You are on page 1of 2

EXPERIMENT NO : DATE :

TITLE: CRO BEAM ADJUSTMENT

AIM: - (1) To bring the beam on CRO.


(2) Connect input to CRO.
(3) Selecting proper channels, volt/ div, time / div.

APPARATUS:-CRO, CRO probe, function generator.

PROCEDURE:
(A) LOCATE FOLLOWING IMPORTANT SWITCHES.
 Power on/off.
 Intensity.
 Focus.
 X- Position (x-shift).
 Y- Position (y-shift). For channel 1 & 2 (optional )
 Time/div.
 Variable time.
 Volt/div.
 Variable volt (optional).
 Triggering.
 Channel selection.
 AT/ normal.
 Level.
 Switches for type of inputs (AC, DC, and GND).
 input of channel -1
 input of channel -2
 GND connector
(B) ADJUSTMENT ON CRO
1. Deselect or unpress or release any press switches.
2. Remove any cable or connected accessory.
3. Bring variable volt and variable time knob on cal position.
4. Switch on power switch.
5. Adjust intensity and focus at middle level and further adjust it for proper appearance of
beam.
6. Select any channel (i.e. channel 1, 2 or dual).
7. Adjust time /div, x-position, y-position to bring the beam.
8. Connect function generator with any one channel of CRO and try to observe sinusoidal
output.
9. We can measure peak to peak voltage of AC wave form , periodic time of AC wave
form and DC voltage by using CRO .

CONCLUSION:

You might also like