To recalibrate or program a DDECII ECM, connect the ECM to enter boot mode by connecting terminals B3, C1, C2, E1, F2, G3, and H3 to specific points - B3 to ignition, C1 and C2 to the J1708 data link, E1 to a 3.9k resistor to ground, and F2, G3, and H3 to ground. To read data from the ECM without recalibration, disconnect power and the E1, F2, G3, and H3 connections, wait 5 seconds, and reconnect power.
To recalibrate or program a DDECII ECM, connect the ECM to enter boot mode by connecting terminals B3, C1, C2, E1, F2, G3, and H3 to specific points - B3 to ignition, C1 and C2 to the J1708 data link, E1 to a 3.9k resistor to ground, and F2, G3, and H3 to ground. To read data from the ECM without recalibration, disconnect power and the E1, F2, G3, and H3 connections, wait 5 seconds, and reconnect power.
To recalibrate or program a DDECII ECM, connect the ECM to enter boot mode by connecting terminals B3, C1, C2, E1, F2, G3, and H3 to specific points - B3 to ignition, C1 and C2 to the J1708 data link, E1 to a 3.9k resistor to ground, and F2, G3, and H3 to ground. To read data from the ECM without recalibration, disconnect power and the E1, F2, G3, and H3 connections, wait 5 seconds, and reconnect power.
hi buddy, well to recalibrate or programing DDECII, the ecm should
stay in boot mode, to put the ecm in boot mode make the next bench conecction.... B3 = Ignici?n C1 = Data link J1708 (-) C2 = Data link J1708 (+) E1 = Connect one resistor of 3.9k to GND F2, G3 y H3 = GND
remember this metod is to calibrate only, to read data from the
ecm disconecct the power, disconnect E1, F2, G3 and H3 wait 5 seconds then connect the power