Professional Documents
Culture Documents
DIY PGMFI Diagnostics - Codes
DIY PGMFI Diagnostics - Codes
User Name
Password
Zaloguj sie Pomoc
Zapamiętaj mnie?
Nowe ogłoszenia FAQ Kalendarz Działania na forum Szybkie linki zaawansowane wyszukiwanie
18-05-2007 22:34 #1
ECU-MAN
Cel:
Wymagane:
- Honda z usterką
- kluczyk zapłonu
Celem tego
majsterkowania jest
www.ozhonda.com/forum/showthread.php?67113-DIY-PGMFI-Diagnostics-Codes 1/14
1.10.2022, 23:36 DIY PGMFI Diagnostics - Codes
znalezienie i
zdiagnozowanie usterki
w Twoim układzie
wtrysku paliwa.
Powszechnie znany w
Hondzie jako system
PGMFI. PGMFI to skrót
od P ro g ra m med F
uelWrzucam .
To majsterkowanie
obejmuje kody
znalezione w
samochodach AUDM,
chociaż można je
dostosować do JDM i
USDM. Kody te są takie
same dla OBDO, OBDI,
OBDIIa i OBDIIb. Aby
pobrać kody z pojazdu
OBDO wystarczy
przekręcić stacyjkę w
pozycję II i spojrzeć na
okno na ECU PGMFI i
policzyć kody z
migającej czerwonej
diody LED, jednak w
samochodach OBDI i
OBDII wymagane jest
zmostkować złącze
kontroli serwisowej
„SCS”, a następnie
włączyć zapłon w
położenie II, żółta
lampka silnika na desce
rozdzielczej, znana jako
lampka kontrolna awarii
„MIL”, będzie migać
kodami.
0 ECU – Elektroniczna
jednostka sterująca
1 O2A – Czujnik tlenu
#1
2 O2B – Czujnik tlenu
#2
3 MAP – Czujnik
ciśnienia bezwzględnego
w kolektorze
4 CKP – Czujnik
położenia korby
5 MAP – Czujnik
ciśnienia bezwzględnego
w kolektorze
6 ECT – Czujnik
temperatury płynu
chłodzącego silnik
7 TPS – Czujnik
położenia przepustnicy
8 TDC – Górny czujnik
martwego środka
9 CYP – Cylinder Czujnik
położenia
10 IAT - Czujnik
temperatury powietrza
www.ozhonda.com/forum/showthread.php?67113-DIY-PGMFI-Diagnostics-Codes 2/14
1.10.2022, 23:36 DIY PGMFI Diagnostics - Codes
dolotowego
12 EGR - Zawór
podnoszący recyrkulacji
spalin
13 BARO - czujnik
ciśnienia
atmosferycznego
14 EACV- (IAC) -
Elektroniczny zawór
sterujący powietrzem
15 IOS - Sygnał
wyjściowy zapłonu
16 INJ - Wtryskiwacze
paliwa
17 VSS - Czujnik
prędkości pojazdu
19 ATLC - Zawór
sterujący blokowania
automatycznej skrzyni
biegów
20 ELD - Detektor
obciążenia
elektrycznego
21 VTS - VTEC
Elektrozawór szpuli
22 VTP - VTEC Zawór
ciśnieniowy
23 KS – Czujnik stuku
41 PO2H – Grzałka
pierwotnej sondy
lambda
42 SO2H – Grzałka
wtórnej sondy lambda
43 FSS – Układ zasilania
paliwem
- kliknij na numer
kodu usterki
powyżej, aby
zobaczyć
przykład MIL
- kliknij nazwę
czujnika, aby
wykonać
diagnostykę
samodzielnie
czujnika
KROK 1
www.ozhonda.com/forum/showthread.php?67113-DIY-PGMFI-Diagnostics-Codes 3/14
1.10.2022, 23:36 DIY PGMFI Diagnostics - Codes
KROK 2
KROK 3
www.ozhonda.com/forum/showthread.php?67113-DIY-PGMFI-Diagnostics-Codes 4/14
1.10.2022, 23:36 DIY PGMFI Diagnostics - Codes
STEP 4
www.ozhonda.com/forum/showthread.php?67113-DIY-PGMFI-Diagnostics-Codes 5/14
1.10.2022, 23:36 DIY PGMFI Diagnostics - Codes
..................................
.............
Pułapka na noobów.
otrzymujesz zdjęcie
, że to jest to,
odczytałeś kody błędów
z ECU. teraz jeśli jesteś
odważny, kliknij link
(jeśli istnieje) kodu,
który masz i spróbuj
zdiagnozować i naprawić
problem.
OBDO
www.ozhonda.com/forum/showthread.php?67113-DIY-PGMFI-Diagnostics-Codes 6/14
1.10.2022, 23:36 DIY PGMFI Diagnostics - Codes
- w zielonym kółku na
zdjęciu powyżej
znajduje się otwór z
czerwoną diodą LED.
Jeśli w pamięci ECU jest
zapisany kod błędu, kod
zamiga w ten sam
sposób, jak opisano
powyżej z MIL, gdy
wyłącznik zapłonu
znajduje się w pozycji
II. Jeśli wszystko jest w
porządku z systemem
PGMFI, po włączeniu
zapłonu dioda LED
będzie szybko migotać,
a dioda pozostanie
wyłączona.
Zastrzeżenie:
Poniższe informacje
są dostarczane
WYŁĄCZNIE jako
PRZEWODNIK i ani ja,
ani Ozhonda nie
ponosimy żadnej
odpowiedzialności za
wyniki innych osób
wykonujących
poniższe czynności.
Wykonujesz te kroki
na własne ryzyko!
