Professional Documents
Culture Documents
Note: Please check rack post type. The rail 1) Remove the inner rail.
pre-installed type is for square hole post. If
➋
rack post is round hole post, please switch to Pull tab forward
and take out
the suitable screws. innerrail.
Remove A type screws(pre-installed) Pull ➌
and switch to B type screws.
inner rail
Ⓐ 9.5 Square Hole Ⓑ 7.1 Round Hole
(Pre-installed)
➊ Click!
2) Install the inner rail onto chassis. Detach Front Bracket from Rack Post
➋ ➋
➊
➍
➍ ➊
➊ ➌
➋
Release the latch to
detach the inner rail.
Click! M4x4
3) Fix the outer rail/bracket assembly to the frame. Detach Front Bracket from Rack Post
Note:
Front and rear bracket installation are the same.
L,R side of rail are symmetrical.
Please repeat installation step for the
other side.
➊ ➋ ➊ ➋
Click! Pull
4) Insert chassis to complete the installation. Detach Front Bracket from Rack Post
➊.Ensure ball bearing retainer is located at the front of the rail. ➊.Loosen shipping screw to pull out chassis.
➋.Insert the chassis into outer rails. ➋.Press the disconnect tab forward to remove chassis.
➌.When hit a stop , please pull / push the release tab on the inner rails. ➊
➍. ➎.Tighten chassis with shipping screws.
Click! locking
➊
➊
➊
➋ M5X13L ➎
➋
➊ ➎
➋
➋
➌ ➎ Pull
➍
➌
➌
➍
pull/push locking