Professional Documents
Culture Documents
1 检查ABS警告灯是否依下列方式亮起
1 Check whether the ABS warning light is on in the following way
2 将点火开关置于“ON”位置,ABS警告灯亮大约3秒,然后熄灭。
2 Put the ignition switch in the "ON" position, the ABS warning light for
about 3 seconds, then go out.
如果不是上述情况,表示有故障,请检查故障码。
If is not the case, said there is a failure, please check the fault codes.
故障码故障检查表索引:
Index of fault code check list:
闪烁次数 可能的原因及处理方法
故障含义
Flicker Possible causes and treatment
Fault meaning
frequency methods
常亮 ECU 故障 更换 ECU
Often light ECU fault replacement ECU
点火电压高 蓄电池电压过高。
2-1
ignition voltage high battery voltage is too high.
点火电压低 蓄电池电压过低。
2-2
ignition voltage low battery voltage is too low.
制动灯开关故障。
brake light switch fault.
制动开关线束故障。
Brake switch wire harness fault.
刹车信号故障
2-3
brake signal fault
踩下制动踏板时,测量 ECU 第 18
脚电压应为 12V。
When the brake pedal is pressed, the
ECU eighteenth feet voltage should
be 12V.
电磁阀电源线束故障。
电磁阀电源故障 Solenoid valve power supply Wire
Solenoid valve power harness fault.
2-4
failure
电磁阀电源保险丝损坏。
Solenoid valve power fuse damage
ABS 电动机损坏。
ABS motor damage
电动泵故障
ABS 电动机保险丝损坏。
2-5 Electric pump failure
ABS motor fuse damage.
ABS 电动机线束损坏。
ABS motor wire damage
左前电磁阀故障
3-1 Left front solenoid valve 电磁阀线圈断路或断路故障。用万
malfunction 用表Ω档测量电磁阀线圈的电阻,
应为 6-7Ω,小于 3Ω表明断路,
大于 10Ω表明断路或接触不良。
左后电磁阀故障
此故障只准许授权维修或整体更
3-2 Left rear solenoid valve
换 ECU 部分。
malfunction
Solenoid valve coil open circuit or
open circuit fault. Solenoid valve
右后电磁阀故障 coil resistance is measured with a
3-3 Right rear solenoid valve multimeter Ω block , should be 6-7
malfunction Ω,less than 3 Ω, show open circuit,
more than 10 Ω , indicates that the
open circuit or poor contact.
右前电磁阀故障 This failure is only allowed to
Right front solenoid authorized repair or replace the ECU
3-4
valve malfunction part as a whole.
左前传感器开路
4-1 Left front sensor open
circuit
传感器线圈或线束开路。用万用表
左后传感器开路 Ω挡测量传感器电阻,应为 1-2K
4-2 Left rear sensor open Ω,大于 2KΩ表明断路或接触不
circuit 良。
Sensor coil or wire harness open
circuit.Solenoid valve coil resistance
右后传感器开路
is measured with a multimeter Ω
4-3 Right rear sensor open block , should be 1-2KΩ,more than
circuit 10 Ω , indicates that the open circuit
or poor contact.
右前传感器开路
4-4 Right front sensor open
circuit
左前传感器短路
5-1 Left front sensor short
circuit 传感器线圈或线束短路。用万用表
Ω挡测量传感器电阻,应为 1-2K
左后传感器短路 Ω,小于 1KΩ表明短路。
5-2 Left rear sensor short Sensor coil or wire harness short
circuit circuit. Solenoid valve coil
resistance is measured with a
右后传感器短路
5-3 multimeter Ω block,should be
Right rear sensor short
circuit 1-2KΩ, less than 1KΩ, indicates that
short circuit.
右前传感器短路
5-4 Right front sensor short
circuit
左前传感器信号异常 传感器输出信号太弱。
6-1 Left front sensor signal Sensor output signal is too weak.
anomaly
传感器线圈短路。
Sensor coil short circuit.
左后传感器信号异常 传感器线圈线束短路。
6-2 Left rear sensor signal Sensor coil wire harness short
anomaly circuit .
传感器线圈与齿圈间的间隙不正
常。
The gap between the sensor coil and
右前传感器信号异常
the gear ring is not normal.
6-4 Right front sensor signal
anomaly
齿圈或轮毅故障。
Gear ring or wheel failure.