Professional Documents
Culture Documents
100
,00
600 ,00
300
0
0,0
ø42
,00
660
,00
100
45
,0
0°
350
45,00°
,00
225
,00
600
,00 0
225 282,0
25,
00 FANE EN11801
18” SUB BASS ENCLOSURE
WWW.FANE-INTERNATIONAL.COM
FANE EN11801
18” SUB BASS ENCLOSURE
100,00
100,00
ø420,00
660,00
660,00
624,00
350,00
250,46
225,00
00°
45,
100,00
45,
00°
225,00
282,00 100,00
600,00 25,00
25,00
100,00
705,00
100,00
MODEL
1.0 1:1 mm Tolerance Linear +/- 0.4, Holes +0.1/-0.0, None - Cumulative
MATERIAL / FINISH
Unspecified material. 18mm Birch Plywood, Baffle 18mm MDF, Brace 18mm
THE PROFESSIONAL SERIES
COLOSSUS 18XB
SUB BASS DRIVER
The Colossus 18XB is intended for use as a high-output sub-bass driver either singly • Deep, warm, well controlled bass reproduction.
or in multi way systems. The unit features a 4 inch ‘sandwich’ inside and outside
| COLOSSUS 18XB
+90
Peak Power (6dB Crest Factor) 4000 w (A.E.S.) Qes 0.358
dBr
+80
Usable Frequency Range -6dB 35 Hz - 1 kHz Qts 0.337
Vas Ltr
+70
Sensitivity (1 w - 1 m) 99 dB 236 litres
+60
Vd litres 0.803 litres
Moving Mass inc. Air Load 173 grams
+50 CMS (mm/N) 0.13 mm/N
20 50 100 200 500 1k 2k 5k 10k 20k Minimum Impedance Zmin 6.5 Ω
Hz BL T/m 25.9 T/m
* Half space response measured in a 975 litre sealed box. Effective Piston Diameter 15.03” / 381.76 mm
Mms (grms) 173 grams
IMPEDANCE Peak Displacement Volume of Cone Vd 0.803 litres
Xmax (mm) 7.5 mm
200
Magnet Weight 120 oz
100 Sd (cm2) 1131 cm2
Magnetic Gap Depth 0.39” / 10 mm
Efficiency % 2.30%
Flux Density
50
1.2 Tesla
Le (1k Hz) 1.99 mH
20
Coil Winding Height 0.90” / 23 mm
Ohms
10
Voice Coil Diameter 4.0” / 101.6 mm
5
-18
PCD / 8x 7 diam on 438.15 Dust Dome Paper
-24 PCD
Connectors Push-button Spring Terminals
-30 Depth 8.05” / 205 mm
Positive voltage at red terminal
Polarity
Weight
-36
31.29 lb / 14.2 kg causes forward motion of cone
5 10 50 100 500 1k 5k 10k 20k
Hz 3.53 - 8.82 cu ft / 125 - 400
Recommended Enclosure Volume
** Normalised bass response in 175 litre tuned to 33 Hz litres
Shipping Weight 35.26 lb / 16 kg
m
18” / 457 mm
9.21” / 234 mm
• Please enquire about alternative impedances.
8.05” / 205 mm
• A.E.S. power handling test. Pink noise bandpass filtered at 12 dB per octave with cutoff frequencies of 30 Hz and 300 Hz. Driver mounted in
free air, test signal applied at rated power for two hours.
• Please note that the frequency response measurements are supplied for comparison only and are not a measure of the low frequency
performance which may be achieved in a fully optimised system.
