Professional Documents
Culture Documents
NOTIFICATION
(Bokar Basar),
Under Secretary (PWD),
Govt. of Arunachal Pradesh
Itanagar – 791 111
Page : 1
1 Title: (1) These rules may be called the ‘Arunachal Pradesh Enlistment of
contractors in Works Departments Rules, 2008’.
(2) It shall extend to whole of the state of Arunachal Pradesh.
(3) It shall came into force on the date of their publication in the
Arunachal Pradesh Gazette.
2 Short Title: Hereinafter these rules shall be referred to as ‘Enlistment Rules
2008’ for the sake of brevity.
The term Arunachal Pradesh Works Departments or (AP WD) wherever
occurs, shall be deemed to include, works departments like Public Works
Department (PWD), Rural Works Department (RWD), Public Health
Engineer Department (PHED), Water Resource Department (WRD),
Department of Hydro-Power Department (DHPD), Urban Development &
Housing Department (UD&HD), Rural Development Department (RDD) etc
under Government of Arunachal Pradesh.
3 Repeal and Saving
3(1) All rules regarding enlistment/revalidation of contractors existing, or
adopted in AP PWD by extension from CPWD, before coming into
force of Enlistment Rules 2008 are hereby repealed.
3(2) Notwithstanding such repeal, the contractors if already enlisted on the
basis of rules earlier in force or adopted by extension in AP PWD shall
continue to enjoy the status of enlisted contractors of AP WD till the
period of such enlistment, including revalidation/extension granted
before coming into effect of the Enlistment Rules 2008, expires.
However, in regard to all other matters and further revalidation of their
enlistment, they shall be governed by the Enlistment Rules 2008.
4(1) No individual, or a firm having such individual as one of the partners, who is
a dismissed government servant, or removed from the approved list of
Contractors, or black listed demoted to lower class, or having business
banned/suspended by any government department in the past, or convicted by
a court of law shall be entitled for enlistment.
15(1) If a firm is converted in two or more firms by any action of its partners, the
new firm(s) or any separated partner(s) in his/her(their) individual/joint
capacity shall have to apply for the enlistment afresh on the basis of work
experience gained as a separate entity.
15(2) If new partners are taken in the firm, each new partner shall have to satisfy
the eligibility conditions mentioned in Rule 4.
15(3) If the number of original partners of a firm reduces to less than half due to
any reason including death of partner(s), the enlistment of the firm shall be
withdrawn. Original partners means the constituents at the time of enlistment
and those who have remained as constituent for more than 5 years.
16 Change in Address - While applying for enlistment, the contractor should
mention address of his/her Registered Office as well as Head Office, if
change. All documents i.e., Banker’s Certificate, Electrical License etc.
should bear one of the above addresses; otherwise the same shall not be
accepted. Registered Office of contractor has to be in the same area or
jurisdiction for tendering of class and category in which enlistment is sought.
16(1) The contractor shall intimate the change, if any, in any of the above addresses, in advance
or maximum within one month of such change along with acknowledgement of noting
down of such change in address from the Bank, Income Tax, Sales Tax authorities etc.
Failure to do so may result in removal of his/her name from the approved list of contractors.
19 (1) Revalidation of Enlistment - The validity of initial enlistment of the contractor shall be
as given in Rule 7. It shall, however, be revalidated on merits, if desired by the contractor.
Only the contractor who has secured two works of appropriate magnitude (as applicable
for enlistment in relevant class) in AP WD, RWD, PHED, WRD, DHPD, UD&HD, RDD
Government of Arunachal Pradesh during the period of enlistment or last revalidation
period of enlistment as the case may be with at least one of them having been completed
100% and the second work completed more than 50% shall be considered for revalidation.
If second work is not completed by more than 50%, the department will select one non-
AP WD work out of the list furnished by the applicant for inspection and consideration of
revalidation. The work completed/secured as an associate contractor of the main
contractor, to whom a composite contract was/has been awarded, shall also qualify for
consideration of revalidation.
20(2) In cases where the application is received within three months after date of
expiry of enlistment/revalidation, the application can be accepted with
double the revalidation processing fee. Applications received, thereafter, shall not be
accepted and contractor should apply for fresh enlistment as per rules.
20(3) Late fee shall be as Enlistment fee. This is payable in the form of Demand
Draft in favour of the authority, as authorized by enlisting authority.
20(4) On receipt of application for revalidation complete in all respect and with all
necessary documents, provisional extension up to six months from the date of
expiry of enlistment/date of issue of order, which ever is later may be issued.
21 Annual Confidential Report of Contractors (ACRC):
21(1) Contractors will be required to complete the form of Annual Confidential
Report of Contractor (ACRC), in duplicate as per Annexure-VII, on
completion of work or every year in respect of works being executed by
him/her under the AP WD Division and submit one copy of the same to the
concerned Executive Engineer/Assistant Engineer of the concerned authority
by 15th January. Second copy of the ACRC bearing acknowledgement of
Executive Engineer/Assistant Engineer along with list of works as per
Annexure - VII be submitted to enlisting authority by 31st January. This
ACRC will be for the works done by the contractor for the period from 1st
January to 31st December of the previous year or part thereof. Depending
upon criteria fixed by the enlisting authority in respect of ACRC, contractors
will be considered for revalidation. The enlisting authority reserves full right
for fixing criteria for evaluation of ACRC.
21(2) The list of all works, pertaining to AP PWD and non-AP PWD, secured , in
hand and completed during above mentioned period, shall be furnished as per
Annexure-III. In case, the contractor hides any information, his/her
revalidation will be liable to be cancelled.
(a) Prior approval shall be obtained from the enlisting authority before
changing the constitution of the firm/company.
(f) He should not indulge in unethical practices and shall maintain good
conduct
(g) He shall execute the works awarded to him/her strictly as per the terms
and conditions of the contract and specifications.
24 Disciplinary Actions: The contractor shall have to abide by all the Rules of
Enlistment and also by the terms and conditions of the contract and the
Notice Inviting Tenders. He shall have to execute the works as per contract
on time and with good quality. The enlisting authority shall have the right to
demote a contractor to a lower class, suspend business with him/her for any
period, debar him/her or remove his/her name from the approved list of
contractors indefinitely or for a period as may be decided by the authority,
after issue of a show cause notice. Decision of the enlisting authority shall be
final and binding on the contractor. The following actions of the contractor
shall, in general, make him/her liable to disciplinary actions:-
24.1 Demotion to a lower class: The contractor shall be liable to demotion to a
lower class, by the enlisting authority, if he:
(g) any other reason which in view of enlisting authority is adequate for
his/her demotion to a lower class.
24(3) Removal from the approved list: The name of the contractor may be
removed from the approved list of contractors, by the enlisting authority, if
he:
(a) has, on more than one occasion, failed to execute a contract or has
executed it unsatisfactorily; or
24(5) Restoration:
(a) The enlistment authority on recommendation from Circle/Zone office and
being satisfied with the merit of each case, to be recorded in writing,
may revoke the order of suspension of business, demotion to lower class
or removal from the list when:
i) in respect of the same offence the accused has been honourably
acquitted by a court of law; or
ii) on review, the enlistment authority is of the opinion that the
punishment already undergone is adequate in the circumstances of the
case; or
(b) The order revoking earlier memorandum on suspension of business,
demotion to lower class or removal from the list, in respect of a
contractor, shall be circulated by the enlistment authority to all Zones /
Circles / Divisions of AP works departments under the State
Government.
