Professional Documents
Culture Documents
CARTOGRAPHY LAB
CRAG 212L- G145
2. “PDSIZE” COMMAND
Command: PDSIZE <enter>
Enter new value for PDSIZE: 1 <enter>
3. “PDMODE” Command
Command: PDMODE <enter>
Enter new value for PDSIZE: 35 <enter>
Note:
C – circle
Re – regenerating windows/refresh
Z- zoom > E- extent
E- erase
X – explode
ESC- escape/ to cancel command
L – line
PL – polyline
CO/CP – copy
PO – points
F – Fillet
BO – boundary creation
Line <enter>
Specify first point: Click the “center of the circle”
Specify next point: type “@distance<bearing” <enter>
Example: @989.56<N34d42’E <enter>
Specify next point: type the next line (same format)
Line DISTANCE BEARING
T-1 1005.60 S 23 d 45’ E
1-2 20.2246 N 62 d 49’ E
2-3 13.0828 S 51 d 5’ E
3-4 16. 8873 S 22 d 39’ W
4-5 29.8707 N 83 d 6’W
5-1 13.5781 N 36 d 2’ E
*Check the end points ( if the end point and starting point does not closed)
***in the command line shows the AREA and PERIMETER of the object/polygon
B. Using Northings and Eastings (Rectangular Coordinates)
1. PO <enter>
Specify a point: input “Eastings, Northings” <enter>
<enter> to repeat the command
input “Eastings, Northings” <enter>