Professional Documents
Culture Documents
GV300W Quick Start
GV300W Quick Start
in k
l
Install the battery Close the case Switch ON Battery
l
Install SIM Card
e c t i a
Driver Installation
u
Q fide n
64-bit systems must have test certificate installed first. See section below
“On 64-bit Windows systems” before attempting to install.
In this case, open the device manager and manually install a
driver for each device instance by right clicking on each device
with the yellow warning icon and selecting “Update Driver Soft-
ware…”.
n
Manual Installation: follow the procedure documented in ReadMe.rtf,
point the driver to the Queclink_WCDMA_USBDriver_V1.01 path (Win7
o
\Win8\XP-Vista) when system asks for driver files.
Windows 7 might not prompt for the driver installation when a USB device
is plugged in.
C
Next select “Browse my computer for driver software”
Finally, select the path to the drivers for the
intended operating system:
To mini USB
To computer
in k
cl i al
u e n t
Before using GV300W for the first
time , please fully charge the battery.
Q fide
on
C
Please refer to Page 3 for details.
Page 3 : PC Manager Tool Quick Start
Run the Manage Tool. Select correct Com port and If you want to test GV300W by SMS, then set “Report
input default password “gv300W”. Then press OK. Mode” to “SMS” and input the phone number in-
tended to receive the SMS from GV300W. After that,
you can go to Step 6.
Otherwise, please go to Step 3.
k
Please contact your SIM card provider and get the APN
Set “Report Mode” to “TCP Short Connection”. Input the IP
n
information for WCDMA. Input it in GTBSI setting.
address and port number of the backend server. Please
i
make sure the IP address can be accessed by internet and
l l
the data sent to this address can be received.
e c t i a
u
Q fide n
Press the “Send” button and update the parameters of Set the parameters of fixed time report so that GV300W
n
GV300W. Then GV300W can report information to your will report its position to backend server periodically.
backend server or SMS receiver. Press “Send” button to update the parameters.
o
Note: These commands can also be sent to GV300W by The following screenshot shows how to configure GV300W
SMS. to report its position every 3 minutes.
C
Command has been accepted when you see the window below.
http://www.queclink.com
sales@queclink.com Queclink
Grace Wang Checked
2018.08.16