This document provides instructions for assembling single and double rear propeller shafts. For single shafts, it describes inserting the spline fork and shaft into the major shaft spline, attaching the wheel flange to the small gear position, and tightening bolts to the specified torque. For double shafts, it details mounting the first shaft and mid-bearing, attaching the mid-shaft bracket, connecting the second shaft, mid joint and small gear with aligned position marks, and tightening bolts to the specified torque. It also lists the transmission oil capacity.
This document provides instructions for assembling single and double rear propeller shafts. For single shafts, it describes inserting the spline fork and shaft into the major shaft spline, attaching the wheel flange to the small gear position, and tightening bolts to the specified torque. For double shafts, it details mounting the first shaft and mid-bearing, attaching the mid-shaft bracket, connecting the second shaft, mid joint and small gear with aligned position marks, and tightening bolts to the specified torque. It also lists the transmission oil capacity.
This document provides instructions for assembling single and double rear propeller shafts. For single shafts, it describes inserting the spline fork and shaft into the major shaft spline, attaching the wheel flange to the small gear position, and tightening bolts to the specified torque. For double shafts, it details mounting the first shaft and mid-bearing, attaching the mid-shaft bracket, connecting the second shaft, mid joint and small gear with aligned position marks, and tightening bolts to the specified torque. It also lists the transmission oil capacity.
1.Put spline(1) fork and propeller shaft into major shaft spline(2) 2.Put propeller shaft (3) wheel flange into major shaft small gear position 3.Tight propeller shaft bolts with regulated torque Bolt distance of wheel flange kg·m 3.6±0.3 Rear propeller shaft (double shafts) 1.Put mid-bearing and 1st propeller shaft on NO.3(beam) 2.Place spline fork(4) into major shaft(spline) (5). 3.Tight bolts of mid-shaft bracket(6) to regulated torque. Bolts torque of mid-bearing bracket kg·m 6.2±0.2
4.Connect 2nd propeller shaft(7),mid joint(8)and
driving small gear(9). Remember the position mark must be in alignment. 5.Tight connect bolts to regulated torque. Bolt torque of propeller shaft wheel flange kg·m 3.6±0.3
Shift gear lever
1.Add oil of prescriptive of hood in transmission Capacity of litre 1.55