‘ALLISON 1000 AND 2000 PRODUCT FAMILIES ELECTRONIC CONTROLS TROUBLESHOOTING MANUAL
DIAGNOSTIC TROUBLE CODES (DTC)
DTC P0563 System Voltage High
J1 HARNESS. CONNECTOR
(GRAY) Tom
‘enon
POWER
BATTERY
POWER TOM
no
ono
12V/24V
BATTERY
Circuit Description
‘The Transmission Control Module (TCM) requires a switched ignition voltage input to operate, This switched
ignition voltage signal originates from the ignition switch or an ignition relay to supply voltage to pins 102 and 104 in
the J1 connector at the TCM,
Conditions for Running the DTC
+ The engine speed is greater than 450 rpm for one second.
+ The components are powered and ignition voltage is greater than 9V and less than 18V (12V TCM) or greater
than 18V and less than 32V (24V TCM).
Conditions for Setting the DTC
DTC P0863 sets when the TCM detects the following condition:
+ 12 volt TEM — Ignition voltage is above 18V for 6 out of 10 seconds.
+ 24 volt TOM — Ignition voltage is above 32V for 6 out of 10 seconds.
5-34 Copyright® 2004 General Motors Corp.