Professional Documents
Culture Documents
Calypsol Equal Profile How Does Calypso Calculate Profile
Calypsol Equal Profile How Does Calypso Calculate Profile
Bilateral Equal Profile – How Does Calypso Calculate Profile TREE MENU
Written by Mark Boucher Home
Current Issue
A common question about profile is, if I take the minimum and the maximum
values of my profile output they don’t add up to the profile results value. What is Past Articles
Calypso
Let’s look at one of the profile tolerance zone shapes. CMM Manager
DMIS Corner
General
Bilateral (Equal Distribution)
GD&T
MCOSMOS
PC-DMIS
Today I Learned
CMMQ Publications
CMM TRAINING
The blue lines are as designated, the upper and lower tolerance lines. Taking the blueprint tolerance and dividing that number by two, i.e. 0.10 is +/- 0.05
will assign the position of these lines.
The red lines are the actual reported profile deviation. This is where things won’t seem to add up. If my min is -0.0006 and my max is 0.0009 why is it not
reported as 0.0015? Instead Calypso reports the profile as 0.0018. Calypso takes the point with the greatest deviation from the nominal geometry and
doubles that result for the actual profile result.
Where A is the absolute value of either the min or the max the actual profile deviation = 2xA.
1. Find the maximum value, or the largest deviation toward the outside of the part
2. Find the minimum value, or the largest deviation toward the inside of the part
Max: .0009
Min: -.0006
A = 0.0009
NOTE FROM EDITOR: Although this article is focused on Calypso this formula is used in all softwares to calculate Bilateral Equal Distribution.
ADVERTISEMENT
All materials in this magazine are the property of CMM Quarterly and its affilate companies and are made Copyright © 2007 - 2016 CMM Quarterly. All rights reserved.
available for the readers information but may not be copied, reproduced, or distributed for profit.
Please consider a donation to help with the costs of publishing this free magazine. Click here to donate.