25 Enlistment-cum-Disciplinary Committees:
To examine and recommend the cases for enlistment, revalidation and
disciplinary actions Enlistment-cum-Disciplinary committees may be
constituted as under:
26 Relaxation:
Subject to review and to encourage growth of contracting industry in the state
with inclusive participation of local contractors, enlistment under classes I, II,
III and IV of Civil category, concessions with relaxations shall be provided
on the qualifying criteria specified against Past Experience, Financial
Soundness, Engineering Establishment, T&P Machinery and Enlistment
Processing Fees for Arunachal Pradesh Scheduled Tribe (APST) contractors
as given in Table-1.
ANNEXURE- I
(See Rule 6)
ARUNACHAL PRADESH PUBLIC WORKS DEPARTMENT
APPLICATION FOR ENLISTMENT AS CONTRACTOR
CLASS CATEGORY
Issuing
Branch In whose favour
Draft No. Date Amount Bank &
drawn upon drawn
Branch
(1) (2) (3) (4) (5) (6)
17 Details of Works completed, in progress and secured during the last 5 years (to be filled
in proforma as given in Annexure –III). This list should include all works whose gross
amount of work done is more than the required magnitude for the class in which
registration is applicable.
18 Certificates from clients in original or attested copy as per proforma given in Annexure-
IV for eligible works.
Details of Works completed, in progress and secured during the last 5 years (to be filled in
proforma as given in Annexure –III). This list should include all works whose gross amount
of work done is more than the required magnitude for the class in which registration is
Certificates from clients in original or attested copy as per proforma given in Annexure-IV for
all eligible works.
Certificates :
(i) I/We (including all partners) certify that I/We have read the Rules of Enlistment of
Contractors in AP PWD as amended upto-date and shall abide by them.
(ii) I/We certify that the information given above is true to the best of our knowledge. I/We
also understand that if any of the information is found wrong, I am/ we are liable to be
debarred.
(iii) I/We certify that I/We will not get myself/ourselves registered as contractor(s) in the
Department under more than one name.
(iv) (a) I certify that I did not retire as an Engineer of Gazetted rank or as any Gazetted
Officer employed on Engineering or Administrative duties in any Engineering
Department of the Government of India during the last two years. I also certify
that I have neither such a person under my employment nor shall I employ any
such person within two years of his retirement except with the prior permission of
the Government. (For individuals seeking enlistment in their own name )
(b) We certify that none of the partners/Directors retired as an Engineer of Gazetted
rank or as any Gazetted Officer employed on Engineering or Administrative
duties of the GOAP in the last two years. We also certify that we have neither
under our employment any such person nor shall we employ any person within
two years of his retirement except with the prior permission of the Government.
(For partnership firms and limited companies).
Signature(s) of applicant(s) :
Date ………………………………………..
No of Documents attached □
ANNEXURE- II
(See Rule 6)
S.
Document Yes No
No.
1 Proof of constitution (Sl. No. 5) :
a) In case of sole proprietorship, Hindu Undivided
Family (HUF): an affidavit executed before a 1st
Class Magistrate that the applicant is the sole □ □
proprietor of the firm/Karta of HUF.
b) In case of partnership firm: (Submit attested copies)
i) Partnership deed attested by Notary Public □ □
ii) Form ”A” or equivalent form issued by
Registrar of Firms □ □
iii) Form “B” or equivalent form issued by
Registrar of Firms □ □
iv) Form “C” or equivalent form issued by
Registrar of Firms □ □
c) In case of Private/Public Ltd Co. Article of Association duly attested by Notary
Public.
2 Power of attorney, if any (Sl.no..8), attested by Notary
Public. □ □
3 Banker’s/Working capital certificate/Working Capital
certificate in original from scheduled bank in the Proforma
given in Annexure-V. The certificate should be on the □ □
bank’s letter-head and in sealed cover and shall be
addressed to the concerned Enlistment Authority (Sl.no..9)
ANNEXURE- III
Date of
Tendered Amount
completed work
Date of start
Stipulated
was done
Actual
Sl No
Contractor’s Signatures
ANNEXURE -IV
(Para 18 of Annexure - I)
3 Agreement amount
and paid
execution of work ?
“Countersigned”
ANNEXURE - V
(See Rule 11.2)
This is to certify that to the best of our knowledge and information Shri / Smt. / M/s
…….……………..having marginally noted address, a customer of our bank are/is
respectable and can be treated as good for any engagement up to a limit of Rs…………
(Rupees…………………………….). This certificate is issued without any guarantee or
responsibility on the Bank or any of its officers.
Address
Ms/Shri …………
…………………….
(Signature)
For the Bank
Signature
For the Bank
Note: 1) Bankers’/Working capital certificates should be on letter head of the Bank and in
sealed cover addressed to enlistment authority.
2) In case of partnership firm, Bankers’/ Working capitalcertificate to include names of
all partners as recorded with the Bank
ANNEXURE - VI
(See Rule 15)
THE LIST OF DOCUMENTS/INFORMATION
REQUIRED TO BE SUBMITTED FOR CHANGE OF CONSTITUTION
A Documents to be submitted
1. Copy of proposed partnership deed duly signed/proposed Memorandum of
articles.
2. An undertaking sworn in before a 1st class Magistrate by all the partners to the
effect that the new firm will take over all assets and liabilities.
3. Dissolution deed/consent of retiring partners/death certificate in case of death of
a partner.
B Furnish the following details in respect of each partner with whom contractor's
firm want to enter into partnership
(Give supporting details where applicable)
i) Whether he is enlisted with AP PWD/MES/Railway/P&T/State PWD.
ii) Whether he is a dismissed Govt. servant.
iii) Whether he is a partner/director of any other firm enlisted with this Department/
MES/ Rly./P&T/State PWD.
v) Whether his name has been removed from the approved list of contractors or
demoted to lower class or orders banning/suspending business with him by any
department in the past.
ANNEXURE- VII
(See Rule 21.1)
Part I (To be filled in by the contractor in duplicate in respect of each work cost of which
falls within the range prescribed for eligibility as per Rule 19 of enlistment rules read with
Table- I. One copy be submitted to EE/AE and other, containing acknowledgement of receipt
and seal of Division/Sub Division office, be submitted to enlisting authority)
1. Period
2. Name & Address of contractor:
3. Class, Category and Enlistment No.:
4. Name & address of Enlisting Authority:
5. Name of Work
6. Name & Address of AP PWD Division:
Sl Item
7.1 Agreement No.
7.2 Estimated Cost/Tender amount
7.3 Stipulated date of Commencement& Completion
7.4 Percentage progress with date/actual date of
Completion
7.5 Gross amount of final bill/work done
7.6 Amount of compensation levied, if any
7.7 Amount of reduced rate items, if any
7.8 Did the contractor go for arbitration ?
7.9 If yes, total amount claimed and amount awarded
9.0 Note : This performance report, duly completed by EE/AE handling the agreement,
should be forwarded to reporting officer of corresponding Class of enlistment .The
counter signing officer, after the report is duly completed, will forward the report to
enlisting authority within two weeks of its receipt from the contractor.
