Professional Documents
Culture Documents
The Set value can be adjusted when the button when the display is still
SINGLE OUTPUT controller is displaying the process showing . Significant only when is set to
TEMPERATURE CONTROLLER temperature. *** If the controller is locked (Controller will be Adj from 1 to 300 Seconds
OPERATING INSTRUCTIONS FPress the button. The display shows locked if the configuration parameter has Default: 1 Sec.
the SET VALUE. or value) then at step 4 above the
Model: 7E1
FTo change; keep the button pressed user will be required to enter the correct
password (as in ) in order to proceed.
and using either or button to OFF Persistance time
increase or decrease the set value Config Parameters
respectively. Significant only when is set to
† is the factory default value.
FKeeping either or button pressed Adj from 1 to 300 Seconds
for more than 2 seconds will result in a Sensor Selection Default: 1 Sec.
rapid change of the value. Pt100DIN
Pt100JIS
Configuration Nickel120
Cycle time
Before the controller can be used, it has † J type
to be configured properly. This can be Significant only when is set to
K type
done as follows: Adj from 2 to 300 Seconds
Congratulations E type
üRemove power to the controller. Default: 8 Sec.
T type
on selecting this state of the art üKeep the button pressed and then
microcontroller based instrument. apply power. Pt100DIN
Please read the following before use üWhen the display shows release Pt100JIS Res: 0.1°C Maximum duty clamp
4 digit display
the button. Nickel120 model only Significant only when is set to
~WARNING Serious injury may result if instructions
are not followed.
üOn releasing the button the display
shows . *** Adj from 60% to 95%
I This unit is not designed as a safety device. Control type
I Failure of devices, such as the thermocouple/ RTD sensor, üPress the button briefly the display Default: 90%
heater, output Relay, SSR or temperature controller itself
can result in severe damage to a product while in process,
shows . Now press the button. † Heating control
melting of the heater or a damaging fire. The display now shows the selected
I An over-temperature protection device must be installed in Cooling control
your process that will remove all power from the heating
sensor.
circuit if the above failure occurs. üPress or button to change the Minimum duty clamp
I Failure to install temperature limiting control protection
where a potential hazard exists could result in damage to sensor. Control method Significant only when is set to
equipment and property and fatal injury to personal.
üAfter the desired sensor is displayed, † ON/OFF Adj from 5% to 40%
press the button again. The display Default: 10%
~CAUTION Product may be damaged or injury may
result if instructions are not followed. now shows again.
Time Proportional