Check you have all the parts Fit the inlet block Step Step to your chosen needed to complete the con- 1 2 side using the densate cleaner. You should have 4 screws & screws supplied. washers, a manifold block, 2 Extra blocks can elbows and a straight push be purchased if fitting, a length of tube, 1 required large and 3 smaller blanking Step Fit the circular plates, 2 spare sampler caps 3 blanking plug and a spring steel strip. into the opposite SEP 900 ST has 2 spring side of unit steel strips. Insert the Insert the metal retainer Step Step STERLING with its bent ends facing 4 filter, which 5 upwards. is the white Slide it down until it makes netting bag contact with the top of the with the tied STERLING filter. Do not top, pushing compress the filter. it gently but For the larger SEP 900 ST, firmly down two retainers are used at base of the 90 degrees to each other housing. for each filter set
Step Check that Sample
Step Step the twist-off 6 7 8 cap is fitted to the sample point. Connect a reinforced hose to the outlet nipple, ensuring it has unimpeded flow Outlet to the foul drain. The Insert the needle-felt Connect the inlet block to the outlet point is either moulded or a filter with its inlet tube filter inlet tube using fittings separate fitting as shown depending as shown supplied. upon the model. Fill with water and check for any leaks NOTES: Please ensure a steady down slope from the outlet point to the foul drain. Never discharge to storm drain or surface water. Test outlet quality weekly using kit provided. Replace filters before outlet cloudiness exceeds the ppm limit for your region.