Class I II III IV V
Reporting E.E. E.E. A.E. A.E. A.E.
Officer
Reviewing S.E. S.E. EE. E.E. E.E.
Officer
Counter C.E. C.E. S.E. S.E. S.E.
Signing
Officer
Report to be CE (D&P) CE(D&P) C.E (D&P) C.E (D&P) CE (D&P)
sent to
1. Period:
2. Name & Address of contractor:
3. Class, Category and Enlistment No.:
4 Name & address of enlisting authority:
5. Name of Work
6 Name & Address of AP PWD Division:
Reporting Officer
(Designation and Address)
*General remarks may include excessive cutting /over writing in tenders, unsubstantiated
allegations, misbehavior, theft of Govt. material, responsiveness, litigative mindedness,
conduct etc.
ANNEXURE- VIII
(See Rule 20.1)
(The applicant should study carefully the Rules of Enlistment and the list of documents to be
annexed with the application form before filling the form. Application found deficient in any
respect are liable to be rejected without any further correspondence)
CLASS CATEGORY
4. (a) Phone
(b) Fax
(c) e-mail
5. Constitution Individual □ Sole Proprietorship Concern □
Partnership Firm □ Public Ltd. Company □
Private Ltd. □
Company
6. If partnership firm, names of the partners/ If Company, name of directors
1 …………………………. 2 ………………………….
3 …………………………. 4 ………………………….
5 …………………………. 6 ………………………….
7. (a) Name of persons holding power of attorney ………………………….
(b) Nationality Indian □ Other □
8 Name of Bankers with full address …………………………………..
11 Does the applicant have sufficient T&P, Machinery, Equipment and workshop as per
requirements mentioned in the Enlistment Rules for the class & category applied for
16 Certificates:
(i) I/We (including all partners) certify that I/We have read the Rules of Enlistment
of Contractors in AP PWD as amended upto date and shall abide by them.
(ii) I/We certify that I/We will not get myself/ourselves registered as contractor(s)
in the Department under more than one name,
(iii) I/We certify that the information given above is true to the best of our
knowledge. I/We understand that if any information is found incorrect, our
enlistment is liable to be cancelled.
(iv) I/We certify that I/none of the partners/Directors retired as an Engineer of
Gazetted rank or as any Gazetted Officer employed on Engineering or
Administrative duties in last two years. We also certify that we have neither
under our employment any such person nor shall we employ any person within
two years of his retirement except with the prior permission of the Government.
(Strike out whichever is not applicable)
Signature(s) of applicant(s) :
2)
3)
4)
5)
Date ……………………………………..
No. of documents attached
ANNEXURE - IX
(See Rule 20.1)
DOCUMENTS ATTACHED FOR REVALIDATION
ANNEXURE - X
(See Rule 22)
CALCULATION SHEET FOR EVALUATION OF CONTRACTOR’S
PERFORMANCE IN AP PWD FOR REVALIDATION
Name of Contractor:
Name of Work:
Item Parameter Calculation for Points Score Maximum
No.
1. Time over ST - Stipulated 20 if TOR = 1.0 20
run (TOR) AT - Actual Time 10 if TOR = 2.0
TOR - AT / ST 0 if TOR = 2.5
(-) 5 if TOR = 3.0
2. Levy of Where (+) 10 if B =0 10
compensation C - Compensation levied (+) 0 if B = 1.5
for delay (-) 5 if B =5
E - Tendered Amount (-) 10 if B = 10
B - (C×100/E)
(No Point awarded if
compensation is not decided)
3. No. of works Number of works completed in 2 or more works = 10 10
in hand. last enlistment / revalidation 1 work =5
period
4. Quality Based on Annual Confidential Outstanding = 40 40
Report of Contractor Very Good = 30
Good = 20
Satisfactory =2
Poor = (-)10
Additional Point-
If reduce rates are
sanctioned = (-)10
5 Capability
Note: -
i) Marks for values in between the stage is to be determined by straight line
variation.
ii) Mark in respect of each parameter under different ACRC for same works
are to be averaged out except for parameter under item-1.
iii) Under each parameter, marks given will be over all average of all works.
iv) Eligibility criteria for revalidation of enlistment will be 50% marks under
each item (over all average of all works) with over all minimum marks as
60%
Table – I Appendix-I
ENLISTMENT RULES - 2018
(See Rules 8, 9, 10, 11 & 12)
1 2 3 4 5 6 7 8 9
General General General General
General Category General Category General Category
Category Category Category Category
Civil IAA Whole of Unlimited Three composite works ₹ 160.00 1) Registered as private A. Piling Equipment
Arunachal of Building and Roads Crore limited company under 1. Pile Driving Equipment ₹ 7.50 Lakh
Pradesh. costing ₹ 80.00 Crore company Registration Act. Augur Type = 4 No(s)
each.
Or alongwith 2) Graduate Engineer (Civil) 2. Tower Crane = 4 No(s)
avarage turn with minimum B. Instruments
over of 25 years experience = 2 No(s) 1. Total Station = 2 No(s)
By Chief Two composite works ₹ 160.00 3) Graduate Engineer (Civil) C. Concreting Equipment
Engineer of Building and Roads Crore per yer with minimum 15 years
in last 5 years. 4 No(s) 1. Steel Shuttering = 30000 Sqm
(CSQ) PWD costing ₹ 120.00 experience =
AP Itanagar Crore each. 4) Graduate Engineer (Civil) 2. Steel Props = 60000 Cum
with minimum 6 years
Or
experience = 4 No(s) 3. Concrete Mixers of full
Note: - One composite works 5) Graduate Engineer (Civil) bag capacity = 5 No(s)
Registered of Building & Roads with minimum 10 years 4. Mortar Mixer = 4 No(s)
office of costing ₹ 160.00 experience = 4 No(s) 5. Vibrators
contractor has Crore and above. Or i) Needle Vibrator (15 Oil
to be in the Diploma Engineers (Civil) and 15 Electric) = 30 No(s)
same area as The composite work each with minimum ii) Beam Vibrator = 4 No(s)
jurisdiction for means Civil &Electrical 10 years experience as iii) Slab Vibrator= 6 No(s)
tendering of Building Work and at surveyor = 4 No(s) iv) Vibro Compactor 2 No(s)
class and least three of the E & M 6) Graduate Engineer (Civil) 6. Batching Plant of 15
category in services mentioned with minimum experience cum capacity with Pump = 10 No(s)
which below under one 8 years as Quality Engineer
enlistment is agreement = 1 No(s) 7. Transit Mixer with
sought.
