Professional Documents
Culture Documents
The electric Energy required to raise the temperature of a given amount of water is 100kwh. If the heat
loses 25% , the total heating energy is___kwh
D. 1250
How many kw hours are consumed by 25 60 watt light bulbs burning 5 hours
D. 7.5
Four identical resistors are first connected in parallel and then in series. the resultant resistance of the
first combination to the second will be?
B. 1/16 times
Two identical resistor connected in parallel is 12 ohms are connected in a dc voltage source 24v with a
series of 6ohms, calculate the power consume of the 6ohm resistor.( Based ito sa pagkakaalala ko,
pakitama na lang po )
B. Rawl plug
Ans: a load where the maximum current is expected to continue for three hours or more
____ is the resistance at the point of contact of two conductor or one conductor and a surface
A. Contact resistance
C. More
When using compressed air to clean the electrical equipment, the air pressure must bo not over 50
pounds. The main reason is the higher pressure____
Tests on a 300m length of single- core mineral-insulatedcable produced the following results: conductor
resistance 2.4 , insulation resistance 40M . What will be the anticipated conductor and insulation
resistance values of a 120m length of the cable?
B. 16ohms, .96ohms
C. Mvolt
A motor enclosure designed and constructed to contain sparks or flashes that may ignite surrounding
gas or vapour is called __________.
B. Explosion proof
If the length and cross sectional area are double. Calculate the total resistance of the wire
A. R
Lighting fixture shall be wired with a fixture cord with a c.s.a not less than ___
C. 0.75mm
D. Bisects
A. Xl=Xc, R=Z
At what frequency will the current in a series RLC circuit reach its maximum value for an applied voltage
of 15 V with R = 500 Ω, L = 100 µH and C = 0.001 µF?
A. 503 kHz
A. Open
The electric Energy required to raise the temperature of a given amount of water is 100kwh. If the heat
loses 25% , the total heating energy is___kwh
A.1500
B. 1000
C. 1333
D. 1250
How many kw hours are consumed by 25 60 watt light bulbs burning 5 hours
A. 1.5
B. 180
C. 75
D. 7.5
Four identical resistors are first connected in parallel and then in series. the resultant resistance of the
first combination to the second will be?
A. 16 times
B. 1/16 times
C. 4 times
D. 1/4 times
Two identical resistor connected in parallel is 12 ohms are connected in a dc voltage source 24v with a
series of 6ohms, calculate the power consume of the 6ohm resistor.( Based ito sa pagkakaalala ko,
pakitama na lang po )
A. Wooden plug
B. Rawl plug
C. Expansion bolt
D. Lag bolt
Ans: a load where the maximum current is expected to continue for three hours or more
____ is the resistance at the point of contact of two conductor or one conductor and a surface
A. Contact resistance
B. Conductor resistance
B. Less
C. More
D. The same
When using compressed air to clean the electrical equipment, the air pressure must bo not over 50
pounds. The main reason is the higher pressure____
Tests on a 300m length of single- core mineral-insulatedcable produced the following results: conductor
resistance 2.4 , insulation resistance 40M . What will be the anticipated conductor and insulation
resistance values of a 120m length of the cable?
A. 16ohms, 16ohms
B. 16ohms, .96ohms
C. .96ohms, 16ohms
D. .96ohms, 40ohms
A. kvolt
B. mvolt
C. Mvolt
D. μvolt
A motor enclosure designed and constructed to contain sparks or flashes that may ignite surrounding
gas or vapour is called __________.
A. Ventilated
B. Explosion proof
C. Encapsulated
D. Air cooled
If the length and cross sectional area are double. Calculate the total resistance of the wire
A. R
B. 2R
C. R/2
D. 3R/2
Lighting fixture shall be wired with a fixture cord with a c.s.a not less than ___
A. 2.0mm
B. 0.5mm
C. 0.75mm
D. 1.25mm
A. Is less than
B. Exceeds
C. Equal to
D. Bisects
A. Xl=Xc, R=Z
B. Xl=Xc
C. Xl+Xc= 1
D. Xl-Xc=0
At what frequency will the current in a series RLC circuit reach its maximum value for an applied voltage
of 15 V with R = 500 Ω, L = 100 µH and C = 0.001 µF?
A. 503 kHz
B. 403 kHz
C. 603 kHz
D. 303 kHz
Thevenin's equivaleny circuit is
A. Open
B. Shorted
C. Grounded
D. None of these
C.Both
D. None