Professional Documents
Culture Documents
SEARCH …
Jinlang TOYOTA 2E
Like Page
Rato
SPONSORED LINKS
AUTOMOBILE
ENGINES The
Toyo TOYOTA ENGINES
BMW ta
2E is
Chevrolet
a 1.3
Chrysler l
(1,29
Cummins
6 cc,
Ford 79.0
General Motors 9 Toyota 5A-FE
cu·in
Honda )
Mazda straight-four 4-stroke natural aspirated gasoline
engine from Toyota E-family. The 2E engine was
Mitsubishi manufactured from 1985 to 1998.
Nissan
The 2E engine features a cast-iron block and
Opel aluminum cylinder head with the single overhead
camshaft (SOHC) and three valves per cylinder (12 in Toyota 3C-TE
Prince
total).
Renault
Compression ratio rating is 9.5:1. It has a 73.0 mm
Subaru
(2.87 in) cylinder bore and 77.4 mm (3.05 in) piston
Suzuki stroke.
Toyota
The engine was available in the following versions:
Mitsubishi
GENERAL INFORMATION COMMENTS
CYLINDER BLOCK
The Toyota 2E has a cast-iron cylinder block with five
bearing support system. It has a 73.0 mm (2.87 in)
cylinder bore and 77.4 mm (3.05 in) piston stroke.
Compression ratio rating is 9.5:1.
Cylinder block
Cylinder block alloy Cast-iron
Compression ratio: 9.5:1
Cylinder bore: 73.0 mm (2.87 in)
Piston stroke: 77.4 mm (3.05 in)
Number of piston rings 2/1
(compression / oil):
Number of main bearings: 5
This website uses cookies to improve your experience. We'll assume you're ok with
Cylinder inner diameter 73.000 mm (2.874
this, but you can opt-out if you wish.
(standard): Cookie settings
in) ACCEPT
Piston skirt diameter 72.910-72.940 mm
(standard): (2.8705-2.8716 in)
Piston pin outer diameter: –
Piston ring side Top 0.040-0.080 mm
clearance: (0.0016-0.0031 in)
Second 0.030-0.070 mm
(0.0012-0.0028 in)
Piston ring end Top 0.260-0.490 mm
gap: (0.0102-0.0193 in)
Second 0.150-0.430 mm
(0.0059-0.0169 in)
Oil 0.200-0.830 mm
(0.0079-0.0327 in)
Crankshaft journal 47.000 mm (1.8504
diameter: in)
Crankpin diameter: 40.000 mm (1.5748
in)
CYLINDER HEAD
The cylinder head is made of aluminum alloy which
gives it good cooling efficiency. The engine has single
overhead camshaft, that is driven by a timing belt and
three valves per cylinder (12 valves in total). The 2E
engine used special valve shims to adjust the valve
clearance.
Cylinder head
Valve Arrangement: SOHC, belt drive
Valves: 12 (3 valves per
cylinder)
Valve head INTAKE –
diameter: EXHAUST –
Valve length: INTAKE 92.26 mm (3.6323 in)
(First)
INTAKE 98.50 mm (3.8779 in)
(Second)
EXHAUST 92.26 mm (3.6323 in)
Valve stem INTAKE 5.970-5.985 mm
diameter: (0.2350-0.2356 in)
EXHAUST 5.965-5.980 mm
This website uses cookies to improve your experience. We'll assume you're ok with
(0.2348-0.2354 in.)
