Professional Documents
Culture Documents
A series RLC circuit consisting of R=10 ohms, X L=20 ohms and XC=20 ohms
is connected across an ac supply of 100 V (rms).The magnitude and the
phase angle (with reference to supply voltage) of the voltage across the
inductive coil are respectively.
a. 100V, 90°
b. 100V,-90°
c. 200V, -90°
2. The modems are used for data transmission over telephone lines to
a. Increases transmission capacity
b. Improve noise performance
c. Incorporate error control coding
d. Eliminate dc component in the transmitter signal
3. How many FFs are required to build binary counter circuits to count from 0
to 1023?
a. 1
b. 6
c. 10
10. An FM radio receiver is tuned to a 90.6 MHz broadcast station. It will receive
an image frequency of
a. 110 MHz
b. 112MHz
c. 114 MHz
d. 120 MHz
11. In a micro processor, the register which holds the address of the next
instruction to be fetched is
a. Accumulator
b. Program counter
c. Stack pointer
d. Instructor register
12. A stack is
a. An 8 bit registers in the microprocessor
b. A 16-bit register in the microprocessor
c. A set of memory locations in R/ W memory reserved for storing
information temporarily during the execution of a program.
d. 16 bit memory address stored in the program counter
14. A 1000 KHz carrier is simultaneously modulate with 300 Hz and 2 KHz
audio sine waves. The frequency which will not be present in the output is
a. 998 KHz
b. 999.7 KHz
c. 1000.3 KHz
d. 700 KHz
18. The blind speed of an MTI radar can be avoided by changing the
a. Carrier frequency
b. Pulse repetition frequency
c. Antenna rotation rate
19. Battery cells are connected in series to
a. Increase the current rating
b. Increase the voltage rating
c. Decrease the internal resistance
d. None of these
TRUE OR FALSE
10. For higher reliability, the MTBF of the equipment should be high.
F
11. The harmonics of a signal is measured using the Oscilloscope.F
14. A photo diode is used for converting thermal energy into light
energy. F
3. MODEM
7. Thermal Imager