Professional Documents
Culture Documents
Chemical Base
CONSOL FLOW 103 is used as a general purpose admixture Modified polycarboxylate in water
to produce a workable concrete mixture having optimum
Density
water cement ratio to obtain an economical mix where the
Specific density: 1.09 ± 0.02 kg/L (at 25 0C)
placing conditions of high quality concrete are more
demanding such as:
Hot weather concrete
Dosage
Ready mix concrete
0.5 – 0.85 % by weight of cement
Pumped concrete
Fair faced concrete Dispensing
Areas where large volumes must be placed at one time CONSOL FLOW 103 should be dispensed directly into
High mechanical strengths are required mixing water prior to its addition to the aggregates.
Note
It is advisable to carry out trial mixes to establish the
CONSOL FLOW 103 provides the following properties as set exact dosage rate required and desired concrete
retarding and superplasticizer: properties.
Extend setting time in hot weather
Reduce water content with a high dosage HANDLING PRECAUTIONS
Increased strengths development Avoids contact with skin and eyes
Improve workability without increase water content Wear protective gloves and eye protection during work
Long lasting control of slump loss If skin contact occurs, wash skin thoroughly
Reduced shrinkage and creep If in eyes, hold eyes open, flood with warm water and
Chloride free-does not attack reinforcement seek medical attention without delay.
Better surface finish For detail health, safety and environmental
recommendations, please consult and follow all
instruction on the Material Safety Data Sheet.
Form
Liquid
Appearance
Transparent
Packaging
200 litres sealed drum
1000 litre IBC’s or tanker delivey on request