Professional Documents
Culture Documents
P/N: 750-3006
Fits John Deere 4700/4710/4720/4730, 4830, 4920/4930 Sprayers
Overview
A series of equipment-specific kits have been developed to allow the interface of
the AutoMate system with your product rate controller. This kit contains the
necessary components and instructions to connect AutoMate with the equipment
models listed above. Please read this manual thoroughly before beginning the
installation.
Kit Contents:
Unpack the installation kit and identify the required parts as shown.
Install the AutoMate interface onto the sprayer with the following steps.
Switch connector
-2-
4. Locate the #2 and #3 Pins on the Pin #’s
boom switches.
-3-
AutoMate Wire Connection Location
Black male Pin #3 wire connection
Black female Pin #3 boom switch
Boom #1
Red male Pin #2 wire connection
Red female Pin #2 boom switch
Brown male Pin #3 wire connection
Brown female Pin #3 boom switch
Boom #2
Red male Pin #2 wire connection
Red female Pin #2 boom switch
Blue male Pin #3 wire connection
Blue female Pin #3 boom switch
Boom #3
Red male Pin #2 wire connection
Red female Pin #2 boom switch
Black/White male Pin #3 wire connection
Black/White female Pin #3 boom switch
Boom #4
Red male Pin #2 wire connection
Red female Pin #2 boom switch
Brown/White male Pin #3 wire connection
Brown/White female Pin #3 boom switch
Boom #5
Red male Pin #2 wire connection
Red female Pin #2 boom switch
Blue/White male Pin #3 wire connection
Blue/White female Pin #3 boom switch
Boom #6
Red male Pin #2 wire connection
Red female Pin #2 boom switch
White/Black male Pin #3 wire connection
White/Black female Pin #3 boom switch
Boom #7
Red male Pin #2 wire connection
Red female Pin #2 boom switch
-4-
7. Connect the remaining boom
switches following the chart
-5-
JOHN DEERE AUTOMATE INSTALL SCHEMATIC
Disconnect boom switch connectors
and connect interface cable
-6-
To GPS
Receiver