Professional Documents
Culture Documents
Tutorial SNSC 2.2 - 2.3 - 2.4
Tutorial SNSC 2.2 - 2.3 - 2.4
Prerequisites
1 male 5-pin green July cable (do not cut the iot module cable because we will need it)
1 pc with windows
1 cp2102 uart adapter
and the latest version of ninebot iap
Step 1 remove the 2 large T27 screws that hold the iot module
2nd step
once the 7 cruciform screws have been removed you will have a card like this disconnect the
speaker, the small battery and remove the sim card which is on the back under a black mass
remove the black mass then you can remove the sim card
Step 4 connect uart adapter to scooter
and if it is not yet done install the latest version of ninebot iap
https://iap.scooterhacking.org/
Step 6 connect uart to ninebot iap
if you have a second socket as in the photo below then reconnect the iot and uart module in
parallel otherwise follow the step below
if you only have one socket then you will have to connect uart and once the scooter is
unlocked you should reconnect the iot module
once that's done, go to ninebot iap and you should have the same thing as the image below
Click on unlock and normally the scooter will have to be unlocked and display the same thing
as in the photo below
if everything has been done correctly it should work and if ever the front light does not turn
on then disconnect and reconnect the iot module.
and if you want to turn off the scooter, either you do it via iap by clicking on lock or otherwise
by disconnecting the battery, this is the simplest method I could find because at least
everything works correctly