Professional Documents
Culture Documents
Q1. Which is a typical value of insolation (irradiance) for full-sun (no clouds) and measured
perpendicular to the Sun's rays (cosine of incident angle=1)?
a. 100 W/m2
b. 1000 W/m2
c. 1000 kW/m2
d. 1000 W/cm2
a. AC
b. DC
c. Both
a. Hydrogen
b. Nitrogen
c. Silicon
d. Carbon
Q5. When PV Solar panels are added in series, what happens to voltage and current respectively?
a. Increases and Remain same
b. Decreases and Increases
c. Remain same and Increases
d. Decreases and Decreases
Q6. Which wire combination would allow me to power a device that needs 6 volts?
a. Two 3 volt solar panels wired in parallel
b. Two 2 volt solar panels connected in series.
c. Two 3 volt solar panels wired in series
d. Two 2 volt solar panels connected in parallel
1
Q7. What is the purpose of a PV charge controller:
a. Controls the amount of current flowing into a battery from the PV panel
b. Controls the current flowing out of the battery to the load
c. Monitors and regulates the voltage of a battery
d. All of the above
a. Solar energy from the sun --> Absorbed by solar cells --> Transferred into homes -->
Inverted by grid-tie inverters --> Electricity
b. Solar energy from the sun --> Absorbed by solar cells --> Inverted by grid-tie inverters --
> Electricity --> Transferred into homes
c. Solar energy from the sun --> Inverted by grid-tie inverters --> Absorbed by solar cells --
> Electricity --> Transferred into homes
d. Solar energy from the sun --> Inverted by grid-tie inverters --> Electricity --> Inverted by
grid-tie inverters --> Transferred into homes