7) Diploma Engineers (civil) Pump i/c all equipment = 5 No(s)
each with minimum
(i). Fire Fighting 8 years experience as D. Lifting & Transportation
(ii). Fire alarm surveyor = 2 No(s) Equipment
(iii). HVAC 8) Graduate Engineers (Civil)
(iv). Lift each with minimum 1. Builder Hoist = 4 No(s)
(v). Electrical sub 6 years experience in 2. Truck / Tippers = 20 No(s)
Project Planning/Billing 2 No(s)
Engineer
Page : 33
1 2 3 4 5 6 7 8 9
9) Graduate Engineers
(E&M) with 25 years E. Pavement Equipment
(vi). DG Set. experience = 1 No(s) 1. Wet Macadam Mix
And the applicant must 10) Graduate Engineer Plant = 6 No(s)
have executed at least (E&M)with 20 years 2. Paver finisher = 6 No(s)
one work of experience = 1 No(s) 3. Road Roller = 6 No(s)
construction of one 6 No(s)
11) Graduate Engineer (E&M) 4. Vibratory Road Roller =
5 storey building either
with 5 years experience = 1 No(s) F. Earthmoving
in the eligible works Equipment
mentioned above or
some other building Or 1. Bulldozer = 6 No(s)
work of ₹ 80.00 Crore, Diploma Engineer (E&M) 2. Excavator cum Loader = 6 No(s)
Road work FC,GSB with 10 years experience =
I,II,III, Carpeting, Seal 4 No(s)
coat, R/Wall, B/wall,
CC Pavement,
protection work, Bridge Note:-
Work. At least 1(one) APST
Degree holder & 1(one)
APST Diploma holder
Engineer must be in his
establishment of the
contractor under Class
IAA.
APST APST APST
APST Category APST Category APST Category APST Category
Category Category Category
Civil IAA Whole of Unlimited Three composite works ₹ 100.00 1) Registered as private A. Piling Equipment
Arunachal of Building and Roads Crore limited company under 1. Pile Driving Equipment ₹ 5.00 Lakh
Pradesh. costing ₹ 40.00 Crore company Registration Act. Augur Type = 4 No(s)
each. 2. Tower Crane = 4 No(s)
Or alongwith 2) Graduate Engineer (Civil)
Two composite works avarage turn with minimum B. Instruments
of Building and Roads over of 25 years experience = 2 No(s) 1. Total Station = 2 No(s)
costing ₹ 50.00 ₹ 100.00
By Chief 3) Graduate Engineer (Civil)
Crore each. Crore per yer
Engineer with minimum 15 years C. Concreting Equipment
in last 5 years.
(CSQ) PWD Or experience = 4 No(s) 1. Steel Shuttering = 30000 Sqm
AP Itanagar One composite works 4) Graduate Engineer (Civil) 2. Steel Props = 50000 Cum
of Building & Roads with minimum 6 years 3. Concrete Mixers of full
costing ₹ 100.00 experience = 4 No(s) bag capacity = 5 No(s)
Crore & above.
Page : 34
1 2 3 4 5 6 7 8 9
1 2 3 4 5 6 7 8 9
Note:-
At least 1(one) APST
Degree holder & 1(one)
APST Diploma holder
Engineer must be in his
establishment of the
contractor under Class
IAA.
1 2 3 4 5 6 7 8 9
D.
Lifting & Transportation
Equipment
1. Builder Hoist = 3 No(s)
2. Truck / Tippers = 8 No(s)
E. Pavement Equipment
1. Wet Macadam Mix
Plant = 2 No(s)
2. Paver finisher = 3 No(s)
3. Road Roller = 8 No(s)
4. Vibratory Road Roller = 3 No(s)
F. Earthmoving
Equipment
1. Bulldozer = 1 No(s)
2. Pokland = 1 No(s)
b) Group B - At least 1, 2,
3 and 5 of the list;
c) Group C - At least 1 of
the list;
d) Group D - At least 2 of
the list;
e) Group E - At least 1 of
the list.
2). For each individual
tender, however AP PWD
may lay down in the NIT
the T&Ps specifically
required.
Page : 37
1 2 3 4 5 6 7 8 9
1 2 3 4 5 6 7 8 9
1 2 3 4 5 6 7 8 9
One work costing 3) Diploma Engineer (Civil) 2. Steel Props = 12000 Cum
Note: - ₹ 30.00 Crore & above. each with minimum 3. Concrete Mixers of full
Registered 2 years experience = 2 No(s) bag capacity = 5 No(s)
office of 4. Mortar Mixer = 2 No(s)
contractor has 5. Vibrators
to be in the i) Needle Vibrator (5 Oil
same area as and 5 Electric) = 10 No(s)
jurisdiction for ii) Beam Vibrator = 2 No(s)
tendering of iii) Slab Vibrator= 4 No(s)
class and
category in iv) Vibro Compactor= 1 No(s)
which v) Shutter Vibrator = 6 No(s)
enlistment is 6. Batching Plant of 15
sought. cum capacity with Pump = 1 No(s)
C. Lifting & Transportation
Equipment
1 2 3 4 5 6 7 8 9
d) Group D - At least 2 of
the list;
e) Group E - At least 1 of
the list.
2). For each individual
tender, however AP PWD
may lay down in the NIT
the T&Ps specifically
required.
APST APST APST
APST Category APST Category APST Category APST Category
Category Category Category
Civil I Whole of Three works costing ₹ 25.00 1) Graduate Engineer (civil) A. Instruments ₹ 3.00 Lakh
Arunachal ₹ 30.00 ₹ 8.00 Crore each. Crore having 5 years experience 1. Total Station = 1 No(s)
Pradesh. Crore with exposure to Planning
2. Dumpy level with
and Design of Shuttering / 2 Set(s)
Or staff =
Props =
Two works of costing 1 No(s) 3.Compass with chain and
₹ 12.00 Crore each. 2) Diploma Engineer (Civil) ranging rod = 2 Set(s)
Or with minimum 5 years B. Concreting Equipment
One work costing experience = 1 No(s) 1. Steel Shuttering = 3500 Sqm
By Chief ₹ 25.00 Crore & above. 3) Diploma Engineer (Civil) 2. Steel Props = 10000 Cum
Engineer each with minimum 3. Concrete Mixers of full
(CSQ) PWD 2 years experience = 2 No(s) bag capacity = 3 No(s)
AP Itanagar 4. Mortar Mixer = 2 No(s)
5. Vibrators
Note: - i) Needle Vibrator (4 Oil
Registered and 4 Electric) = 8 No(s)
office of ii) Beam Vibrator = 1 No(s)
contractor has iii) Slab Vibrator= 2 No(s)
to be in the iv) Vibro Compactor= 1 No(s)
same area as v) Shutter Vibrator = 3 No(s)
jurisdiction for 6. Batching Plant of 15
tendering of cum capacity with Pump
class and = 1 No(s)
category in C. Lifting & Transportation
which Equipment
enlistment is
sought. 1. Builder Hoist = 1 No(s)
2. Truck / Tippers = 3 No(s)
Page : 41
1 2 3 4 5 6 7 8 9
D. Pavement Equipment
1. Paver finisher = 1 No(s)
2. Road Roller = 3 No(s)
3. Vibratory Road Roller = 1 No(s)
E. Earthmoving
Equipment
1. Bulldozer = 1 No(s)
2. Excavator cum Loader = 1 No(s)
Note :-
1). Contractor seeking in
Class I under Civil
category shall possess
equipment as follows :-
a) Group A - All of the list.
b) Group B - At least 1,
2, 3 and 5 of the list;
c) Group C - At least 1 of
the list;
d) Group D - At least 2 of
the list;
e) Group E - At least 1 of
the list.
