Professional Documents
Culture Documents
2. Remove the reservoir cap 2, and then Checking the tilt operation
check the fluid level in the reservoir. (EHD, ED)
w
Be sure to tilt the outboard motor fully and
support it with the tilt stop lever. It can not
be tilted up partially. Otherwise the out-
1
board motor could fall back down sudden-
2
ly.
3
up. Fully tilt the outboard motor up and
Make sure that the trim and tilt rams are down 2-3 times and check the entire tilt
fully extended when removing the reser- range for smooth operation.
voir cap, otherwise fluid can spurt out
from the unit due to internal pressure.
NOTE:
If the fluid is at the correct level, the fluid
should overflow out of the filler hole when the
4
reservoir cap 2 is removed.
Reservoir cap 2:
7 N·m (0.7 kgf·m, 5.2 ft·lb)
matically, and then check the outboard
motor could not tilting up. 7
8
1
68830420
9
6885J11 3-16