Professional Documents
Culture Documents
X6 Configuration Manual
X6 Configuration Manual
CREATE ADMIN
Press **++*#+→Input *1234#+→register fingerprint 3 times (green light on and a long buzz) →press **+ to
exit (green light on and a long buzz)
CHANGE ADMIN
Press **++*#+→Press admin fingerprint →press *8+ (green light on and a long buzz) →register fingerprint 3
times → press **+ to exit (green light on and a long buzz)
If the administrator password is lost, you can reset the password to default by using tamper switch.
Operation:
1. Dismantle the device and wait for 30 seconds until a short beep is heard.
2. Press the Tamper Switch thrice to reset to the initial administrator password.
Note:This operation must be done within 30 seconds; the default administrator password is 1234.
ADD/EDITUSER (finger)
Press **++*#+→Press admin fingerprint→press *#+→ Input a new/ exist user ID(5 digit max) *#+→ register fingerprint 3
times (green light on and a long buzz) →press *#+ continue to add new users OR press [*] to escape(green light on
and a long buzz)
ADD CARD
Press **++*#+→Press admin fingerprint→press *#+→ Input a new/ exist user ID(5 digit max) *#+→ register card 2 times
(green light on and a long buzz) →press *#+ continue to add new users OR press **+ to escape(green light on and a
long buzz)
ADD PASSWORD
A. When a group of password was changed into 00000, then this group of password was shut down
B. When a group of password was changed successfully, you can input next group of number to modify
directly.
Delete a single user Press **++*#+→Press admin fingerprint →press *3+ →Press *2+ → Put work number *#+ /
fingerprint / card →press **+ to exit Delete all of the users
Default: 6 second
Press **++*#+→Press admin fingerprint→press *4+ →Input unlock duration (1s~10s) →press **+ to exit
Press **++*#+→Press admin fingerprint →press *5+ →Input authentication mode value *#+→press **+ to exit
Alarm Switch (Default ON) The switch is the master switch of the machine, only when it's on, can the alarm
incorrectly, tamper alarm and magnet alarm be working properly. The alarm will be shut down when it's
off. Press **++*#+→Press admin fingerprint→press *0++ *1+→Configure main switch *#+ (0: ON,
1:OFF)→press **+ to exit
Only when this function is on, the machine can be alarmed during tampering. Press **++*#+→Press admin
fingerprint→press *7+→Configure tamper alarm switch *#+ (0: ON, 1:OFF)→press **+ to exit