2). For each individual
tender, however AP PWD
may lay down in the NIT
the T&Ps specifically
required.
General General General General
General Category General Category General Category
Category Category Category Category
Civil II Whole of Three works costing ₹ 8.00 Crore 1) Graduate Engineer (civil) A. Instruments ₹ 2.30 Lakh
Arunachal ₹ 8.00 Crore ₹ 3.00 Crore each. having 5 years experience
1. Dumpy level with
Pradesh. with exposure to Planning
Or staff = 2 Set(s)
and Design of Shuttering /
Two works of costing Props = 2.Compass with chain and
1 No(s)
₹ 5.00 Crore each. ranging rod = 2 Set(s)
Page : 42
1 2 3 4 5 6 7 8 9
By Chief Or 2) Diploma Engineer (Civil) B. Concreting Equipment
Engineer each with minimum
One work costing 2 No(s) 1. Steel Shuttering = 3000 Sqm
(CSQ) PWD 5 years experience =
₹ 8.00 Crore & above. 2. Steel Props = 9000 Cum
AP Itanagar
3. Concrete Mixers of full
bag capacity = 2 No(s)
4. Mortar Mixer = 2 No(s)
5. Vibrators
i) Needle Vibrator (3 Oil
and 3 Electric) = 6 No(s)
ii) Beam Vibrator = 1 No(s)
Note: - iii) Slab Vibrator = 2 No(s)
Registered iv) Vibro Compactor = 1 No(s)
office of C. Lifting & Transportation
contractor has Equipment
to be in the
same area as 1. Truck / Tippers = 3 No(s)
jurisdiction for D. Pavement Equipment
tendering of
1. Paver finisher = 1 No(s)
class and
category in 2. Road Roller = 3 No(s)
which 3. Vibratory Road Roller = 1 No(s)
enlistment is Note :-
sought. 1). Contractor seeking
enlistment in Class II
under Civil category shall
possess equipment as
follows :-
a) Group A - All of the list.
b) Group B - All of the list.
c) Group C - All of the list.
d) Group D - At least 2 of
the list;
2). For each individual
tender, however AP PWD
may lay down in the NIT
the T&Ps specifically
required.
Page : 43
1 2 3 4 5 6 7 8 9
APST APST APST
APST Category APST Category APST Category APST Category
Category Category Category
Civil II Three works costing ₹ 6.00 Crore 1) Graduate Engineer (civil) A. Instruments ₹ 1.20 Lakh
Whole of ₹ 8.00 Crore ₹ 2.00 Crore each. having 3 years experience 1. Dumpy level with
Arunachal Or with exposure to Planning staff = 2 Sets
Pradesh. and Design of Shuttering /
Two works of costing 2.Compass with chain and
Props = 1 No(s) 2 Sets
₹ 3.00 Crore each. ranging rod =
1 2 3 4 5 6 7 8 9
1 2 3 4 5 6 7 8 9
1 2 3 4 5 6 7 8 9
Note: -
Registered
office of
contractor has
to be in the
same area as
jurisdiction for
tendering of
class and
category in
which
enlistment is
sought.
1 2 sought.3 4 5 6 7 8 9
By SE of Or
concerned One work costing
APPWD circe ₹ 0.50 Crore & above.
Note: -
Registered
office of
contractor has
to be in the
same area as
jurisdiction for
tendering of
class and
category in
which
enlistment is
sought.
Page : 48
1 2 3 4 5 6 7 8 9
By SE of Or
concerned APST Unemployed Certificate for
APPWD circle Diploma Engineer working
(Civil) capital of
₹ 0.04 Crore
for at least
Note: - Or
last six
Registered
months.
office of
contractor has
to be in the Registered Co- Certificate for
same area as operative Society. working
jurisdiction for capital of
tendering of ₹ 0.04 Crore
class and for at least
category in last six
which months.
enlistment is
sought.
Page : 49
1 2 3 4 5 6 7 8 9
(B.Pertin)
Commissioner (PWD)
Govt. of Arunachal Pradesh
Itanagar
Page : 50
Past
Jurisdiction & Tendering Experience of Financial Engineering T&P Enlistment
Category Class Enlistment limit completed Soundness Establishment Machinery Processing
Authority works in last fee
5 Years
1 2 3 4 5 6 7 8 9
General General General
Category Category Category
Furniture I Whole of Arunachal Rs.1 Three works Banker’s Designers Properly fitted Rs.10,000
Pradesh; Crore of Rs 20 Certificate capable of workshop,
Lakh each. Of producing wall paints, polish
by Chief Engineer, Rs. 01 Crore. thought out and other
(CSQ) AP, PWD. furnishing large finishing
buildings. equipment.
Note:
Registered officer or APST APST
contractor has to be Category Category
In the same area as Rs.75 lakhs Rs. 7,500
jurisdiction for
tendering of class
and category in
which enlistment is
sought.
Furniture II Whole of Arunachal Rs. 25 Three works Banker’s _ Properly fitted General
Pradesh; Lakh. of Rs 06 Certificate workshop, Category
Lakh each. Of paints, polish Rs.5,000
By Rs. 25 Lakh and other
Chief Engineer, finishing APST
(CSQ) AP, PWD. equipment. Category
Rs. 4,000
Page: 51
1 2 3 4 5 6 7 8 9
Furniture III Within respective Rs. 10 Lakh. Three works of Banker’s - Properly fitted Rs.2,000
Zone of AP PWD; Rs. 2 Lakh Certificate Workshop, paint
each. Of Rs. 10 & other
by CE of concerned Lakh. finishing
AP PWD Zone equipment
- -
Furniture IV Within respective Rs 3.0 lakh Two works of Banker’s Rs 2.000
Circle of AP PWD; Rs. 50,000 each Certificate of
Or one work of Rs. 3.00 lakh
Rs. 1 lakh
By SE of concerned
AP PWD Circle Registered Certificate for
Cooperative Working
Society Capital of
Rs 20.000 for
at least last
six months
Page: 52
1 2 3 4 5 6 7 8 9
Horticulture II Whole of Arunachal Rs. 15 lakh Three works Banker’s B .Sc Matador -1 No. General
Pradesh; (excluding Certificate (Agriculture) Wheel Barrows Category
maintenance Of with minimum 5 (Rubber Rs. 5,000
by designated works) of Rs. 15 lakh years experience Tyres)-3 nos.
officer of the Horticultural -1 No Power lawn
concerned activity each Movers – 2
Department. costing Rs. 5 Nos.
lakh or more Power sprayer
excluding Rubber hose APST
cost of civil Pipe – 200m all Category
& implement for Rs. 4,000
electrical day to day
works working and
Carriage.
Horticulture III Within the Rs 7 lakhs Three works Banker’s Qualified or All implement Rs. 1,000
Designated area in (excluding Certificate Experienced for day to day
Arunachal Pradesh; Maintenance Of Rs. 7 employee with working and
Works) of lakh experience not carriage. No
by designated Horticultural less than 10 years T&P Shall
officer of the Activity each in be issued by the
concerned Costing Rs 2 Horticulture depot.
department Lakh or more activity.
