Professional Documents
Culture Documents
1 x Base Plate
4 x Screw M4x12mm
2 x Heavy Spring
Attaching the Base Plate
1. 1. Attach the base to the base plate as shown on the picture.
2. Use the M4x12mm screws to attach the baseplate. Ensure the screws are fully tightened to be flush with the baseplate.
Replacing the Cams and Springs
1. Remove the base from the base plate and unscrew the highlighted screws from the top part and remove it from body.
Option 1
1. Attaching the WarBRD base to the VPC Desk Mount Adapter - WarBRD Base/TM Warthog Base (https://virpil-controls.eu/vpc-desk-mount-adapter-
warbrd-base.html)
2. Fix the base with the M4x12mm screws from the adapter kit.
1. Detach the right corner from the VPC Desk Mount Adapter - WarBRD Base/TM Warthog Base (https://virpil-controls.eu/vpc-desk-mount-adapter-
warbrd-base.html)
2. Connect with adapter the base and a corner from set VPC Mouse Mount Adapter. VPC Mouse Mount Adapter (https://virpil-controls.eu/vpc-mouse-mount-
adapter.html)
3. Fasten the construction with the M4x12mm screws.
4. Unscrew the remaining screw and nut (highliten on the picture) from the adapter.
5. Put the adapter with base onto carriage of a mount, as it shown on the picture, and fix with the same screws and nuts.
6. Set a computer mouse pad on the corner.
7. Fix the pad with the screws and nuts from the VPC Mouse Mount Adapter.
Troubleshooting
Please visit the VIRPIL Controls support portal for troubleshooting advice. If you are still experiencing issues or unable to find answers to your specific question, please create a
ticket on our support portal!
https://support.virpil.com (https://support.virpil.com/)