V210 Pump P/V V211 Cooling Fan P/V V212 Flow Control P/V V213 Relief Pressure Up V214 Pilot Relay V215 Swing Priority S/V V216 Reverse Fan Speed S/V V217 Starter Relay V218 After Heat Relay V220 Front Pump Press Sensor V221 Rear Pump Press. Sensor V222 Hyd. Oil Temperature Sensor V223 Water Temperature Sensor V224 Engine Speed Sensor V225 Fuel Level Sensor V226 Alternator Potential V227 Dial V228 Accel. Pedal V229 Parking Brake Press. Sensor V230 E/g Control Motor Sensor V231 Accel. Pedal SW E011 Coolant temperature sensor E012 Fuel temperature sensor E013 Boost air temperature sensor E014 Boost air pressure sensor E017 E/G oil temperature sensor E018 E/G oil pressure sensor E021 Battery voltage E022 Fuel pressure sensor E032 Fuel pressure monitoring MPROP E037 CAN-B line E038 Engine overspeed E039 Main relay (SCG) E041 Redundant shutoff path E042 E/G speed (Crankshaft E043 E/G speed (Camshaft) E044 Engine speed sensor E045 EEPROM E046 Recovery E047 Monitoring of PRV E048 Power supply E049 Main relay SCB E051 Main relay ECU E058 Solenoid power stage 1 E059 Solenoid power stage 2 E061 Solenoid power stage 3 E062 Solenoid power stage 4 E063 Solenoid power stage 5 E064 Solenoid power stage 6 Fuel HI pressure pump (E/G: Current controlled Highside E065 power stage 1) E066 Preheat light (E/G:Lowside Power stage 2) E068 Preheat relay (E/G:Highside Power stage 1) E091 CAN-A line E097 Monitoring of misfire cylinder 1 E098 Monitoring of misfire cylinder 2 E099 Monitoring of misfire cylinder 3 E101 Monitoring of misfire cylinder 4 E102 Monitoring of misfire cylinder 5 E103 Monitoring of misfire cylinder 6 E104 Monitoring of misfire multiple cylinder E105 Monitoring of overrun E106 Engine speed redundant FMI FMI 0 Above normal range (DATA VALID but ABOVE 0 NORMAL OPERATIONAL RANGE) FMI Below normal range (DATA VALID but BELOW 1 NORMAL OPERATIONAL RANGE) FMI Incorrect signal (DATA ERRATIC, INTERMITTENT OR 2 INCORRECT) FMI Voltage above normal (VOLTAGE ABOVE NORMAL OR 3 SHORTED TO HIGH SOURCE) FMI Voltage below normal (VOLTAGE BELOW NORMAL OR 4 SHORTED TO LOW SOURCE) FMI Current below normal (CURRENT BELOW NORMAL 5 OR OPEN CIRCUIT) FMI Current above normal (CURRENT ABOVE NORMAL 6 OR GROUNDED CIRCUIT) FMI Abnormal signal (ABNORMAL FREQUENCY OR 8 PULSE WIDTH OR PERIOD) FMI Failure mode not identifiable (ROOT CAUSE NOT 11 KNOWN – Malfunction) FMI NOT AVAILABLE OR CONDITION EXISTS 31