Professional Documents
Culture Documents
INDEX
For analyzers with brand new PC, follow all instructions in Section 2.
For analyzers already supplied with the PC or in case of software
updates, follow instructions in Section 3.
Section 1: Overview of the Installation disk functions
Insert the CD-ROM containing the operating program of the analyzer in the CD-ROM drive.
The following screen appears:
NOTES:
Whichever PC or operative system you have, the next instructions must be followed.
- stand-by: the energy saving mode must be disabled
- the UAC must be disabled
- the access to the operative system must always be in administrator mode
- Windows firewall must be disabled
- system characters must be in standard format (96 dpi)
- the energy saving stand by mode due to the closing of the PC cover must be disabled
Section 2: analyzers supplied without PC
ATTENTION: all the below instructions definition (sentences in the menus) may
change due to the operative system, installed service pack or the kind of PC used.
Please, refer always to the PC/OS instructions manual.
This operation must follow the "Disable Stand-by and Suspend" and must be followed
by the procedure "Disable Stand-by on USB".
Figure 1
NOTE: before installing the operative program, make sure that on the PC
there is already installed at least a default printer.
PRINTER INSTALLATION
Open the Printers window (=> Start button => Settings => Printers) and click on “New
Printer”, then follow the instructions. Otherwise, insert the printer’s installation disk into the
driver and follow the printer’s setup instructions.
Make sure that the CD-ROM containing the operating program of the analyzer is still in the
CD-ROM drive. If not, insert the disk and wait until the window shown in fig. 1 appears.
Click “NEXT”.
CAUTION:
DO NOT INTERRUPT THE ONGOING INSTALLATION, UNLESS FOR SERIOUS REASONS.
Now the operating program has been installed correctly in the system.
2.3. Installing the analyzer configuration
All analyzer settings have already been performed in factory. Mechanical calibrations, FCC
and other settings have been saved into a USB pen drive, and must be imported into the
analyzer's new PC in order to make the instrument ready to use.
Insert the USB pen drive into the PC. Double click on the file Configuration.exe and the
following window will appear.
Figure 2
Click on the button "Restore". At the question "Are you sure to overwrite the actual
configuration?" answer "Yes"
Let the PC load the configuration.
Now it is possible to start the analyzer operative program.
Type the Installation Key available in the file named “Install_CD_Key” (which is one of the
unzipped files in the folder)
Click Ok
Click on Advanced User
Click Ok