Excluding
Cost of civil
&
Electrical
works.
Page: 54
1 2 3 4 5 6 7 8 9
Nursery Whole of Rs. 10 Lakh Three works Banker’s B .Sc Green House, Rs. 2000
Arunachal of nursery Certificate of (Agriculture) Poly House,
Pradesh: Activities Rs. 10 lakh. with 5 years’ Water
each costing At least two Experience resource like
By designated Rs. 2 Lakh or acres of land -1 No. Tube Well,
officer of the more. under Irrigation
concern plantation of system and
department. nursery. all implement
for day to day
Note: working.
Registered officer
of the contractor
has to be in the
same area as
jurisdiction for
tendering of class
and category in
which enlistment
is sought.
Page: 55
Past
Jurisdiction & Tendering Experience Financial Engineers T&P Enlistment
Category Class Enlistment limit of Soundness Establishment Machinery Processing
Authority completed fee
works in
last 5 Years
1 2 3 4 5 6 7 8 9
General General
Internal I Whole of Rs.2 Crore Three Category Graduate Engineer Steel/Aluminium leather Category
and Arunachal works of Banker’s ( E/M) with 1.5 m to 8 m - 2 Nos Rs. 10,000
External Pradesh: Rs. 30 Lakh certificate of minimum experience Chase Cutting
Electrical each Rs 2. crore of five years -1 No machines – 2 Nos
Installation By designated without Diploma holders Electrical wire drawing
Chief Engineer fittings or of (E/M) with equipment - 2 Nos
of Department Rs. 50 lakh minimum experience Torque Wrench for nut /
of power. each with APST of five years - 1 NoBolt/Screw -2 Nos APST
fitting. At category Conduit die set -2 Nos Category
Note: least one Banker’s Or Diploma holder Pipe vice - 2 Nos Rs. 7500.
Registered work should certificate of (E/M) with Bench vice -2 Nos
office of be of Rs. 1.50 minimum experience LT Meggar 1000
contractor has internal Crore of 10 Years – 1 No Volts -2 Nos
to be in the Electrificati Diploma Holder Tong Tester - 2 Nos
same areas as on on of (E/M) with Multi - Meter -2 Nos
jurisdiction buildings. minimum experience Hydraulically operated &
for tendering of 5 Years -1 hand operate cramping
of class and No machines - 2 Nos
categories in Earth Tester - 2 Nos
which Portable drilling
enlistment is machines -2 Nos
Sought. Overhead Conduit
Puller -2 Nos.
Page: 56
1 2 3 4 5 6 7 8 9
General General
Category Category
Internal II Whole of Rs.60 Three works Banker’s Diploma Chase cutting Rs. 10,000
&External Arunachal lakh of certificate holders Machine -2 Nos
Electrical Pradesh; Rs 10 lakh of Rs. 60 (E/M) with Electrical wire
Inclement Each lakhs minimum Drawing
by Without experience of 5 Equipment -2 Nos
designation fitting years -2 Nos Nos. Steel/ Aluminium
CE of or of Rs. 15 Lander 1.5 m to 8m -1No
DoP. Lakh each Conduit die set -1No
with APST Pipe vice -1 No APST
Fitting. At Category Bench vice -1 No Category
least one Banker’s LT Meggar 500V -1 No Rs. 7,500
work certificate Tong Taster -1 No
should be of of Rs. 45 No Multi Meter -1No
Internal lakhs Hydraulically
electrification Operator
of buildings. & hand operator
Crimping machines -1No
Earth tester -1No
Portable drilling
Machine -1No
Overhead conduit
Puller -1No
Page: 57
1 2 3 4 5 6 7 8 9
General
Internal III Within the Rs. 20 Three works Banker’s Diploma holders Chase cutting Category
& External Respective lakh of Certificate (E/M) with 3 Machine -2 Nos Rs. 5,000
Installation Zone of Rs 5 lakh of Rs.20 years Electrical wire
DoP; each. At Lakh. Experience Drawing Equipment -2 Nos
least one -1 Nos Conduit die set -1 No
works Pipe vice -1 No
by CE of Should be of Bench vice -1 No
the Internal LT Meggar 500 Volts -1 No
concern electrification Tong Taster -1 No
Zone of of buildings. Multi Meter -1 No APST
DoP. Hydraulically Operator Category
Or & hand operator Rs. 4,000
Crimping machines -1No
Unemployed Certificate Earth tester -1No
Graduate for Portable drilling
Engineer working Machine -1No
(E/M) Capital of Overhead conduit
Rs. 2 lakh Puller -1No
for at least
last six
month
Page: 58
General
HVAC I Whole of Three works Category Graduate Refrigerant gas Leak GENERAL
Arunachal of Rs.125 banker’s Engineer (Elect/ detector -1 No Category
Pradesh: Lakh each of certificate Mech.) with Anemometer -1 No Rs. 20,000
central of Rs 5 Minimum Hydraulic & hand operated
By designated A.C system crores Experience of 5 Crimping tools -1 No
Chief Engineer Comprising Years Pilot tube
of Department of In the trade manometer -1No
of power. 100 TR or APST -1 no Psychrometer -1No
more in each Category And Diploma Phase sequence APST
Note: case out of banker’s Holder (Mech) Indicator - 1No Category
Registered which at least certificate Each with Magnetic dial Rs. 15,000
office of one work of Rs. Minimum 5 Indicator - No
contractor has to should be 4.25 Years’ LT Meggar 1000 V -1No
be in the same with Crores Experience in the Acoustic
areas as centrifugal/ Trade -2 Nos Measurement meter -1No
Jurisdiction for screw type Hydraulic pressure
tendering of air Testing equipment -1No
class and conditioning Note: Gas welding machine -1No
categories in compressor In addition, the Cutting machine -1 No
which enlistment system. firm should Portable electric
is Sought. Separately have a Welding machine -1 No
fully equipped Portable drilling
Design Machine -1 No
Department with
Page: 59
1 2 3 4 5 6 7 8 9
Adequate Note: in addition, the firm
Engineers at Shall have manufacturing
their and testing facilities for at
headquarters least one of the following
equipment.
1) AC Compressors.
