Professional Documents
Culture Documents
To Install: .........................................................................................................3
Target Grids.....................................................................................................9
Emergency Luminaires..................................................................................69
To Install:
From the START button go to RUN and type D: SETUP.EXE (or whatever your CD
drive letter is)
Setup will give the choice of either accepting the default path for Chalmlite™ location
(C:\CHALMLITEV4.04) or choosing a different path location.
The final question from Setup allows you to have an Icon shortcut placed on your
desktop. If you choose not to do this you can operate Chalmlite™ from the Start –
Programs – menu bar.
If you move any of the above folders after installation the CMW.CFG pathnames
should be changed to suit.
Chalmlite™ Version 4.04 can be installed onto and accessed via a Network server
but is not itself a true Net-workable program. Two users cannot access the program
at the same time.
Alternatively Chalmlite™ may be installed onto individual PC’s and the Project Files
saved to a Network location for security purposes.
Project Set-Up
The first stage of any lighting design is to create a new project. To do this follow the steps outlined below.
¾ Define Limits window - You must now determine the working area
o Enter Width of area
o Enter Length of area
Snap Values
Snap Values are the term used to determine where the mouse will be operating from on the page.
¾ The lower right hand corner that is highlighted area shows the use positioning of the mouse on the working area.
¾ Snap - the snap value determines the frequency in metres the mouse is snapping in the working area
o Snap Status – remain on
o Snap Value – measurement in metres
¾ The lower right hand corner that is highlighted area shows the use positioning of the mouse on the working area.
Target Grids
The Target Grid enables You to calculate the lighting levels represented on the project being created.
¾ The New x-y grid window opens and enables You to determine the proximity for each point.
¾ Target Grid
o Left click on the grid to place the first corner on the Target Grid
o Click on the opposite corner to secure the grid area