)
Dir Module 01 Configuration Module 02 Zone Map 03, 04 analysis.
Overlays module 11 , 5c, 13, 10
ATA Modules.
Load Overly to RAM
Choose correct overlay with compare ROM files.
Defect list modules plist, glist, tlist
Defect module P-list 33. P-list Translator 31.
G-list 34. G-list translator 32. SA Defect list 35.
SA Translator (in Rom) 30. Track Defect List (T-list) 36.
Adaptive module analysis.
Modules 40, 41. Module 49,4a.
SF Logs modules Exx in details.
Arco Log modules 20XX in details.
Key modules for data recovery
Common fault due to ROM & SA modules
Key module for data backup old I series and new royal series
Read, write, repair, editing modules of wd hard disks
Micro code firmware versions
1. For admission the student has to pay 50% amount in advance and the remaining amount has to be paid on the
first day of training. (Bank details will be sent by email or text)
2. After receiving of 50% payment, we will send you online study material for that particular course, students
have to study online notes then come for offline class.
3. At least 2 or 3 participants have met, Only then will training be given. Otherwise the training will be canceled.
4. NO RESERVATION, NO TRAINING SLOT
5. Students have to bring their ID proof and passport size photo with them, And must be submitted for the first
day of admission..
6. Hostel/hotels/ paying guest can be arrange on request of students
OPP.DELHI GATE POLIC, E CHOWKY, NR.BUS STAND & RAILWAY STATION, SURAT
Tel : 0261-3209777 , 0261- 2490201
4 HOTEL DECENT Decent 700/- 800/-
(2 km from institute) Super Deluxe 500/- 600/-
Deluxe 450/- 550/-
Economic 400/- 500/-
ABOWATH COMPLEX NO. 2, FIRST FLOOR, CINEMA ROAD, OPP. KRISHNA CINEMA,
SURAT. TEL : 0261-2413871, 2452595
5 HOTEL TIRUPATI OPP. RAILWAY STATION, SURAT
RESIDENCY Tel : 0261-2402880
(near institute)
6 PAYING GUEST ARFEESS RESIDENCY, NEAR COUNTRY CLUB,
(3 to 4 km from OPP.HARI CHAMPA, BADRI NARAYAN
institute) MANDIR ROAD, NEAR BAPS HOSPITAL,
ADAJAN-SURAT. MOB.+91-9909963963
https://www.youtube.com/playlist?list=PLZLbhrWE--cMv3rbC_ilOvQKrCDfl4Rdc
Our Ex-Studetns