Professional Documents
Culture Documents
608 GN Flood Lamp - Rear H747 BR Variable Speed Fan Sol Return 191-6587 Sender: Engine Oil Temperature
Machine Control CONN 20 F-2, G-2 44.2 @ 50°C (122°F)
610 OR Head Lamp Basic H766 YL Implement Detent Sol D
Event Code Condition
611 PU Head Lamp Hi H795 PK Operator Mode Select Switch The connectors shown in this chart are for harness to harness connectors. 196-1185 Sensor: Speed Timing 1000 - 1200
51
E015 High Engine Coolant Temperature Derate 34 Connectors that join a harness to a component are generally located at or
612 GY Backup Alarm J843 PU Operator Select Switch Empty: 240 - 250
C 18 13 near the component. See the Component Location Chart. 204-3403 Sender: Fuel Level
E017 High Engine Coolant Temperature Warning 614 PU Park/Tail/Dash/Lamp K900 YL Instrument Cluster - CAN Hi 68 Full: 28 - 33
E025 High Inlet Air Temperature Derate 615 YL LH Front FloodCab Flood Lamp/Rops K977 PK Trans Oil Temp Sensor 46
7 206-5203 Solenoid: MSS Antenna 1
E027 High Inlet Air Temperature Warning 617 BR Running Lamp Switch K990 GN CAN Data Link Resister 54
215-3014 Solenoid: Axle Oil Cooler Clutch 9.4 ± 5.0
E039 Low Engine Oil Pressure Derate 619 GN Dimmer Switch L983 WH Injector Common 1 & 2
11 ¹ At room temperature unless otherwise noted.
633 BU Attach Lighting Ckt L984 OR Injector Common 3 & 4 23
E053 Low Fuel Pressure Warning
6
30 Page,
709 OR Sensor Power Supply N975 PK RS-232 Port 1 TXD (Product Link)
720 PU Neutralizer Override Switch N979 GN RS-232 Port 1 GND (Product Link)
727 GN Secondary Ster Motor Relay P910 BR Secondary Steering Test SW Input
728 BU Suppl Ster Cont SW P916 OR Trans Neutral Switch
751 GN Tranmission Shift Sol No. 3 - REV P976 BR Quick Coupler SW to Low Pressure Sol
752 YL Tranmission Shift Sol No. 1 - FWD Lo R746 PK Turbo Outlet Press Sensor
754 BU Tranmission Shift Sol No. 2 - FWD Hi R747 GY Atmospheric Press Sensor
Machine Harness Connector And Component Locations
755 OR Tranmission Shift Sol No. 5 - 3rd Gear T901 YL MSS Exciter Coil In
761 GY Lift Kickout Sol SW T902 PK MSS Exciter Coil Out
762 YL Bucket Positioner Sol SW X918 PU Gnd Level Shutdown (N/O)
779 WH Coupler Engage Sol X919 WH Gnd Level Shutdown (N/C)
Failure Mode Identifiers (FMI)¹ 799 WH Sensor Power (10V) X972 GN Variable Shift Control Switch - Pos 2
FMI No. Failure Description 818 BR Serial Data (Transmit) X973 BU Variable Shift Control Switch - Pos 3
0 Data valid but above normal operational range. 819 GY Serial Data (Receive) X974 BR Variable Shift Control Switch - Pos 4
1 Data valid but below normal operational range.
Related Electrical Service Manuals
2 Data erratic, intermittent, or incorrect.
3 Voltage above normal or shorted high.
Title Form Number
Alternator: 9W-3043 SENR3862
4 Voltage below normal or shorted low.
Atch: 185-5294 SENR4757
5 Current below normal or open circuit.
Electric Starting Motor: 111-4275
6 Current above normal or grounded circuit. Consist: 207-1517 SENR3581
7 Mechanical system not responding properly. (Japan) Consist: 168-8125106-8559 SENR3828
8 Abnormal frequency, pulse width, or period. Payload Control: 165-4047 SENR6614
9 Abnormal update. Traction Control: 172-9391 SENR6719
10 Abnormal rate of change. Powertrain Control: 172-9389 RENR6066
11 Failure mode not identifiable.
Machine Security System
12 Bad device or component. 158-6155 RENR2462
Control:
13 Out of calibration.
14 Parameter failures.
15 Parameter failures.
16 Parameter not available.
17 Module not responding.
18 Sensor supply fault.
19 Condition not met.
20 Parameter failures.
¹The FMI is a diagnostic code that indicates what type of failure has occurred.
WIRE GROUP COLOR DESCRIPTIONS
GROUND CIRCUIT
WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS OFF
WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS ON
VOLTAGE CONVERTER OUTPUT CIRCUIT
STARTING CIRCUIT
START AID CIRCUIT
TRANSMISSION / ENGINE PUMP CONTROL CIRCUIT
TRACTION CONTROL CIRCUIT
MACHINE SECURITY CONTROL CIRCUIT
ENGINE CONTROL CIRCUIT
HEATER AND AIR CONDITIONER CIRCUIT
TURN SIGNAL / WIPER WASHER CIRCUIT
PAYLOAD CONTROL CIRCUIT
CAT DATA LINK
J1939 (CAN) DATA LINK
IMPLEMENT / VALVE / TOOL CONTROL CIRCUIT