2)Condenser
3) Chillers
4)AHUs
AVAC II Whole of Rs. 150 Three works General Graduate Refrigerant gas General
Arunachal lakh Of Rs. 50 lakh Category Engineer(Mech) Leak detector -1 No Category
Pradesh; Each. At least Banker’s With minimum Anemometer -1 No Rs. 10,000
Two works Certificate Experience of 5 Hydraulic &hand operated
Should be of of years in the trade crimping Tools -1 No
by designated Central AC Rs. 150 -1 No Pilot tube manometer-1 No
CE of DoP. Plant of Lakh Psychrometer -1 No
Capacity 40 And Diploma Indicator -1 No
TR holder (Mech) Magnetic dial
or more in APST with minimum 5 Indicator -1 No APST
each case Category years’ LT Meggar 1000 V -1 No Category
Banker’s experience in the Acoustic Rs. 7,500
Certificate trade Measurement meter -1 No
of Rs. 120 -1 No Hydraulic pressure
lakh
Page: 60
Testing equipment -1 No
Gas welding and
cutting machine -1 No
Portable electric
Welding machine -1 No
Portable drilling machine -
1 No
HVAC III Within the Rs. 60 Three works General Diploma Refrigerant gas General
Respective zone Lakh Of Category holders (MECH) Leak detector -1 No Category
of DoP; Rs. 12 lakh Banker’s each with Anemometer -1 No Rs. 10,000
Each Certificate minimum Hydraulic & hand
Pretending Of Rs 60 experience of 5 operated crimping
By CE of the Of central Lakh years in the trade Tools -1 set
Concerned AC -2 Nos Pilot tube -1 No
Zone of DoP. Plants/package Pyschorometer -1 No APST
Type APST Phase sequence Category
A.C Category Indicator -1No Rs. 7,500
plant Banker’s Magnetic Indicator -1
Certificate No
Of Rs. 45 LT Meggar 1000V -1
lakh No
Acoustic measurement
Page: 61
1 2 3 4 5 6 7 8 9
Meater -1 No
Hydraulic pressure -1 No
Testing equipment -1 No
Cutting machine -1No
Portable electric -1 No
Welding machine -1No
Portable drilling
Machine -1 No
Past
Jurisdiction & Tendering Experience of Financial Engineers T &P Enlistment
Category Class Enlistment limit completed Soundness Establishment Establishment Processing
Authority works in last
5 Years
1 2 3 4 5 6 7 8 9
Diesel Whole of Rs. 2 Three works General Graduate Engineer (E/M) Phase sequence General
Generating I Arunachal crore of Category Having experience of not indicator -1 No Category
Sets (D.G. Pradesh; Not less then Less than three years in the Hydraulic and Rs. 20,000
SET) Rs. 30 lakh Banker’s Trade & Diploma (E/M) hand operated
By designated Each and Certificate Qualified Engineer, with crimping
Chief Engineer each Of Rs. 2 Not less than seven years tools - 1 No
Of Department Work should Crore experience in the design Magnetic dial
Of power. Involve D.G. erection testing and indicator -=1 No
Sets of commissioning of D.G portable electric
Note: Capacity Sets-1 No welding
Registered Not less then APST Firm desiring enlistment in machine -1 No
Officer of 380 K V A Category class should have an Portable drilling
Contractor has and engineering office capable machine -1 No
to Should be Banker’s of preparing estimate and earth tester -1 No
Be in the same OEM Certificate submitting bills regularly Battery tester -1 APST
Area as And OEA of Of Rs. for works done provided for No Category
Jurisdiction for One or more 1.50 in the contract. Their office Multimeter-1 No Rs. 15,000
Tendering of Reputed crore should have sufficient Tong
Class and makes tenders in an intelligent Tester - 1 No
Category in Of engineers manner and for supervisor
Which and of works.
Enlistment is alterations
Sought.
Page: 63
1 2 3 4 5 6 7 8 9
Diesel II Whole of Rs.60 Three works General One graduate Engineer Phase sequence General
Generating Arunachal ,Lakhs of not less Category (E/M) having indicator -1 No Category
sets( D.G Pradesh: than Rs. 15. Bankers experience of not less Hydraulic and hand
sets) Lakhs certificate of than two years in the operated cramping Rs. 10,000
By designated Each and Rs. 60 Lakhs trade, & a Diploma tools -1 No
CE of DOP. each works (E/N) qualified Magnetic Dial
should Engineer, with not less indicator -1 No
involve D.G APST than five years LT meggar
sets of categories experience in the 1000 V - 1 No
capacity not Bankers erection testing and Acoustic
less than250 certificate of commissioning of measurement
KVA and Rs. 45 Lakhs D.G. sets. Meter -1 No
should be Firm desiring Portable electric
OEM enlistment in this class welding machines -
and OEM of should have an 1 No
one or more Engineering office Portable Drilling APST
reputed capable of preparing of Machines -1No Category
makes of estimate and Earth tester -1 No Rs. 7,500.
engines and submitting bills Battery tester -1 No
Alternators regularly for works Multimeter -1 No
done provided for in Tong tester -1 No
the contract. Their
office should have
sufficient estimate
submitting tenders in
an intelligent manner
and for supervision
and works.
Page: 64
1 2 3 4 5 6 7 8 9
Diesel III Within the Rs. 20 Three works Banker’s Diploma holder (E/M) General
Generating Respective lakhs Of not less then certificate -1 No Category
Sets (D.G Zone of Rs. 8 lakhs of Rs.20 lakhs Rs. 5,000
SETS) DoP: Each and each Note:
Work shall Firm desiring enlistment
By CE of Involve D.G. In
the this class should have an
Concerned Engineering Officer
Zone of Sets of Capable
DoP. Capacity not Of preparing estimate and
Less than 100 Submitting bills regularly
KVA For work done provided
for
In the contractor. Their
officer should have APST
sufficient technical Category
personal for preparing
estimates and submitting Rs. 4,000
traders in an intelligent
manner and for
supervision of works.
Page: 65
Past
Category Class Jurisdiction & Tendering Experience Financial Engineer’s T &P Enlistment
Enlistment limit of Soundness Establishment Machinery Processing
Authority Completed Fee
Works in last
5
years
1 2 3 4 5 6 7 8 9
Electrical I Whole of Rs. 2 Three works General Graduate Phase sequence General
Sub Arunachal Crores Of not less Category Engineer (E/M) Indicator -1 No Category
Stations Pradesh; Then Rs. 50 Banker’s having an Primary and Rs. 10,000
Lakhs Certificate Experience of Secondary injection
Each Of Rs. 2 not less than five Equipment -1 No
By designated involving Crores years in the trade HT 5000 Meggar -1 No
Chief Engineer Transformer -1No LT 1000 V
Of Department Capacity of APST Meggar -1 No APST
Of power. Not Category And Diploma Hydraulic and hand Category
Note: Less than Banker’s (E/M) qualified operated
Registered 1000 Certificate Engineer, with Crimping tools -1 No Rs. 7,500
Officer of KVA in each of Rs. not less than five Dielectric strength testing
Contractor has work out of 1.50 years experience Equipment - 1 No
to which one crores In the design, Portable Welding
Be in the same should be dry Erection testing Machine - 1 No
area type and Portable drilling
As jurisdiction transformer commissioning Machine - 1 No
for tendering of and vacuum of Earth tester - 1 No
Class and circuit Sub-Station
Category in breaker -1 No
Which
Enlistment is
Sought.
