Professional Documents
Culture Documents
2. Does pump PM 9 provide aspiration for automatic mode, manual mode, or both?
_______________________
4. In an at rest state, what is the inner piston position of the aspirate pump (PM9)?
__________________________________
5. The inner piston position determines the volume (high or low) aspirated?
True or False
7. The volume of blood/fluid aspirated during automatic and manual modes are the same.
True or False
8. The outer piston is in the down position for manual mode aspiration. True or False
12. List the Cylinder number and associated Solenoids that control movement of the Center
Section of the BSV.
Shear Valves
14. Shear valves are used for segmenting __________, __________ blood samples and
stained _________ samples.
15. The diff sample is routed to the Diff _________ _________ and Retic samples is routed
to the Retic ____________ chamber.
16. The Diff and Retic Blood Segment valve provide _______ µl of whole blood sample.
17. The Stained Retic Segment valve provides ______ µl of stained retic dilution.
18. During sample aspiration the Diff and Retic Segment valves are in the ________
position. HOME / SEGMENT
Needle Assembly
19. The Stationary Needle is enclosed within a ________________.
22. The bellows _____ sensor must be activated before the system rinses the needle vent
line or backwashing the needle.
23. Diluent is pushed through the needle and accumulates in the bellows for draining to
waste. True or False
27. How many bubble/blood detector error messages can occur during the aspiration cycle?
_______________
28. If any of these checks fail, an aspiration error occurs and the system will retry the same
tube again if the # of aspirations per tube is set to 1.
True / False
29. If you run samples in Automatic Mode with the Bubble/Blood Detectors disabled, the
results will be displayed at the Workstation with P flags.
True / False
Hand Detector
30. What is the hand detector used for?
_________________________________________________________ and
_________________________________________________________
31. In manual mode, a sample ______ must be entered before the system will aspirate.
33. Solenoid __________ provides diluent and Solenoid _________ supplies vacuum to the
cleaning truck.
34. Before rotating the BSV, the cleaning truck must be in the ____________ position.