MOUNTING INSTRUCTIONS- AUXILIARY HYDRAULIC CONTROL KIT
Frame Mounted-Two Unit Control-M-500 Gasoline, LP. Gas, Electric & M-600 Electric
Figure 1
Before installing auxiliazy hydraulic control kit, be certain that machine ie not running
and auxiliary foot pedal (center pedal) is in neutral position.
TE: When making connections, it is important that all fittings be free of dust and dirt.
With two 1/2" NPT x 1/2" JIC straight adapters, connect male half of quick coupler
(Figure 1; tem 1) to shortest tube (Figure 1; Item 2), and female half of quick coupler
(Figure 1; Item 3) to longest tube (Figure 1; Item 4) and tighten securely.
Remove bolt from right side of foot pedal guard an‘ install tube line mounting bracket.
Replace and tighten bolt (Figure 1; Item 5). pba tee A .
3/8" x 3-3/4" hex
Mount hydraulic valve assembly to valve mounting plate with thr.
screws, spacers and nylock hex nuts (Figure 1; Item 6).
Loosely bolt valve and mounting plate to upright brace approximately 9" from top using
‘two 3/8" x 2-1/2" hex screws and nylock hex nute.
Position tube lines (shortest on top) against tube mounting bracket. Arrange tube lines
#0 one is on cach side of retainer bolt. Loosely bolt retainer strap to tube line mount-
ing bracket with one 3/8" x 1" hex screw and nylock hex nut (Figare 1; Item 7), DO NOT
TIGHTEN,
Remove the two 1/2" JIG plugs irom auxiliary hydraulic ports at rear of machine (Fig=
ure 1; Iteins 8 & 9). Connect longest tube line (Figure 1; Item 4) to front port of auxili-
ary hydraulic circuit (Figure 1; Item 8)and short upright tube (Figure 1; Item 10)to-rear
port of auxiliary hydraulic circuit (Figure JIC straight
adapters.
Item 9) with two 1/2 JIC x 1/NG INSTRUCTIONS- AUXILIARY HYDRAULIC CGNTROL KIT
ted -Two Unit Control-M-500 Gasoline, L.P, Gas, Electric « M-600 Electric
ort of hydraulic valve assembly connect hydraulic tube (Figure 1; item 10) asing
"to 1/2" NPT straight reducing adapter and one 1/2" NPT x 1/2" JIC 90° elbow.
auxiliary hydraulic control in the following manne’
srt pivot bushing into base of lever (Figure 2; Item i)
agh' grease fitting to base of lever {Figare 25 Item 2)
sgn linkage rod and connect to hydraulic valve assembly, secure with one 1/4"
ead hinge pin. Lock hinge pin in place with one 3/32" x 3/4" cotter pin.
iLtabes properly placed, tighten all fittings and connections. Check port side of
ie valve assembly to be suré-that unused ports are properly plumbed for attach-
If Sttachment is to be used at later date, plug ports.
bAs106
Tienes GebB)ctt-2