Professional Documents
Culture Documents
net/publication/272905281
Numerical simulation as a tool for optimizing tool geometry for rubber pad
forming process
CITATIONS READS
5 1,672
4 authors, including:
Some of the authors of this publication are also working on these related projects:
This work is a contribution to the Ministry of Education and Science of the Republic of Serbia funded Project TR 35011. View project
Structural Integrity and Reliability of Advanced Materials obtained through additive Manufacturing (SIRAMM) View project
All content following this page was uploaded by Aleksandar Grbovic on 08 February 2016.
Figure 11. H=4.5 mm a) first case (RI, RII and RIII equal 2
mm) b) second case (RI, RII and RIII equal 3 mm)
Figure 14. H=1.5 mm a) first case (RI, RII, and RIII equal 2
mm) b) second case (RI, RII, and RIII equal 3 mm)
Figure 15. The influence of RIII on the filling the cavity of the
tool rib a) case one (RI, RII and RIII equal 2mm) b) case two
(RI, RII and RIII equal 3mm)