Professional Documents
Culture Documents
Transmit enable
Battery indicator
(in back) (on = enabled)
Signal Power
strength Transmit on LED
indicator enable/
disable
Power
on/off ABC signal/
Channel Mode select:
Normal/Test/ 0 crossing
selector
External
Channel
Channel Selects one of eight selector
Coarse Fine
selector receiver channels
adjust adjust
Signal strength Indicates signal strength
indicator of selected channel
a. Beginning at the transmitter antenna of the a. Turn on the second transmitter’s signal.
reference system, place the sense coil against b. Switch the receiver channel to the channel used
or near the transmitter coil. Position the coil for by the second transmitter and verify that the
the strongest possible signal. receiver signal from the second transmitter is
b. Verify that channel 1 shows the proper aligned properly. You can verify that it is aligned
transmitter burst signal (Figure 3). properly by comparing it with systems phased
c. While watching the receiver signal and burst previously using the scope and sense coil.
signal on the oscilloscope, adjust the Phase Continue phasing systems as described in Step B. No
Adjustment pot on the first transmitter module timing adjustment are required because of the second
so that the burst signal starts at the Falling transmitter.
Edge of any one of the three pulses (Figure 4). Remove the first transmitter and use it as necessary to
You are ready to begin phasing other systems to the extend beyond the range of the last transmitter location
reference signal. and so on. Each time you setup a new transmitter, you
must realign the new signal with the current reference
B. Synchronize systems within the range of signal as done in step C.
the reference transmitter.
1. At the next system, place the sense coil at or Figure 3. Transmitter burst aligned to one of
near the transmitter antenna.
ABC phase signals (viewed at 4ms/Div)
2. Verify that you are still receiving a clear ABC
signal from the receiver (Figure 3). Phase C Phase A Phase B