RK
PERFORMANCE CHECKS
‘Output Power and Distortion
1. Connect a 49 dummy load to the output terminal.
2. Sat the Bright, Distortion, Reverb, Tremolo Intensity and Tremolo Speed
knobs to minimum, Volume, Bass, Middle, Treble and Pre-set Volume knobs
to maximum,
3. Feed a 400 Hz signal through the Input Jack,
4. Set the input level so that the output level is +28.2 dBm (100 Watts RMS).
5. The distortion factor should be within 10 %.
Frequency Response
6. Feed —50 dBm signals from 20 kHz down to 20 Hz observing the output on
a level meter,
7. The indicated response should be within + 3.48 of the specified response curve.
Noite Level
8. At no input condition noise level should be below ~20 dBm. When the
Volume knob is turned from maximum to minimum, the noise level should
bbe below —45 dBm. During this check, make sure the power switch is set
to the On position which provides the lower hum level,
Figure 8 Frequency Response Curve
NOTE: Value of “dBm” in this manual refers to 0 dBm = 0.775 V, except
where specified,