THE PROFESSIONAL SERIES
COLOSSUS 18SB
SUB BASS DRIVER
The Colossus 18SB is intended for use as a high-output bass driver in multi way • Fast, accurate bass. Defined, clean and punchy.
systems. It features a 4 inch ‘sandwich’ inside and outside windings voice coil,
+80
Usable Frequency Range -6dB 35 Hz - 2.5 kHz Qts 0.346
Vas Ltr
+70
Sensitivity (1 w - 1 m) 100 dB 199 litres
+60
Vd litres 0.893 litres
Moving Mass inc. Air Load 177 grams
+50 CMS (mm/N) 0.109 mm/N
20 50 100 200 500 1k 2k 5k 10k 20k Minimum Impedance Zmin 6.5 Ω
Hz BL T/m 24 T/m
* Half space response measured in a 975 litre sealed box. Effective Piston Diameter 14.84” / 376.93 mm
Mms (grms) 177.2 grams
IMPEDANCE Peak Displacement Volume of Cone Vd 0.893 litres
Xmax (mm) 8.25 mm
200
Magnet Weight 120 oz
100 Sd (cm2) 1134 cm2
Magnetic Gap Depth 0.43” / 11 mm
Efficiency % 2.49%
Flux Density 1.1 Tesla
50
10
Voice Coil Diameter 4.0” / 101.6 mm
5
-18
PCD / 8x 7 diam on 438.15
Connectors Push-button Spring Terminals
-24 PCD
Positive voltage at red terminal
-30 Depth 7.91” / 201 mm Polarity
causes forward motion of cone
Weight
-36
27.6 lb / 12.51 kg
5 10 50 100 500 1k 5k 10k 20k
Hz 4.41 - 14.12 cu ft /125 - 400
Recommended Enclosure Volume
** Normalised bass response in 175 litre tuned to 35 Hz litres
Shipping Weight 28.9 lb / 13.1 kg
m
18” / 457 mm
8.66” / 220 mm
• Please enquire about alternative impedances.
7.91” / 201 mm
• A.E.S. power handling test. Pink noise bandpass filtered at 12 dB per octave with cutoff frequencies of 30 Hz and 300 Hz. Driver mounted in
free air, test signal applied at rated power for two hours.
• Please note that the frequency response measurements are supplied for comparison only and are not a measure of the low frequency
performance which may be achieved in a fully optimised system.
THE PROFESSIONAL SERIES
SOVEREIGN PRO 18-800P
BASS DRIVER
The Sovereign Pro 18-800P is intended for use as a high-output bass driver in • Highly versatile in 2-way ported enclosures.
multi way systems and features a 4 inch ‘sandwich’ inside and outside windings
+80
Usable Frequency Range -6dB 35 Hz - 1 kHz Qts 0.337
Vas Ltr
+70
Sensitivity (1 w - 1 m) 97.5 dB 234 litres
+60
Vd litres 0.848 litres
Moving Mass inc. Air Load 147 grams
+50 CMS (mm/N) 0.129 mm/N
20 50 100 200 500 1k 2k 5k 10k 20k Minimum Impedance Zmin 7.92 Ω
Hz BL T/m 25.5 T/m
* Half space response measured in a 975 litre sealed box. Effective Piston Diameter 15.03” / 381.76 mm
Mms (grms) 170 grams
IMPEDANCE Peak Displacement Volume of Cone Vd 0.85 litres
Xmax (mm) 7.5 mm
200
Magnet Weight 120 oz
100 Sd (cm2) 1131 cm2
Magnetic Gap Depth 0.39” / 10 mm
Efficiency % 2.88%
Flux Density 1.2 Tesla
50
10
Voice Coil Diameter 4.0” / 101.6 mm
5
-18
PCD / 8x 7 diam on 438.15 Dust Dome Solid Paper
-24 PCD
Connectors Push-button Spring Terminals
-30 Depth 7.71” / 196 mm
Positive voltage at red terminal
Polarity
Weight
-36
27.6 lb / 12.5 kg causes forward motion of cone
5 10 50 100 500 1k 5k 10k 20k
Hz 4.41 - 14.12 cu ft / 125 - 400
Recommended Enclosure Volume
** Normalised bass response in 175 litre tuned to 35 Hz litres
Shipping Weight 28.9 lb / 13.1 kg
m
9.05” / 230 mm
18” / 457 mm
• A.E.S. power handling test. Pink noise bandpass filtered at 12 dB per octave with cutoff frequencies of 35 Hz and 350 Hz. Driver mounted in
free air, test signal applied at rated power for two hours.
• Please note that the frequency response measurements are supplied for comparison only and are not a measure of the low frequency
performance which may be achieved in a fully optimised system.