Page: 66
1 2 3 4 5 6 7 8 9
Electrical II Whole of the Rs. 60 Three works General Graduate Phase sequence General
Sub States; Lakhs of Category Engineer(E/M) Indicator -1 No Category
Stations not less then Banker’s having an Primary and Secondary Rs. 10,000
by designated Rs. 15 lakhs certificate experience of injection
CE of DoP. each involving of Rs. not less than two equipment -1 No
transformer 60 lakhs Years in the HT 5000 Meggar -1 No
capacity of trade -1No LT 1000 V Meggar -1No APST
not APST Hydraulic and hand Category
Less than 500 Category operated Rs. 7,500
KVA in each Banker’s And Diploma Crimping tools -1 set
work certificate (E/M) qualified Dielectric strength
Rs. Engineer, with testing
45 lakhs not less than Equipment - 1 No
five years Portable Welding
experience Machine - 1 No
in the erection. Portable drilling
testing and Machine - 1 No
commissioning Earth tester - 1 No
of Sub-Station Tong tester - 1 No
-1 No
General General
Category Category
Electrical III Within the Rs. Three works Banker’s Diploma Phase sequence Rs. 5,000
Sub Respective 20 of Certificate Holder (E/M) Indicator -1 No
Stations Zone of DoP; lakhs Rs. 5 lakhs Of Rs.20 -1 No Primary and Secondary
BY CE of the each involving lakhs Injection Equipment -1
Concerned transformer No APST
Zone of DoP. HT 5000 Meggar -1 No Category
Rs. 4,000
Page: 67
1 2 3 4 5 6 7 8 9
Capacity of APST LT 1000 V Meggar- 1 No
Not Category Hydraulic and operation
Less than Banker’s Crimping tools - 1 set
200 Certificate Dielectric strength testing
KVA Of Rs. 2 Equipment - 1 No
lakh Portable welding
Machine - 1 No
Portable drilling
Machine - 1 No
Earth tester - 1 No
Tong tester - 1 No
Page: 68
Past
Jurisdiction & Tendering Experience of Financial Engineer’s T&P Enlistment
Category Class Enlistment Limit Completed Soundness Establishment Machinery Processing
Authority Works in last 5
years
1 2 3 4 5 6 7 8 9
Lifts/ I Whole of Rs. 2 Three works General Graduate General
Elevators Arunachal crore Of Category Engineer (E/M) Category
Pradesh; not less then Banker’s Having an Rs. 10,000
Rs. 60 lakhs Certificate Experience of
By designated Each. The of not less then
Chief Engineer firms should be Rs. 2 Three years in the
Of department original Crores Trade
Of power. manufacturing - 1 No
on the date of And Diploma
Note: application APST (E/M) qualified APST
Registered and Category Engineer, with Category
Officer of should be Banker’s not less than Rs. 7,500
Contractor has to maintaining at Certificate seven years
Be in the same less 100 lifts of Experience
Area as satisfactorily Rs. 1.50 In the design.
Jurisdiction for and should crore Erection testing
Tendering of have And
Class and maintaining Commissioning
Category in centres at least Of lifts/
Which at 10 locations Elevators/
Enlistment is In India. Escalators
Sought. - 1 No.
Page: 69
Past
Category Class Jurisdiction & Tendering Experience of Financial Engineer’s T&P Enlistment
Enlistment limit Completed Soundness Establishment Machinery Processing
Authority Works in last 5
years
1 2 3 4 5 6 7 8 9
Firm I Whole of Rs. 1 Three works General Graduate Chase cutting machine - 1 General
Alarm Arunachal Crore. Of Category Engineer (E/M) No Category
System Pradesh; Not less than Banker’s Having an Wire drawing Rs. 10,000
Rs. 25 lakhs Certificate Experience of Equipment - 1 No
By designated each of fire Of Rs.1 not less then Multi meter - 1 No
Chief Engineer Alarm System Crore Three years in LT 500 V meggar - 1 No
Of department Works out of the Battery tester - 1 No
Of power. Which one Trade -1 No Hand operation
Should be of APST Crimping tools - 1 No
Note: Addressable Category
Registered Firm Alarm Banker’s And Diploma
Officer of System. Certificate (E/M) qualified APST
Contractor has of Engineer, with Category
to Rs. 75 lakhs not less than Rs. 7,500
Be in the same seven years
Area as Experience
Jurisdiction for In the design.
Tendering of Erection testing
Class and And
Category in Commissioning
Which Of Fire Alarm
Enlistment is System - 1 No
Sought.
Page: 70
Past
Category Class Jurisdiction & Tendering Experience of Financial Engineer’s T&P Enlistment
Enlistment limit Completed Soundness Establishment Machinery Processing
Authority Works in last 5
years
1 2 3 4 5 6 7 8 9
Fire I Whole of Rs. 2 Crore Three works General Graduate LT Meggar General
Fighting Arunachal of Category Engineer (E/M) 1000 V -1 No Category
System Pradesh; not less than Banker’s having an Gas welding Rs. 10,000
(Water Rs. 50 lakhs Certificate experience of machine -1 No
Based by designated Each of fire of Rs.2 not less then Hydraulic pressure
Wet riser Chief Engineer fighting Crore three years in testing
& of department System the equipment -1No
Sprinkler) of power. Works Trade -1 No
APST Magnetic dial
Note: Category Indicator - 1No
Registered Banker’s and Diploma Hand operator
Officer of Certificate (E/M) qualified Crimping tool -1No APST
Contractor has of Engineer, with Multi meter -1 No Category
to Rs. 1.50 not less than Battery tester -1No Rs. 7,500
Be in the same crore five years Portable electric
Area as Experience In welding
Jurisdiction for the design. Machine -1No
Tendering of Erection testing
Class and And
Category in Commissioning
Which Of Fire fighting
Enlistment is System
Sought. - 1 No
Page: 71
1 2 3 4 5 6 7 8 9
Fire II Whole of Rs. 30 Three works Banker’s Graduate Chase cutting General
Alarm Arunachal lakh Of Certificate Engineer (E/M) Machine - 1 No Category
System Pradesh; not less than of Rs.30 having an Wire drawing Rs. 5,000
Rs. 10 lakhs lakhs experience of Equipment - 1 No
By designated each of fire not less then Multi meter - 1 No
Chief Engineer Alarm System Three years in LT 500 V meggar - 1 No
of DoP. Works. the Battery tester - 1 No
Trade -1 No Hand operation
Crimping tools - 1 No
Or Diploma
(E/M) qualified APST
Engineer, with Category
not less than Rs. 4,000
five years
Experience In
the design.
Erection testing
And
Commissioning
Of Fire Alarm
System
- 1 No
Page: 72
1 2 3 4 5 6 7 8 9
General Graduate General
Category Engineer (E/M) Category
Fire II Whole of Rs. 60 lakhs Three Banker’s Having an LT 500 V Meggar- 1No Rs. 10,000
Fighting Arunachal works Certificate Experience of Gas cutting and
System Pradesh; Of Of Rs.60 not less then welding machine -1 No
(Water not less lakhs Two years in the Hydraulic pressure
Based By than Trade Testing
Wet riser designated -1 No Equipment -1 No APST
& CE of DoP. APST Magnetic dial Category
Sprinkler) Category Or Diploma Indicator -1 No Rs. 7,500/-
Banker’s (E/M) qualified Hand operator crimping
Rs. 15 lakhs certificate Engineer, with tools -1 No
Each of of not less than five Multi meter -1 No
firefighting Rs. 45 lakhs years Battery tester - 1No
System Experience In the Portable electric
Works. design. Welding machine -1 No
Erection testing
And
Commissioning
Of Fire Fighting
System - 1 No