Professional Documents
Culture Documents
CAUTION: To prevent personal injury or equipment damage, these instructions must be read
and carefully followed. No alterations shall be made to this product.
ss01957
CAUTION: LED activity is not an indicator of circuit integrity. LED activity is for reference
only. Refer to applicable service information for circuit diagnostic procedures. For
best results, use a high-quality, low-impedance, digital volt ohm meter.
Features Specifications
The DLC Breakout Box: Operating range 7.0–20.0 VDC input
• Allows for diagnosis and easily taken measurement at Maximum load Up to 5.0 amp output
the DLC.
Overload protection Yes; PTC fuse (self-healing)
• Displays vehicle protocol activity on LEDs. Monitoring voltages Below 11.6V beeper ON; higher
• Displays battery voltage and provides an audible than 15.2 V beeper ON
warning (beep) when voltage is out of range. Volt displays 3-digit LED (resolution: 0.1 V)
Banana sockets 16 outputs × 4.0 mm diameter
Tech Support with LED lamp indications
Email: oetech@service-solutions.com Protocols detected PWM (J1850), VPW (J1850),
ISO 9141-2, DIS/ISO 14230-4,
Phone: 1-800-662-2001 CAN bus (J-2284)
OBDII connection 2 m, including length of tool
Operating temperature 0–50°C (32–122°F)
Permitted humidity <70%
Reverse polarity Yes; LED lights on correct
protection polarity
Certifications CE; FCC; RoHS
Operating Instructions Terminal Side (TS) View
1. With the ignition switch in the OFF position, connect
the DLC Breakout Box to the vehicle DLC.
Momentary Closure
Switch