Professional Documents
Culture Documents
Uses Properties
Renderoc BF is designed for application to imperfections in The following results were obtained at a water:powder ratio
concrete and masonry surfaces. It is suitable for application of 0.2
upto 5mm thickness, and can be used in the following
situations: Property
Initial setting time (BS EN 196) : 115 mins
Filling blow holes prior to overcoating
Final setting time (BS EN 196) : 165 mins
Skim-coat over concrete to receive protective coatings Fresh wet density : 1840 kg/m3
Compressive strength : 3days - 10N/mm²
General reprofiling over large areas
7days - 20N/mm²
Reprofiling, in association with other Renderoc mortars Average Linear Coefficient
of Thermal Expansion : 2.5 x 10-6 per oC
Advantages
Note : Working life and setting time will vary dependent
Cost effective/ time saving - no independent primer or on ambient, substrate temperatures and wind
curing agents required speed.
Do not proceed with the application when rainfall is Mixing should be carried out in a suitably sized mixing
imminent unless in a sheltered or protected situation. vessel, using a slow speed (400/500 rpm), heavy duty drill
If any doubts arise concerning temperature or substrate and a Fosroc mortar mixing paddle.
conditions, consult the local Fosroc office. Pour 4 - 6litres of water (depending of workability required)
into the mixer and, with the machine in operation, add one
full 20 kg bag of powder, then mix for 3 to 5 minutes, until
fully homogeneous. Do not use more than 6 litres of water
per 20kg bag.
Renderoc BF
Fosroc Renderoc BF
Important note
Fosroc products are guaranteed against defective materials and manufacture and are sold subject to its standard Conditions for the Supply of
Goods and Service. All Fosroc datasheets are updated on a regular basis. It is the user’s responsibility to obtain the latest version.
Head Office
telephone: (+9714) 2039699 fax: (+9714) 2859649 email: agf@fosroc.com
Al Gurg Fosroc Co. LLC
Regional offices
Post Box 657, Dubai Abu Dhabi, Al Gurg Fosroc telephone: 673 1779 fax: 673 1449 email: abudhabi@fosroc.com
Bahrain, YBA Kanoo telephone: 17738200 fax: 17732828 email: bahrain@fosroc.com
United Arab Emirates
Kuwait, Boodai telephone: 4817618 fax: 4832124 email: kuwait@fosroc.com
www.fosroc.com Oman, Al Amana telephone: 24815080 fax: 24817554 email: oman@fosroc.com
UAE/0492/13/I
Revision date: 23/11/2020 Revision: 3 Supersedes date: 26/07/2018
1.2. Relevant identified uses of the substance or mixture and uses advised against
Identified uses Cementitious overlay
Health hazards Skin Irrit. 2 - H315 Eye Dam. 1 - H318 Skin Sens. 1 - H317 STOT SE 3 - H335
Human health Dust or splashes from the mixture may cause permanent eye damage. Dust may irritate the
respiratory system. Symptoms following overexposure may include the following: Coughing.
Dust has an irritating effect on moist skin. Prolonged contact with moist or wet product may
cause burns. Frequent inhalation of dust over a long period of time increases the risk of
developing lung diseases.
Environmental The product will harden into a solid mass in contact with water and moisture. The resultant
material is not biodegradable.
Hazard pictograms
1/8
Revision date: 23/11/2020 Revision: 3 Supersedes date: 26/07/2018
RENDEROC BF
3.2. Mixtures
Classification
Eye Irrit. 2 - H319
STOT SE 3 - H335
Classification
Skin Irrit. 2 - H315
Eye Dam. 1 - H318
Skin Sens. 1 - H317
STOT SE 3 - H335
The Full Text for all R-Phrases and Hazard Statements are Displayed in Section 16.
Ingestion Do not induce vomiting. Rinse mouth thoroughly with water. Give plenty of water to drink. Give
milk instead of water if readily available. Never give anything by mouth to an unconscious
person. Get medical attention immediately.
Skin contact After contact with skin, take off immediately all contaminated clothing, and wash immediately
with plenty of water. Get medical attention promptly if symptoms occur after washing.
Eye contact Do not rub eye. Remove any contact lenses and open eyelids wide apart. Rinse immediately
with plenty of water. Continue to rinse for at least 15 minutes. Get medical attention. Show
this Safety Data Sheet to the medical personnel.
