Professional Documents
Culture Documents
Data Sheets
INDEX
1. Mix Designs
INDEX
CIKOflow HY120
New generation low range concrete plasticizer
Properties Dosage
Better dispersion of cement particles The normal dosage is 0.5 to 3.0 litres per 100kg cement
with small adsorbed area. which includes replacements (if any) such as microsilica,
Exhibits combined properties of high GGBFS, calcined clay (metakolin) and fly ash.
water reduction and prolonged
workability retention. The optimum dosage should be determined by
Maintains concrete flowability over a conducting laboratory/site trials considering proposed
long time. mix design, ambient conditions and performance
Provides high early compressive and requirements.
flexural strengths.
Low water cement ratio yields to low Usage instructions
permeability. CIKOflow HY120 is a ready to use concrete admixture.
Reduction in permeability, yielding to Required/calculated amount of CIKOflow HY120 should
increased durability. be measured by means of measuring jar or dispenser
and should be added to concrete during mixing process
Application area preferably after dispensing 70% of total water.
CIKOflow HY120 is suitable for all kinds of high To attain optimum efficiency of the admixture, it is
strength, high cement content and low water always recommended to dose CIKOflow HY120 to wet
cement ratio concrete. Typical application concrete mix. This can be done by mixing 70-75% of the
includes total water with all other ingredients of concrete followed
Self compacting concrete by the addition of CIKOflow HY120 diluted with
Hot weather concreting that demands remaining 25-30% water.
prolonged workability retention NOTE: CIKOflow HY120 should not be mixed with
Precast concrete for early high strength. dry/lump concrete.
More suitable for congested
reinforcement
To avoid cold joints
To obtain low heat of hydration
1
Compatibility with other admixtures Technical Support
CIKOflow HY120 should not be used in For any technical support, do not hesitate to contact
conjunction with any other admixtures. In case CIKO team at any time as CIKO offers on and off site
of such requirements please consult CIKO services to end users, specifier and contractors.
technical service department for assistance.
3. HAZARDS IDENTIFICATION
Physical hazards N.E.
Primary route of exposure Skin contact
Effects of acute / chronic
exposure
Skin contact Possible mild transient irritation on prolonged contact
Eye contact May cause temporary irritation
Inhalation Over exposure to mist may cause irritation of the respiratory tract
Ingestion Very slightly toxic. May cause G.I irritation, nausea and cramps.
4. FIRST AID MEASURES
Skin contact Wash thoroughly with soap and water. If any irritation develops, seek
immediate medical attention.
Eye contact Flush with plenty of fresh water and se ek immediate medical
attention.
Inhalation Remove to fresh air.
Ingestion Administer milk or water. Do not induce vomiting. Call the physician
or Poison Control Centre immediately. Do not give anything orally to
an unco nscious person. This applies to al l pr oducts that w ill not
require vomiting to be induced, however, medical attention or
consultation is to be sought immediately.
5. FIRE FIGHTING MEASURES
Conditions of flammability None
Means of extinction None
Flash point & means of
determination None
Upper flammable limit None
Respirator None
Other -
9. PHYSICAL AND CHEMICAL PROPERTIES
Physical state Liquid
Odour and appearance Slightly ammoniac / Yellowish liquid
Odour threshold N.A.
Specific gravity 1.05 + 0.015
Vapour pressure N.A.
Vapour density N.A.
Evaporation rate N.A.
Boiling point N.A.
Freezing point N.A.
Melting point N.A.
pH 8.0
Incompatible materials Do not mix with other concrete admixtures as they may gel
Conditions of reactivity
Hazardous decomposition
products None
11. TOXICOLOGICAL INFORMATION
Toxicology information N.A.
Skin contact Possible mild transient irritation on prolonged contact
Eye contact May cause temporary irritation
Inhalation Over exposure to mist may cause irritation of the respiratory tract
Ingestion Very slightly toxic. May cause G.I irritation, nausea and cramps.
12. ECOLOGICAL INFORMATION
Ecological information N.A.
13. DISPOSAL CONSIDERATIONS
Waste disposal In the event of large spills at ready-mix plants, either flush into the
wash-out pit, or dike and contain. Contained material may be
absorbed and disposed of, or allowed to evaporate and the solids
disposed of in a trash container.