18-05-2007 10:35 PM #2
www.ozhonda.com/forum/showthread.php?67113-DIY-PGMFI-Diagnostics-Codes 7/14
1.10.2022, 23:36 DIY PGMFI Diagnostics - Codes
ECU-MAN
SCS location
Green block gangster
If anyone has a picture of the SCS location not listed here please send
it to me to help update the list
18-05-2007 10:35 PM #3
ECU-MAN
Reset ECU
Green block gangster
most OBDI and OBDIIa and OBDIIb cars is just a matter of finding the
7.5Amp backup fuse in the underhood fues box and pulling it out for 3
or so seconds. Anything longer than 10 seconds really is a waits of
time.
www.ozhonda.com/forum/showthread.php?67113-DIY-PGMFI-Diagnostics-Codes 8/14
1.10.2022, 23:36 DIY PGMFI Diagnostics - Codes
*** note the above picture is a guide only and may not show the
actual fuse you should pull in your car. ***
If you cant find the fuse or are having trouble resetting the ECU, then
you can remove the negative battery terminal ( for 3 to 10 seconds )
to clear the ECU memory as a sure way to get it reset. This method
isn’t the best as you have to put in the radio code and reset the radio
station presets plus the clock.
There are lots of myths going around like remove the fuse for 10
minuets or disconnect the battery and turn on the head light and
touch the battery terminals together to drain the power from the ECU
ect. All false.
For the S2000 you have to remove the 30A backup fuse in the
underhood fuse box.
www.ozhonda.com/forum/showthread.php?67113-DIY-PGMFI-Diagnostics-Codes 9/14
1.10.2022, 23:36 DIY PGMFI Diagnostics - Codes
After resetting the ECU with OBDO and OBDI cars your right to go.
However with OBDII cars you have to "learn" the idle load parameters
to the ECU. This can be done by turning off all electrical accessories in
the car ( turn everything off in the car and only let it idle ) and
allowing the car to idle until the thermo fans kick in and out at least
twice. Then turn off the car and your done.
No need to drive the car and rev it to redline or anything else like
that.
Thanks to CRXer, here is the ECU reset fues for 1988- 89 GEN II CRX
with OBDO
09-07-2007 08:14 PM #4
ECU-MAN
code 19 coming soon !!!
Green block gangster
Join Date: May 2004
Car: : twin GX160's
09-07-2007 09:27 PM #5
wynode
People are gonna go crazy when they see this!
www.ozhonda.com/forum/showthread.php?67113-DIY-PGMFI-Diagnostics-Codes 10/14
1.10.2022, 23:36 DIY PGMFI Diagnostics - Codes
10-07-2007 11:23 AM #6
TheGoodDeal
Member
Join Date: Sep 2006
Excellent write up, very details, clear picture & examples and
Car: : Civic GLI 1997 EK1
confusion point out.
Thanks!!
10-07-2007 06:48 PM #7
CRXer
WTF!!!!!!!!!!!!!
Member
Holy crap,this should be stickied to every tech section of every honda
Join Date: Mar 2006 forum that ever existed.
Location: Sydney
Car: : doorstop At least sticky it to the top of the DIY section,it would be easier to link
up to every question that was ever asked.
ECU LED location for OBD0 versions(maybe should put in the SCS
location post)
ECU reset fuse for CRX gen2 & prob other similar era cars like
integra.Marked "HAZARD" fuse.
www.ozhonda.com/forum/showthread.php?67113-DIY-PGMFI-Diagnostics-Codes 11/14
1.10.2022, 23:36 DIY PGMFI Diagnostics - Codes
08-08-2007 05:48 PM #8
xedent
I have a 96 ej8 coupe and i cant find the SCS connector even if i look
at the pic that you uploaded for my car, its not there, there is only the
Newcomer
yellow one behind it.
Join Date: Aug 2006
Location: Noosa QLD
Car: : ED Civic
08-08-2007 06:24 PM #9
ECU-MAN
try looking on the oppisite side where the ecu is.
Green block gangster
Join Date: May 2004
Car: : twin GX160's
08-08-2007 10:29 PM #10
xedent
Newcomer
try looking on the oppisite side where the ecu is.
Join Date: Aug 2006
Location: Noosa QLD
Car: : ED Civic
I have looked under there all, cant find anything
08-08-2007 10:51 PM #11
dynosaur
well done , ECU-MAN
Member
Join Date: Apr 2006
Location: HELL
Yo~~! Vtec go ! go ! go !
www.ozhonda.com/forum/showthread.php?67113-DIY-PGMFI-Diagnostics-Codes 12/14
1.10.2022, 23:36 DIY PGMFI Diagnostics - Codes
Check this :
08-08-2007 11:30 PM #12
ECU-MAN
Originally
Green block gangster Posted by
Join Date: May 2004 xedent
Originally
Posted by
dynosaur
well done ,
ECU-MAN
thanks dude
Quick Navigation
DIY Articles / Reviews
Top
«
Previous Thread
|
Next Thread
»
www.ozhonda.com/forum/showthread.php?67113-DIY-PGMFI-Diagnostics-Codes 13/14
1.10.2022, 23:36 DIY PGMFI Diagnostics - Codes
FAQ DIY Articles Forum ACT & Tasmania New Threads
Merchandise Build Threads Calendar New South Wales New Posts
Terms Wallpapers Gallery Queensland FOR SALE ITEMS
Subscribe Social Groups South Australia ACT & Tasmania
Victoria New South Wales
NT and WA Queensland
South Australia
Victoria
NT and WA
Contact Us
Ozhonda.com
Archive
Privacy Statement
Top
All times are GMT +10. The time now is 07:10 AM.
All logos and trademarks in this site are the property of their respective owner(s). The comments are the property of their posters.
www.ozhonda.com/forum/showthread.php?67113-DIY-PGMFI-Diagnostics-Codes 14/14