4.2. Most important symptoms and effects, both acute and delayed
2/8
Revision date: 23/11/2020 Revision: 3 Supersedes date: 26/07/2018
RENDEROC BF
General information The severity of the symptoms described will vary dependent on the concentration and the
length of exposure.
Inhalation Frequent inhalation of dust over a long period of time increases the risk of developing lung
diseases.
Ingestion Ingestion of large doses may result in irritation to the gastrointestinal tract.
Skin contact May have an irritating effect on moist skin after prolonged contact, or may cause dermatitis
after repeated contact.Prolonged skin contact with wet preparation may cause serious burns
without pain being felt, including through clothing.
Eye contact Eye contact may cause serious and potentially irreversible injuries.
4.3. Indication of any immediate medical attention and special treatment needed
Notes for the doctor Treat symptomatically.
Special protective equipment Use protective equipment appropriate for surrounding materials.
for firefighters
3/8
Revision date: 23/11/2020 Revision: 3 Supersedes date: 26/07/2018
RENDEROC BF
Protective equipment
Appropriate engineering Atmospheric levels of dust must be maintained within the Occupational Exposure Limit.
controls Where mechanical methods are inadequate or impractical, appropriate personal protective
equipment must be used.
Personal protection Personal protection equipment should be chosen according to the CEN standards and in
discussion with the supplier of the personal protective equipment. This product may present a
chromate (VI) allergy risk. Users should wear appropriate personal protective equipment.
Eye/face protection The following protection should be worn: Chemical splash goggles. (conform EN 166)
Hand protection Use impervious, abrasion and alkali resistant gloves. Barrier cream applied before work may
make it easier to clean the skin after exposure, but does not prevent absorption through the
skin.
Other skin and body Use barrier creams to minimise skin contact. Wear appropriate clothing to prevent repeated or
protection prolonged skin contact.
4/8
Revision date: 23/11/2020 Revision: 3 Supersedes date: 26/07/2018
RENDEROC BF
Respiratory protection Wear a respirator fitted with the following cartridge: Particulate filter, type P2.
Colour Grey.
Odour Odourless.
Oxidising properties The mixture itself has not been tested but none of the ingredient substances meet the criteria
for classification as oxidising.
5/8
Revision date: 23/11/2020 Revision: 3 Supersedes date: 26/07/2018
RENDEROC BF
10.1. Reactivity
Reactivity When mixed with water, hardens to form a stable mass that is not reactive in normal
conditions.
Inhalation Irritating to respiratory system. Inflammation of the nasal mucous membrane by exposure to
cement dust.
Skin contact This product is strongly irritating. Prolonged contact may cause burns. May cause
sensitisation by skin contact.
Eye contact Irritating and may injure eye tissue if not removed promptly.
Acute and chronic health Repeated and/or prolonged contact may lead to dermatitis.
hazards
6/8
Revision date: 23/11/2020 Revision: 3 Supersedes date: 26/07/2018
RENDEROC BF
Species Rabbit
12.1. Toxicity
Ecological information on ingredients.
Disposal methods Dispose of waste to licensed waste disposal site in accordance with the requirements of the
local Waste Disposal Authority.
General The product is not covered by international regulations on the transport of dangerous goods
(IMDG, IATA, ADR/RID).
14.1. UN number
Not relevant.
Transport labels
No transport warning sign required.
7/8
Revision date: 23/11/2020 Revision: 3 Supersedes date: 26/07/2018
RENDEROC BF
14.7. Transport in bulk according to Annex II of MARPOL and the IBC Code
Transport in bulk according to Not relevant.
Annex II of MARPOL 73/78
and the IBC Code
15.1. Safety, health and environmental regulations/legislation specific for the substance or mixture
EU legislation Regulation (EC) No 1907/2006 of the European Parliament and of the Council of 18
December 2006 concerning the Registration,Evaluation, Authorisation and Restriction of
Chemicals (REACH) (as amended).
Revision comments NOTE: Lines within the margin indicate significant changes from the previous revision.
Revision 3
This information relates only to the specific material designated and may not be valid for such material used in combination
with any other materials or in any process. Such information is, to the best of the company's knowledge and belief, accurate
and reliable as of the date indicated. However, no warranty, guarantee or representation is made to its accuracy, reliability or
completeness. It is the user's responsibility to satisfy himself as to the suitability of such information for his own particular use.
8/8