this, but you canspring
Valve opt-out
freeiflength:
you wish. 41.52
Cookie
mmsettings
(1.6346 in) ACCEPT
Camshaft INTAKE 35.87-35.97 mm
cam height: (First) (1.4122-1.4161 in)
INTAKE 35.38-35.48 mm
(Second) (1.3929-1.3968 in)
EXHAUST 35.83-35.93 mm
(1.4106-1.4146 in)
Outer camshaft journal 26.979-26.995 mm
diameter: (1.0622-1.0628 in)
MAINTENANCE DATA
Valve clearance
Intake valve 0.20 mm (0.008 in)
Exhaust valve 0.20 mm (0.08 in)
Compression pressure
Standard 13.0 kg/m2 / 200 rpm
Minimun 10.0 kg/m2 / 200 rpm
Compression differential 1.0 kg/m2 / 200 rpm
limit between cylinders
Oil system
Oil consumption , L/1000 up to 0.5 (1 qt. per
km (qt. per miles) 1200 miles)
Recommended engine oil 5W-20, 5W-30, 10W-
30
Oil type API SE, SF or SG
Engine oil capacity (Refill With filter change 3.2
capacity) ll
Without filter change
2.9 l
Oil change interval, km 10,000 (6,000)
(miles)
Ignition system
Spark plug NGK: BPR6EY-11
DENSO: W20EXR-
U11
Spark plug gap 0.8 mm (0.031 in) or
1.1 mm (0.043 in)
VEHICLE APPLICATIONS
Model Years
Produced
Toyota Corolla (AE92, AE111) – –
South Africa
Toyota Corolla (EE90, EE96, EE97, –
This website uses cookies to improve your experience. We'll assume you're ok with
EE100)
this, but you canSprinter
Toyota opt-out(EE90,
if youEE96,
wish.EE97,Cookie settings
– ACCEPT
EE100)
Toyota Starlet (EP71, EP81, EP82, –
EP90)
Toyota Starlet Van (EP76V) –
Toyota Corsa –
Toyota Conquest (South Africa) –
Toyota Tazz (South Africa) –
Toyota Tercel (Caribbean / South –
America)
26 COMMENTS
Mehdi says:
MARCH 25, 2019 AT 7:27 PM
Hi dear all
Is 20W50 a suitable oil for 2E engine in meadle east
(Iran Tehran) or not?
Thanks so much.
REPLY
Admin says:
MARCH 26, 2019 AT 6:21 AM
REPLY
Ramy says:
AUGUST 26, 2019 AT 7:46 PM
In catalog writing the oil with filter 2,8 and with filter
2,6 without here wrote 3,2 with change filter 2,9
without who is right
REPLY
Admin says:
AUGUST 27, 2019 AT 2:57 AM
REPLY
REPLY
nasir says:
SEPTEMBER 18, 2019 AT 9:46 AM
Hi,
Would any body like to tell about the
primary,secondary and power jet size in toyota corolla
1988 12 valve 2e engine.
Thanks
Regards
REPLY
nasir says:
SEPTEMBER 18, 2019 AT 9:47 AM
Hi Nasir
REPLY
https://www.toyota.com/owners/resources/
warranty-owners-manuals/corolla/1999
Ahmed Leila
REPLY
yuri says:
OCTOBER 14, 2019 AT 12:26 PM
REPLY
awang says:
DECEMBER 29, 2019 AT 12:49 PM
REPLY
awang says:
DECEMBER 29, 2019 AT 1:10 PM
admin.
This website uses tumpang
cookies tanya masalah
to improve enjin saya.We'll
your experience. tidakassume you're ok with
boleh rem lebih dari 4000rpm. ada solusi untuk
this, butmengatasi
you can opt-out
nya?
if you wish. Cookie settings ACCEPT
REPLY
Riley says:
JANUARY 3, 2020 AT 3:13 AM
Hi. Please may I know the sizes of the drive belts for
the 2e 1.3 corolla engine? Thanks a lot
REPLY
REPLY
gary says:
APRIL 19, 2020 AT 12:21 PM
REPLY
REPLY
Hi
This website uses cookies to improve your experience. We'll assume you're ok with
Is there a torque setting for the bolts that locate the
this, butcamshaft.
you can opt-out if you wish. Cookie settings ACCEPT
REPLY
Piet says:
MAY 19, 2020 AT 5:57 AM
REPLY
REPLY
Suranga says:
OCTOBER 7, 2020 AT 2:08 PM
REPLY
sidwel says:
NOVEMBER 5, 2020 AT 12:53 PM
REPLY
Kevin says:
DECEMBER 16, 2020 AT 11:07 PM
REPLY
This website uses cookies to improve your experience. We'll assume you're ok with
Hi everyone…plse help me am looking for a
this, butcarburator
you can opt-out if you wish.
2e manual,am Cookie
based in settings
zambia…kindly ACCEPT
send me where I can access the item…will appreciate
REPLY
ver says:
APRIL 19, 2021 AT 11:23 AM
REPLY
REPLY
Leave a Reply
Your email address will not be published.
Comment
Name *
Email *
Website
POST COMMENT
© 2016-2022 ENGINE-SPECS.NET
This website uses cookies to improve your experience. We'll assume you're ok with
this, but you can opt-out if you wish. Cookie settings ACCEPT