Professional Documents
Culture Documents
Section 3E
CONTENTS
PAGES
MAIN DATA AND SPECIFICATION ……………………………………………………………….3E-2
TORQUE SPECIFICATION…………………………………………………………………………..3E-3
SPECIAL PART FIXING NUT AND BOLT………………………………………………………….3E-3
WHEELS AND TIRES………………………………………………………………………………..3E-4
SUMMRIZE…………………………………………………………………………………………..3E-4
MAINTENANCE……………………………………………………………………………………...3E-8
DISASSEMBLY……………………………………………………………………………………….3E-9
INSPECT AND REPAIR……………………………………………………………………………….3E-10
REASSEMBLY…………………………………………………………………………………………3E-11
TROUBLESHOOTING…………………………………………………………………………………3E-12
Wheels and tires 3E- 2
2WD
Front tire Rear tire
Tire size Wheel size Tire pressure (Kpa) Tire size Wheel size Tire pressure (Kpa)
4WD
TORQUE SPECIFICATION
Wheels and tires 3E- 3
TIRE IDENTIFICATION
LT 215 / 75 R 15- 6PR
Layer of wire gaze
Wheel rim diameter
Wheels and tires 3E- 7
Radiation structure
Diameter ratio
Width of the rated section(mm)
Cargon
185 R 14 - 8PR
205 / 70 R 14
Notice:Tire air pressure should accord with nameplate on door of cab and door frame of cab.
Air pressure of tire is too high,so tire would burst and operation would reverse.
Air pressure of tire is too low,so tire would burst and fall adhension factor.
MAINTENANCE
You can maintain it according to the greneral maintain processes.
Wheels and tires 3E- 8
Exchange tire
If the size of the front tire is different from others ,you can
exchange the two front tires each other and take place of among
the back tires under indirection of the picture.
If the size of the front and back tires are in accord ,you can
exchange the tires under indirection of the right picture.
Wheels and tires 3E- 9
Removal steps
(4X2Model) (4X4Model)
1. wheel cover 1a.wheel nut
2. wheel nut 2a.wheel cover
3. wheel and tire assembly 3a.wheel and
tire assembly
4. tire assembly 4a.tire assembly
Reassembly steps
(4X2Model) (4X4Model)
1. tire assembly 1a.tire assembly
2. wheel and tire assembly 2a.wheel and tire assembly
3. tire nuts 3a.wheel cover
4. wheel cover 4a.wheel nuts
Wheels and tires 3E- 12
Important operation
1.1a .Tire assembly
Make the valves alignment the mark of tire balance(about
8mm diameter wheel)
TROUBLESHOOTING
Typical examples of abnormal tire tread and major causes:
CAUTION:Similar wear patterns can be caused by worn
suspension parts, misalignment or wheels and tires,
and other suspension related problems.
Wheels and tires 3E- 13
Wheels and tires 3E- 14
Wheels and tires 3E- 15