Professional Documents
Culture Documents
APPROVALS
Name Title Signature Date (YYYY-MM-DD)
J. Patrick Author 5/30/18
Engineering
Service Manager
Manufacturing
3D Platform | +1.779.771.0000
6402 E. Rockton Road, Roscoe, IL USA 61073
www.3DPlatform.com| 3dplatform.freshdesk.com
Document Number: 3DPTI-0003
Document Revision: Basic
Release Date: 2017-07-26
Table of Contents
Introduction .................................................................................................................................................. 3
Process .......................................................................................................................................................... 3
Prepare for the PID Tune Process. ............................................................................................................ 3
Start the PID Tune Process ........................................................................................................................ 3
Store the PID Values ................................................................................................................................. 3
Conclusion ..................................................................................................................................................... 4
Page 2 of 4
Document Number: 3DPTI-0003
Document Revision: Basic
Release Date: 2017-07-26
Introduction
The PID tuning process will stabilize heater control and reduce fluctuation. This process should be run
when changing out the extruders and extruder components, or if temperature fluctuation is noted.
Process
This will tell the controller to start the process, and to use 200C as the setpoint for the extruder. The
controller will then heat and cool down several times to calculate the new PID values. Ensure the Fans
are turned off for the duration of the PID tune process. The controller with perform a 4 phase process.
Note: Use the M303 Command during the tuning to check the status of the PID tune Process
Page 3 of 4
Document Number: 3DPTI-0003
Document Revision: Basic
Release Date: 2017-07-26
Conclusion
After tuning, temperature readings should be stable within 2 degrees of set point without major
fluctuation. Repeat the tuning process after changing extruders or if temperature fluctuation is noted.
Page 4 of 4