Professional Documents
Culture Documents
Home
New
Top
Sitemap
Contacts
Search
Hint
: components:
otice
: be sure to tape the tip of the screwdriver when using it to disengage the meshing of the clips and
claws.
Hint
: indicate the bolts, screws and nuts, which are necessary for installation and removal of the
instrument panel, in the illustration and the text with alphabets.
2. Precaution
Hint
11. Remove floor shift shift lever knob sub–assy (m/t transaxle)
Hint
Notice
Hint
a. Remove the screw<i> from the glove compartment door stopper sub–assy.
b. deform the upper part of the glove compartment door assy to release the stoppers.
c. pull the glove compartment door assy upward to remove it.
a. Disengage the clip, then remove the glove compartment door stopper sub–assy.
a. Using a screwdriver, disengage the 4 claws, then remove the parking brake hole cover
sub–assy.
Hint
a. Using a screwdriver, disengage the 7 claws, then remove the front door scuff plate lh.
Hint
Other materials:
Circuit description
The side squib (rh) circuit consists of the airbag sensor assy center and front seat airbag assy
(rh). It causes the srs to deploy when the srs deployment conditions are satisfied. Dtc b0110/43
is recorded when a short is detected in the side squib (rh) circuit. Wiring diagram ...
Inspection procedure
1 Inspect fuse(ecu–ig fuse) Remove ecu–ig fuse from the instrument panel j/b. check continuity
of ecu–ig fuse. Ok: continuity 2 Inspect battery Ok: voltage: 10 – 14 v 3 Inspect skid control ecu
connector(ig1 terminal voltage) In case of using hand–held tester: ...