Professional Documents
Culture Documents
Lifting point:
Lift through Release Block:
cage solid bar #REL-1519-2010 Pressure Relief Valve (PRV)
(2) Remove screws from top end-cap.
Slide transducer away from tube.
(1)Remove bolts from cage.
Check motor interconnect wire is
Bend cage arms outwards.
connected.
Slide cage away from beacon.
Disconnect to replace battery.
110mm
Releases: 70
Fault Finding
Operation
Did the 1519 Release ever work?
Unique Channel ID’s
If the answer is yes, either the battery is discharged or the unit is faulty. Look for mechanical damage.
0001 to 1024
Try resetting the beacon by removing the battery and leaving it disconnected for 30 seconds before
Status Messages reconnection.
Status Battery Voltages and Motor Status reported If there are no signs of mechanical damage, try replacing the battery.
Arm This flag indicates that the beacon is in an armed condition and may be released.
If these tests do not help or resolve the problem, contact Applied Acoustic Engineering immediately for technical
Released Indicates that a prime/release action has just completed assistance.
Commands Spares
All commands and settings to the 1519 are made acoustically using the PAM 3510 or Easytrak Nexus. For Release Block: Part Number REL-1519-2010
detailed operating instructions please see the operating manual for the surface systems. Battery Pack Part Number REL-1519-3000
Lifting Cage: Part Number REL-1519-2002
Get ID: In order to communicate with a 1519 the ID must be known. If unknown ‘Get ID’ Main Body O-Ring Part Number MEH000025
can be used to identify the beacon.
Set ID: To set the ID of the 1519.
Reset: To reset and clear all status flags within the 1519.
Battery Status 1519 returns battery levels.
Nominal Battery Pack Voltages are 6.0V Receiver and 18.0V Transmitter
Motor Status 1519 returns motor status
Arm To Arm the beacon prior to Release
Release / Prime To Activate the release, which will rotate the motor on the release for three minutes
to unscrew the block from the shaft.
Activating a Release
CONFIGURE ID ON
DECK UNIT
BATTERY STATUS
See the PAM 3510 or Easytrak Nexus manual for more detailed instructions for release operation.